Ford 6.0L Power Stroke Diesel :: Truck Will Crank Longer Than Normal When Parked
I have noticed that my truck will crank longer than normal when i park backed into my drive way but it only does it every now and then. I am guessing an internal oil leak but it starts fine cold or hot.
View 10 RepliesFord 6.7L Power Stroke Diesel :: Coolant Leak - Puddle Under The Truck After Parked
My good friend has a 2011 6.7 and has been dealing with a coolant leak for a few months. Dealership has had the rig a few times and said it passed " a pressure" test etc. and they see no issue, yet he finds a puddle under the truck when after it has been parked. How best to check it out? I'm not familiar with some of the common trouble spots on the 6.7 like I am with the 7.3.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Parked On Hill And Truck Started Sliding Down
Today I visited a buddy who lives on a pretty steep hill. I always set my E-brake while in Neutral to make sure it's holding the truck before sliding it into park. So I got out and unloaded a few things and was in his garage. I heard a skidding sound outside, I was about 40 feet away from it when I looked out my truck was skidding down the hill!
I ran out and to the drivers door, opened it and pressed on the brakes with left hand right when it hit the bottom of the hill and it barely stopped from hitting the blue car parked on bottom of the hill. Next time if I stop on this hill I'll make sure it''s nose up hill and make sure I have 4X4 engaged to have all wheels locked up. I know this probably happened because the lack of weight on the rear wheels but this was a pretty crazy scare with only 7800 miles on her!
You can see the skid marks from my rear wheels, my friend lives in the middle of the block.
Ford 6.7L Power Stroke Diesel :: Exhaust Smell So Bad When Truck Warming Up?
Got to thinking today while my truck was warming up, why does the exhaust smell so bad. I think it is kinda interesting that the exhaust pipe is so clean also, like new matter of fact.
So what make the exhaust smell? The exhaust filter traps the partials right but where did the diesel smell go? I can understand it when in regen but in normal operation I don't get it. I guess I just don't the mechanics behind it. All I do know is that, what is left just stinks especially when warming up.
Ford 6.7L Power Stroke Diesel :: 2012 - Exhaust Smell Coming From Truck - White Smoke
Today I drove to dinner in my 2012 6.7 with no problems then on the way home my brother said he noticed my truck was white smoking quite a bit and he said there was a very strong exhaust smell coming from my truck ( he was in his car behind me) I ran a diagnostic test and what came up was code P0401 (I believe that's right). Need to figure out what is going on with my truck before I take it to the mechanics and get charged up. The truck still has DPFs in it just has a DPF back exhaust and has a AFE cold air intake running on a stock tune. However I do have the DPF deletes and EGR delete sitting in my garage just haven't gotten them on the truck yet.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Diesel Fumes In Cab During Regen
On the way in to work this morning, I get the "Cleaning Exhaust Filter" message. This was great because I still had about 15 minutes of driving left and it usually comes on right when I am pulling into my driveway. As soon as the regen starts, I can smell diesel exhaust/fumes in the cab (this is going 70 mph on the freeway). When the regen was done, the smell went away. Is this normal? I could understand if I was sitting still getting some exhaust in the cab, but moving at full speed everything should be blowing away. This is my 4th or 5th regen and the first time I have noticed it.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Fumes In The Cab Once In A While
On occasion, not always, and after the truck has warmed up, some fumes enter the cab. If it happens when I pull into the garage and stop, the smell is noticeable on the outside also. Like I said, its not always present, only occasionally and at very slow speeds or when coming to a stop. I don't smell the fumes at speeds above 35 to 40 mph - I guess it simply blows by when traveling faster. Its difficult to describe what it smells like, but to me its like diesel exhaust fumes. But this is a 6.7L engine so there should be no diesel exhaust fumes - right?
So, having said all this, I took the truck into the dealer this past week for the 14E03 recall and asked them to also find the source of the fumes. When the service was completed, the service underwriter said I had a small leak from "one of the two" cooling lines under the turbo unit. I was asked to drive the truck and see if they fixed the problem. Since I'm a total rookie regarding diesel engines and turbo chargers, I would ask the members here if you have experienced this situations and what action was taken to resolve it. By the way, my 2011 truck as about 85,000 miles on it.
