Ford - Explorer :: 2002 - Shudder In First Gear / Truck Shifts Into 4wd By Itself And Stays There After New TCM
Replaced the 2002 ford explorer 4x4 traction control module because of a shudder in first gear. With the new module the shudder disappeared but now the truck shifts into 4wd by itself and stays there. I am now on my 2nd new module because I returned the first one thinking it was defective.
If I cycle the 4x4 high switch and the 4x4 auto switch, the truck switches back int 2wd but on for a moment then goes back into 4wd. I don't get a 4x4high indicator light but I can hear and feel it is in 4wd. Almost like it thinks the truck needs work with the traction. I have now disconnected the module completely and the trucks runs/shifts beautifully in 2wd. I know my transmission is good. BTW, I have no trouble codes.
Do I have a bad speed sensor somewhere? and How do I trouble shoot for it?
Ford - Explorer :: 2003 - Rear Axle Shudder When Turning Either Direction From A Stop
I own a 2003 Explorer, 4.0 v6, w/93k. When turning either direction from a stop I get a shudder from the rear end. Ford has issue tsb # 17717 but I cannot fix the fix, only a description of the problem. Where can I find a fix I wondered?
View 2 RepliesFord - Explorer :: 1998 - High Pitched Whine Type Noise Coming From Mass Airflow Sensor
There's a high pitched whine type noise coming from my Mass Airflow Sensor. I can get it to go away temporarily if I goose the gas pedal, but it comes back after a minute or two. Has not affected drive-ability, but it's pretty annoying. It sounds like the hot wire is probably vibrating. Is there any fix for it, or do I have to replace the sensor to get rid of it?? Have tried cleaning it, but that did not work.
View 6 RepliesPassat (B5) :: Whine When Turning Coming From Just In Front Of Pedals?
new water pump and tensioner pulley, power steering hoses have been tightened yet still making this whine. It did stop for a while after i topped up the p/s reservoir but its fallen below the required amount again and garage has apparently tightened the hoses so shouldn't be leaking.
Don't know if its relevant or not but when i make a left turn and begin to straighten up I hear a clunk sound (sounds like coming from just in front of pedals, not 100%)
Ford 7.3L Power Stroke (1999-2003) :: Steering Will Whine Only In The Morning When Pull Out Of The Driveway
So when driving my tuck the steering on it would sorta lock up like it wanted to push the truck to one side then it would free up and the steering would be real loose it just felt like it had no power steering to one side it's not the same side each time and it pulses when I'm at a stop if I move the the tires Erving the motor doesn't seem to work so far I have replaced ball joints and all tie rods they needed done anyways it would still do it got an alignment done last week and it almost seems worse now could just be coincidence.
I'm thinking power steering pump but when the steering locks up to one side I'm also wondering if it's the steering box it's kinda hard to explain it what's going on and there is no popping noise or anything when the steering frees up. It's kinda scary on the freeway when I go around a corner the steering gets real loose and wonders back and forth not all the time but quit a bit but when going strait it will feel like it wants to pull to one side then the steering will loosen up again. The steering will wine only first thing in the morning when I pull out of the driveway then it's fine
Ford F-150 - 1997-2003 :: Tranny Shudder In OD Doing About 20 - 35 Mph
I have an 01 4x4 Ext cab with the 5.4 auto. It just started to shudder in drive doing about 20-35 mph, it quit when I turned the OD off and has not come back yet. It also jumps in and out of OD while running highway speeds, kind of like hitting a bump or something like it. The shudder was in about 10 degree temps and not fully warmed up and the jump happens whenever I am at speeds around 60-75.
View 7 RepliesFord 6.0L Power Stroke Diesel :: 2006 - In Tow Mode Tranny Clunk And Shudder?
2006 long bed with LS diff sometimes gets a fairly robust CLUNK! sound and feel when decelerating with tow mode engaged. It only happens once per 20 trips and only about a mile down the road, and it only happens once in a blue moon. It definitely is the rear end making the noise and brief shudder. Otherwise the truck runs extremely well.
I had the pumpkin off and fluid changed with Ford friction modifier added at about 100,000 miles. Truck is at 160,000 now. I just got done with a trip in the mountains of Idaho carrying a truck camper and used tow/haul mode extensively for engine braking and climbing, worked like a champ. This was just one trip of many this summer. This is about the only thing wrong that happens on my truck, but usually occurs before I get very far from the house. Should I just forget about it?
