Ford F-150 (2009-2014) :: 2012 - Shudder And Thunk While Accelerating?
In june of 2014 I purchased a 2012 F150 Harley Edition with the 6.2 for my wife to use as a daily driver. I told her that she could have any vehicle she wanted and she chose the White Harley Truck.
It is a Ford Certified Pre Owned and we took delivery with about 30,000 miles on the odometer.
From the test drive in June 2014 until today the truck has had two distinct issues with the rear end and suspension:
1. After coming to a normal stop (at a light) when you start to accelerate (on green) there is a distinct thunk that is heard and felt. Having owned other vehicles with a slip yoke drive shaft I knew right away that the slip yoke needed to be cleaned and lubricated and that is how the dealer repaired this issue. The repair lasted about 10,000 miles and the thunk started again recently.
2. Also after coming to a normal stop and then accelerating there is a vibration felt until the mass of the truck is moving along at about 20 MPH. It's not a vibration like a wheel/tire is out of balance it's more like the whole vehicle is shaking similar to the Space Shuttle Experience ride at the Kennedy Space Center. The shudder is severe enough that my elderly neighbors asked if the truck "was going to make it without falling apart" when my wife and I took them to dinner one evening. The Shudder is exponentially worse when towing any kind of trailer. I have a tandem axle car hauler to haul a 1992 Jeep YJ to various events and the whole setup might weigh 5000 LBS max which is well under the tow capacity of the truck. To say the shaking is violent is putting it lightly.
When I took it in for service, the dealer told me that it was my fault for riding around with the locking differential locked. I told them nice try and that I know what a locking diff is and how to use it because I have two of them in my Jeep. I then took the service advisor for a ride, made him verify the diff is off and demonstrated the problem without even leaving the parking lot. At that point he acknowledged the condition I left the vehicle with him again. The repair the dealer made was to change the rear differential fluid and called me to say the truck was ready.
I drove back to the dealer again (35 minutes in light traffic) where I was presented with the vehicle. I didn't have to leave the lot before I knew it still was not fixed and pulled back into the service lane. I was greeted by the advisor who then proceeded to tell me it was "characteristic of the vehicle." I was completely frustrated and took my truck with it's "characteristic" shudder home.
Ford F-150 (2009-2014) :: 2012 - Shudder Feels Like Transmission Slipping When Mash The Go Pedal
I purchased my 2012 EB used with 35k miles on it. at about 42k I had the condensation issue happen when passing several RV's in a mountain pass. I took the truck to the dealer I purchased it from and they did the TSB13-8-1 Fix to it. I noticed right away that I had lost some power (I was very saddened).
I also have Noticed that I lost about 2.5-3 MPG. Since the work was done I still have a shudder that feels a lot like the transmission is slipping when I mash the go peddle. this does not happen every time but I would say it does happen better then 50% of the time at highway speeds trying to pass slower rigs or getting up to speed to enter the highway.
My question is has ford updated the TSB's for the 2012 EB F150's lately? I love this Truck, it is the only vehicle (besides my motorcycle) I have owned to date that I was not tired of after about 6 month's. I hope when I take the truck back to the shop next week that there is a fix that works that I get my MPG's and power back and that lets me drive it the way it should be driven.
Ford F-150 (2009-2014) :: 2005 5.4L - No Passing Power
I have a 2005 F150 5.4 L 4 speed Tran. and a identical 2010 F150 5.4L but with a 5 speed Tran. that I just bought. it seems to have no passing power. I reset the PCM driver adaptive memory and the truck does not seem to have any pick up as compared to my 2005. Could it be the throttle body position sensor or something else.
2005 has over 200k
2010 has 80k
both are extended cab 4X4
Ford F-150 (2009-2014) :: Lost Takeoff And Passing Power?
I have 163,000 + on my 2009 fx4. Recently I have lost my take off power and passing power. I have the manifold leak but the dealership says that's not the problem. Took it in twice to the dealership and once to an independent and nobody knows what's wrong. No codes are showing. Had a dealership tune-up at about 120,000 miles. Need some starting points cause it's very annoying and unsafe. I tow alot and the "get up and go" is gone.
View 3 RepliesCamry 2012+ :: Front Passenger Seat Seems To Shake / Shudder A Lot - Squeaky Center Dash
I have a 2012 Camry SE and my front passenger seat seems to shake/shudder alot. It constantly shudders and makes so much noise when no one is sitting in it, that it's driving me crazy! I can't tolerate the noise of it. If I go over a bump it shudders, if i'm driving on a rough highway, it shudders and shakes so badly that I have to put my hand on it to make it stop. It makes squeaky noises as well. It doesn't happen when driving on smooth surface.