The following morning after driving a few miles, I noticed the smell again. As I drove on and thought about it, I was hoping the liquid that leaked during the service would fully burn off and that would be the end of it. Today while driving some 40 miles with several stop and goes, no fumes were present.
Ford - Focus :: 2001 - Smelling Gasoline Fumes Inside The Car
For weeks I've been smelling gasoline fumes inside the car, usually when the weather is cold and when the car has been sitting overnight; sometimes while it is idling. Have had to car to my mechanic, who I have confidence in and who has done a good job with repairs in the past. He could not locate the source of the fumes.
View 9 RepliesFord 6.0L Power Stroke Diesel :: Truck Sluggish When Stepped On Throttle - Huge Black Trail Out The Exhaust - P132b
Driving back from Baseball tonight, I stepped on the throttle truck was sluggish and a huge black trail out the exhaust. On and off the throttle a few times and no more smoke.
Checked codes when we got home and had p132b. I had this a month ago, replaced the map sensor and no issues. So am I looking at a turbo cleaning? Besides the unison ring, is there a seal and bearing kit? I am at 205k at this point and as far as I know the turbo is untouched.
Ford 7.3L Power Stroke (1999-2003) :: 2002 - Diesel Fumes Smell?
2002 Excursion 4x4 7.3 PSD 90,000 miles Hydra Tuner
the past few days I started smelling diesel fumes in the cab of my truck with bent on and also at the front of the truck when installing new bumper and winch. It's not real strong in the cab but pretty stout at the bumper. I have poped the hood and made a quick visual inspection and from underneath the only evidence of any leak is some power steering fluid which is a different issue (I think)
a week or 2 ago I was cleaning the Ex and noticed 2 or 3 drops of red fluid on the concrete under the Ex I crawled under and looked up and the steering knuckle was pretty wet. Popes the hood and took a look from the top and the power steering pump was sticky and dirty but the only fluid was on the top of the cap.. I'm not real familiar with the set up on the Ex but I have heard the PS support the break booster. From visual inspection it seems as though the fluid is coming they the small (vent?) hole on the cap. What I can/need to do to stop this?
Ford 6.0L Power Stroke Diesel :: Died In The Driveway?
AE shows 600+ ICP while cranking, 48.5v-49v ficm continuously, has sync, has 50 psi fuel with manual gauge, replaced fuel filters with Ford, fresh oil change, 2 new batteries, cleaned EGR, no codes.
Prior to this I changed the driver's side injectors because (before I had AE) Ford said it needed #8 (power balance) due to a stutter at minimal load at highway speed. Figured I'd change them all due to 290,000 miles. Had enough cash for 1 side this month. Ran great! Had AE hooked up and showed all good pressure, volts, temps then died in the driveway.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Oil Leak / Marks On Driveway
1st major problem on my 72,000 mile 2011 F350 is an oil leak that has gotten worse in a short time.. I've been putting it off as I can't be without my truck as I use it for my business but I have to take it in as its leaking pretty bad and leaving its mark on every driveway I pull into,going to take it in the morning to get diagnosed,going to have the exhaust smell in cab during regen looked at also as its been a problem for sometime time now but have just have delt with it till now. Here is a pic of the leak...
Where it may be coming from? Looks like its coming from the top side somewhere..
Ford 6.0L Power Stroke Diesel :: Randomly Shut Off When Pulling Into The Driveway - P0341 Code
A Little Background, my FICM wasn't bad per se but it would dip below 45 volts when the outside temp was around freezing. I pulled it and sent it for repair at the same time the Atlas 40 tune was loaded into the FICM.
First few days of driving mileage was better, truck ran great. All of a sudden one day pulling into the driveway it randomly shutoff. Two occasions since it has acted goofy at started, bucking a little a low throttle. Mileage has returned to how it was before I had the FICM fixed and ATLAS tune applied. To this point I had no codes at all.
Now today it randomly throws P0341 - Camshaft sensor out of range.
So heres the question - do I replace the sensor or try to get at the harness for inspection? Out of range would usually mean the sensor itself is failing while open circuit is usually wiring related. I know its uncommon for this particular sensor to fail but i'm not sure which direction to go.