Ford - Explorer :: Squeak Coming From Rear Passenger Side When Turning Left
I can usually track these down, but this one is eluding me. It seems to be coming from the rear passenger side and really only bad when turning left or veering left at slow speeds.
View 11 RepliesFord F-150 (2009-2014) :: 2012 FX4 Shake And Shudder In Tranny Driveshaft Passing Through 1500 RPM
I've got a 12 FX4 SC 6.5' w/Ecoboost. After 1K miles I began to develop a shudder/shake in the tranny-driveshaft passing through 1500 rpm. 4 dealers, 6 overnights and 2 escalations, I finally am told there is a design problem in the pre Jan 12 trucks. Fixed with frame mod to manufacturing process after Jan, but no solution for current owners with the problem. I replaced my 07 FX4 SC with this truck and loved it for the first 1K miles. Now I hate driving it, especially in traffic (lots of cycles through 1500 rpm).
View 5 RepliesFord Transmission :: 2007 E350 - Shudder When Accelerating In OD - Whine In Park / Neutral
Looking for your collective expertise
2007 E350 with 5.4L and 4R70W trans. 107K miles and the fluid has probably never been changed ( my mistake - thought it was 100K interval - finding out from my reading that is def not true ). Anyway, following is recent development (last couple days):
Symptom #1: In Park/Neutral there is a whine. As soon as you put it in P or N, the whine 'spins up', stabilizes, and does increase with engine RPM.
Symptom #2: Hesitation (albeit minor) when starting from stop in D and R, with _very_ minor shudder. Sometimes feels like it's struggling a bit to move its own weight just until it's rolling.
Symptom #3: Shudder when accelerating in OD. No shudder when I turn off OD. It does not stop when applying brakes (a test suggested elsewhere). Also, the shudder does not happen when applying gas while braked in D at standstill. Only at highway speeds (enough to be in OD).
This all started at the end of a trip (90 miles or so in 85-90 degrees) when I was pulling a utility trailer (maybe 2000 lbs loaded). Not sure if related, but traction control warning went off a couple times. I think I have a axle seal leak that may be triggering that.
Otherwise shifts fine (no change in shift behavior or smoothness). Things seem to be worse when it has heated up. Should I start with a fluid change? Wasn't sure because there are comments out there saying don't do it or the tranny will just fail faster (I am skeptical).
Ford - Explorer :: Moving By Itself When Parked In Leveled Driveway
I have a 98 Ford Explorer, on a few occasions i have parked my car in my driveway which is level the next morning i come out and the car has moved about 4 foot. Its an automatic, what would cos this to happen with nobody in the car and it's in park???
View 5 RepliesFord - F150 :: Shaking When Truck Pulled Out Of Driveway And Began Acceleration
Purchased a 2000 F150 (over 200,000 miles) from a company fleet. The truck is not driven on a daily basis, only when needed to haul something to land field. One morning I had to drive the truck. When I pulled out of the driveway and began acceleration the truck began to shake violently. After some experimentation I came to the following conclusion. The vehicle starts to shake when a speed of 45 mph reached.
If I try to hold the speed between 45-55 mph the shaking continues. If I let off of the accelerator, the shaking stops, if I accelerate thru 45, the shaking stops. The shaking is not from wheels, rotors, axle etc. The check engine lite also came on during this time. When the shaking starts, if I attempt to accelerate, the truck looses power briefly then picks up. I didn't pay alot for the truck and really don't know how much I am willing to put into it. If it doesn't cost alot would like to keep the truck running.
Ford F-150 (2004-2008) :: Truck Won't Roll After Backing Trailer Up Steep Driveway
After returning from about a 5 hr roadtrip, I backed my snowmobile trailer up my steep driveway in 4wd and the truck did not want to move after that. The truck is an '05 SCREW 4X4 5.4L with about 110,000 miles on it. Trailer is probably around 1,000 lbs with the snowmobile on it.
The driveway is steep and short. That combined with the 90 degree turn to get in and some uneven terrain and part the path onto slippery frozen grass makes for a bit of a rodeo trip backwards up the driveway with a trailer.
Anyway, after getting the trailer up into it's place, I unhooked it, switched back to 2wd, disengaged the parking brake, and put it into drive. The truck didn't roll which was weird as it's now in drive pointed down hill. With about 1/4 - 1/3 throttle, it crept forward. Again, this is down hill. I got out walked around the truck (make sure I didn't forget to unhook anything etc) and tried again. Same thing.