Secondly, the center dash is very squeaky, and made out of hard plastic. I feel there is no insulation behind, and thus it squeaks whenever I go over a bump. What steps did you take to resolve it?
Ford F-150 - 1997-2003 :: By Passing The Tranny Cooler On Radiator?
I have an 03 f150 supercrew that had a 4.6L. I am installing a 3.9 Cummins diesel. I will have a separately mounted transmission cooler. I'm using the stock radiator as these engines run cool. It has a transmission cooler built into it. If i just leave the fitting loose, will it cause me any problems. It is a plastic can on each end and i suppose it to have contact with the radiator passages.
View 7 RepliesFord F-150 (2009-2014) :: 2010 - Bad Bed Shake On Small Bumps
I just picked up a 2010 f150 xtr 4x4 few weeks ago and I notice the bed shake is pretty bad when hitting small bumps int he road. I watch in my rear view mirror and it seems the drivers side is doing all the shaking, and the passenger side of the box seems solid (minimal movement like a truck should). It only shakes on bumps and does not increase with speed or anything so im assuming its Not my tires? I can literally feel the shaking in my feet in sync as i watch the box rattle in my rear view. Also look at my passenger seat and it looks like a vibrating chair, an extreme one.
I got under the truck everything looks solid, checked all the bed bolts are tight, i honestly have no clue at this point. I use to have a 2000 ranger and honestly I find the box shake on my new 2010 is just as bad as my old truck. My brother and cousin both have 2011 f150's and i find theres to ride alot nicer than mine. My truck is a supercab and theirs are crew cabs, however i don't see it making that big of a difference in ride? Checked tire pressures i have 30lbs in the back tires and 35 in the front. Like it said its only on bumps, doesn't start shaking on a smooth road, so im expecting some sort of bad suspension component?
trucks a 2010 f150 xtr 4x4 supercab with 18" wheels
Ford 6.7L Power Stroke Diesel :: Driveshaft Shudder With Goose Neck - Airbag?
So I picked up a 53' for the racecar. When I'm hauling it on take off I'm getting a pretty good shutter out of the truck. My crew chief who owns a maintenance shop, said it's a known issue, and ford has been shimming the drive shafts.
I talked to the service writer at my dealership and he said it's a known issue and they are working on it. However, he said if they shim the driveshaft, there is a good chance it could fix the problem loaded, but then unloaded I'd have the problem. Is there a setup that's recommended?
I'm towing about 15k, but that's far from the limit of my 450.
Ford F-150 (2009-2014) :: Takeoff And 55 MPH Shudder
Been suffering some take off shudder as well as the 55mph shudder and finally took the truck into the dealer who informed me it is throwing a couple of misfire codes (no CEL). Quoted for spark plugs. Looking around the boards, seems a lot of people are seeing premature wear on the ecoboost plugs and have had success regapping or replacing. Any words from 5.0L owners? What are the odds they just need regapped? I'll probably just replace them anyway, but its a good discussion. Also are they are simple to replace as it looks- just pop the coil packs off and they are there in the valve covers?
View 14 RepliesFord F-150 (2009-2014) :: Where Is The Auto Tranny Dipstick
F150 2011 3.5L Ecoboost. Where is the transmission dipstick?
View 14 RepliesChevrolet - 1500 :: 2012 - On Hills Water Temp Gauge Goes 2 / 3 And Tranny Temp At 200 - 210 Degree?
I have a 2012 Crew cab Silverado 5.3 V8 with the towing package. When I pull my travel trailer (approx. 5000 lbs), the water temp stays 1/2 guage and the tranny temp is 170-190, however, on steep hills the water temp guage goes 2/3 to 3/4 guage for a short time and the tranny temp reaches 200-210 degrees. Is the elevated water and tranny temps okay or should I try to reduce them back to the normal range. What is the max temp I should keep the tranny at?
View 9 RepliesFord F-150 (2009-2014) :: 2011 - Shudder Over Bumper?
I bought a 2011 F-150 a year ago. Today was I driving my truck like usual and for some odd reason, it revved up to 3500 and then my truck shooked like I hit a big pump. I'm debating whether I have a faulty transmission or something. I barely touched the foot pedal. I wasn't evening barely putting any pressure on the accelerator and for some odd reason, it revved up that high and something shook my truck. I know a little bit about vehicles, my transmissions are not my thing. I'm gonna' take it in Monday morning to work.
View 1 RepliesFord F-150 (2009-2014) :: 2010 - With A/C On Shudder At Idle?
Just pick up a 2010 FX4 with the 5.4. Noticed at idle with the A/C on 75% of the time my truck is shuddering at idle. If i turn the A/C off it goes away. Common sense is that i know the the A/C draws a lot from the engine but have a shudder like that? The P/O's ESP transferred to me so i can take it in if need be.