Ford 6.0L Power Stroke Diesel :: 2004 F250 Stall After Start When Backing Out Of The Driveway
I have had literally no issues with my 2004 F250 Super Duty. Went out and started the truck like every other time for the past 13 years. Started backing out of the driveway and burped the throttle and it just quit??
I put back into park and it rolled over for about a minute and finally caught. When i put it back into gear i had zero throttle response. I have a NOx sensor fault code and and EGR fault code. I replaced the FICM 2 years ago.
Ford 6.7L Power Stroke Diesel :: Diesel Exhaust Fluid Reset?
I've topped up the DEF and the warning is still showing that I'll have reduced engine power within 45kms.
Its weird, just yesterday it showed 550kms to empty so I added one full container, all day it kept showing less and less kms' til empty. Warning lights and bells etc.
This evening topped it completely and still shows. Is there a way to reset it without having to stop at the service dept.
Ford 6.0L Power Stroke Diesel :: 2004 - Missing And Rough Idle After Sitting All Day In Rain - Parked
Truck (04 excursion, 2WD, early build 6.0, 160k) started missing and rough idle on way home from work after sitting all day in rain - parked. started fine in morning and drove to work with no trouble - it was raining over night too.
To get you up to speed. for a few weeks before had intermittent trouble starting. would fire up as normal, fast and loud, but then stall immediately (usually after sitting overnight). would start back up but with a little long on the key and some gas pedal action. only happen one out of ten or twenty starts and seemed to follow getting fuel in unknown locations while on a trip out of town. decided to change out fuel filters and drain separator. seemed to fix it for a week or so then it happened again two days before above event, while weather was dry. Not sure if related but only recent problem to speak of.
Back to current:
- no check engine light or codes (I have a scanner)
- stalled out close enough to home the night in question I rolled it into driveway and tried to start it while rolling in neutral - no start
- once parked in driveway also no start
- next evening wanted to get it into garage (to dry off) and it started but rough idle and missing. this was after 24 more hours sitting in rain.
- been in garage 24 more hours and this evening got it to run but same result (rough idle and hard start). tried to check connections (mainly FICM) and move wire loom around - still same.......
Where to check next, need some diagnostic...
Ford 7.3L Power Stroke (1999-2003) :: Replaced Heater Core Still Smelling Antifreeze?
replaced heater core because when pulling a trailer it would admit steam out the defrost vents and the smell of antifreeze, what it could be?
View 8 RepliesFord 6.0L Power Stroke Diesel :: Filled Up With Diesel And About A Hour Later The Truck Is Knocking And Idling Rough
Wtf is going on, Temps are all good, no check engine codes...bad diesel fuel? I had 1/4 tank of diesel fuel when I filled it up...
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Truck Act Like Going To Start And Black Smoke Coming Out From The Exhaust
I have a 2003 Superduty with 193k miles that is bone stock. I sold the truck to a friend and when he decided to not pay the remaining balance on the truck, I took back ownership. The truck was having heating issues and it set at a mechanic shop for nearly 2 years waiting for a diagnosis on the heating issue. Fast forward to the present and I now have the truck at my home. Heating issue was the radiator but this is no longer a concern. When I went to pick up the truck from the mechanic, the truck started fine. Every other day for the last 4-5 weeks I would start the truck with no problems.
I get the truck tagged and start driving it on a daily basis. I've put several hundred miles on it but the more I drive it, the less it wants to start. Now it's to a point where it only cranks but won't start. I can take a gas rag and hold it in the intake and eventually it will start. Once it's running, it runs great and has no issues starting. But once it sets for 3-4 hours, it won't start without some sort of assistance.
While trying to find the issue, I've found and repaired 2 fuel leaks and in the process I replaced fuel filter, air filter, replaced glow plug relay, replaced batteries, replaced CPS. Fuel pump is working fine. I've tried the ICP test and doesn't make a difference.
The glow plug light or WTS light works so don't think its the GP. The CES light was on. Had it scanned and it was the air bag sensor so no support from the CES.
While I was working on it yesterday and after cranking on it for 5-10 minutes, it would act like it was going to start and black smoke would be coming out from the exhaust. I let it set to cool the starter it fired up like it had no issues.