Once I made it to the fairly level street, the truck would still only move, barely, with about 1/4 - 1/3 throttle. Now it was like some of the wheels were free but at least one had to break traction with the pavement to allow the truck to move forward. So with constant pressure on the accelerator it would chirp one or more of the wheels a bit at a time as it crept forward. Acted like it was in some sort of imaginary tug of war. After about 40' of driving it worked itself out. I've driven about 10 miles since and seems just fine.
I'm concerned because I plan to do this frequently with this trailer and in the summer frequently with a boat weighing about 3,500 lbs although shouldn't need 4wd in the summer.
Ford F-150 (2009-2014) :: Transmission Leak - Drip And Run Stain Under The Truck On Driveway
I have an 09 screw, 4.6 3v, 3.55, 2wd. Last week, I noticed on the driveway a drip and run stain under the truck. I dismissed it as ac runoff. But it remained and lengthened. I got under it yesterday, and the tranny crossmember has fluid on it. I can't pinpoint where it is coming from. There was no drip either, and the truck was relatively cool. Of course there is no tranny fluid dipstick to check and the tranny pan is intact. It seems to be behind the transmission towards the driveshaft.
View 14 RepliesFord - Explorer :: 1997 - Tranny Swap - AWD To 2WD?
I have found a 97 explorer 4x4 with a v6 and auto trans priced really cheap. It has something called control track on it. Everything is in real good shape except the trans. It only works in reverse. Is there a common failure on these trans that might cause this ? from what Ive read this is a awd set up. that's is 4wd -all the time. If the trans is a major repair I would rather do away with the awd and convert to a simpler 2wd. Would such a swap be advisable ? I m wondering about wiring harnesses, sensors, cars computer, etc.
View 1 RepliesFord 6.7L Power Stroke Diesel :: Smelling Exhaust Fumes In Cab Of Truck When At A Stoplight Or Parked In Driveway
Recently I have been smelling exhaust fumes in the cab of my truck when at a stoplight or parked in the driveway. When driving, the smell tends to go away. This occurs with the windows up and the climate control on auto. I can also smell this when I shut down the truck and exit. I am looking for anything that may be causing this. Hoping not to have to take it to the dealer.
View 14 RepliesFord - Explorer :: Low On Fluid - Tranny Or Transfer Case?
My 4WD sport trac was running fine. I took it off road and put it in 4WD. After I was done in the woods. I put it back into 2WD and backed up to unlock. I then drove 2 hours home. The next day the transmission started shifting funny, especially overdrive almost like I was low on fluid. (which I check and I'm not) And the truck sounds like its running ruff. Is my transfer case still ingaged? Do I need to take it in for tranny work?
View 9 RepliesFord - Explorer :: 2004 4X4 - Slight Whine At 55 MPH
I recently had to sell my 1990 Ford Bronco (hence my name) because it failed emissions six times and I gave up. I bought a 2004 Explorer 4X4 with 93K. I am very happy with my new truck. It is very clean and looks like new. I only noticed one thing - a slight whine from the rear end at 55 mph when I am on the gas. It doesn't really sound like a bearing. I read somewhere that Ford put a lighter weight gear oil in the diffs to increase fuel economy, and if you put in a heavier grade then the whine will go away. Is this true? If so, what should I use? The whine is barely noticeable and doesn't bother me, but if it could be eliminated easily by changing the oil I'd do it. I also read that someone did this and a week later the diff blew up. I'd rather have a very slight whine than a diff blowing up! What should I do here?
View 14 RepliesFord - Explorer :: 2003 Whine At Rear End Between 50 To 65 MPH
I have a 2003 explorer with 6000 original miles, the truck was only used to go to the corner store by my past in laws, the tires which I have just replaced were the original Michelin with the date code 0303, the problem I am having is a fairly loud whine/hum during acceleration between 50mph and 65mph, I live in the Florida keys and trust worth mechanics are far and few between so I brought it to my Ford dealer which I buy body parts from all the time, after a test drive the service adviser said that they will have to remove the pumpkin put it on the bench and inspect it, I said ok, they called me back into the shop and showed me the unit, the tech said that I had metal filings in the unit and it was out of alignment, I saw the filings, which included the ring, pinion all inner bearings, the two outer shaft bearings and the two dust seals and oil, I verified this and the price seams to be right....my question is the labor they want to charge me 8 hrs to do the work. The rear end is a 355, not Limited and not traction.
View 3 Replies