View 13 RepliesFord F-150 (2009-2014) :: Shudder When Come To A Stop While In 1st Gear
Extended cab ecoboost 2x4. Shudders as I come to a stop while in 1st gear. Feels like it's something to do with the transmission. Haven't taken it in yet. Not towing/hauling.
View 3 RepliesFord F-150 (2009-2014) :: Shudder In 2nd Gear Low Speed
New start for an old problem. 2010, F-150, 5.4, 5.5' bed. Truck is new to me, used 105K miles. Love the truck, got it to tow TT I was having trouble towing with a shorter wheel base vehicle. Has HD towing package, tows great, good power, stable. First trip out with the TT the ole Shudder in 2nd gear low speed reared it's ugly head. I did do the slip joint re-lube with Ford wonder grease.
View 7 RepliesFord F-150 (2009-2014) :: Tranny Slipping When Pulling Trailer
I have a 2012 Ford 4x4 crew cab 150 xlt. 15,000 miles. When pulling my dump trailer I was stopping to turn and the transmission disengaged. Once I turned the corner coasting the transmission kicked back in again. During this happening pushing the gas did nothing but rev up engine. My dealer said if this happened that a warning light would of came on or a wrench would appear on dash but it didn't. He said then it didn't happen. This happened 3 times in 10 miles of driving. I had it in tow mode.
View 4 RepliesFord F-150 (2009-2014) :: 2010 - Shudder Downshifting From 2nd To 1st When Stopping
2010 F150 5.4, 6 speed... I am fast approaching the end for the factory 60,000 mile drive line warranty. I have had the slow speed 0-2 miles per hour shudder since 3,000 miles. The shudder downshifting from 2nd to 1st when stopping. As well as the highway shudder when gradually accelerating above 55 mph (empty and loaded)
The dealer that I purchased the truck from has driven with me several times and experienced the problems. They reflashed the computer at 5,000 miles. it made the shudder frequency double. i.e., twice as rapid. Reflashed again with no change.
I finally called Ford Motor Company, and they were surprised that I had not filed a complaint earlier. They followed up with the dealer.....who's service dept opted not to work on the vehicle again. I am now working with another dealer, and will be starting from scratch.
Long story short. I see that some have replaced torque converters, transmissions, clutch plates, valve bodies, and on and on....
Ford F-150 (2009-2014) :: 5.0L Torque Converter Shudder / Vibration
Been doing a lot of reading about shudder/vibration on the 2011+ F150's and it seems to all center around the two piece driveshaft found on the longer wheelbases and more during take-off than other times. I have an '11 5.0L 4x4/auto with the 145 wheelbase and the 1-piece aluminum driveshaft and am experiencing a shudder in 3rd gear primarily, most noticeable during light acceleration with medium load (like gently accelerating up a slight incline).
When this is occurring I can see the tach needle fluctuating just slightly (maybe 50-150rpms, just barely bouncing) but I have no check engine light and the only time I have take-off shudder is under hard acceleration which feels like axle hop (which isn't too rare on soft leaf springs with 360hp engines!).
Anyways, this 3rd gear shudder is very soft and nobody has noticed it that has rode in the truck with me, but it sure feels like the old AODE/4R70W trans would when the fluid was getting old and the TC started to shudder during "soft" lock. 5.0L? Certainly could be a miss, though power is good, mileage is great and no CEL is lit...
Ford F-150 (2009-2014) :: Trans Slamming / Shudder / Random Misfires
Well, just picked the truck up from the dealer. Had to pay for the shudder diagnosis which turned up a #8 misfire as well as lesser random misfires on the mode 6 test (no CEL) since it out of B2B warranty. Also brought up the transmission issue I have been having. Virtually every morning when I go to pull out of the driveway, when I put the truck in park it was quite violently slamming into gear, even if I let it idle long enough to drop the neutral RPM's.
Service writer was a bit baffled, but after touching base with their driveline technician, and verifying it was in no way similar to how any other F150 engages they were able to locate TSB 11-11-11 which, to me, seems primarily concerned with the harsh 1-2 and 2-3 shifting but also noted the harsh engagement.
Anyways, they squeezed me in over night and in 2 days had my parts in and installed (apparently on these trucks they have to physically get the numbers off the solenoids to be replaced as there are a couple options). 3 solenoids tested bad and were replaced under the powertrain warranty. Truck did not slam when I picked it up, looking forward to testing tomorrow morning!
The best part is that when the tech went to drive the truck in this morning to start working it not only slammed into gear for him (verifying my concern) but it also demonstrated the violent 1-2 upshift. Too bad they couldn't push a spark plug through warranty, guess I'll have to wait for my Rockauto order to come in