Ford F-150 - 1997-2003 :: 2003 4x4 - Tranny Doesn't Engage
I have a 03 4x4 5.4lt supcab with 154k miles. I replaced the shift motor about 40,000 ago but it has always been tempormental like I had to engage it in 4lo in N and then shift to 4hi to keep it in 4hi. Now fast forward to today. Went to shift to 4lo in N and it didn't shift. I only heard the relays click once and then it wouldn't shift into any gear even though the indicator was on PRND123. Didn't matter.
Also, Park didn't engage and the speedometer acted like it was engaged in RN and D. No movement what so ever. I think it might be the shift motor that shifted part way and is stuck in between gears. Is this possible? I drove fine to the dirt road and I haven't had problems other then the shift motor being touchy. I don't want to pay for a new tranny if it might be the shift motor.
Ford F-150 - 1997-2003 :: Auto Tranny Not Engaging
03 F150 2WD-I dropped tranny pan, changed filter, reassembled, put in 4 qts fluid. Checked dipstick, seemed to be overfilled, despite instructions to add 5 qts. Started truck, put it in reverse, went about 4 feet and then tranny wouldn't engage-ran it through all gears, just acts like in park or neutral. Over or Under filled???
View 4 RepliesFord F-150 - 1997-2003 :: 2000 - Changing Tranny Oil?
How much tranny oil it will take for just a pan drain and filter change, 2000 f 150, 7700, 4x4, 5-4....
View 3 RepliesFord F-150 - 1997-2003 :: By Passing The Tranny Cooler On Radiator?
I have an 03 f150 supercrew that had a 4.6L. I am installing a 3.9 Cummins diesel. I will have a separately mounted transmission cooler. I'm using the stock radiator as these engines run cool. It has a transmission cooler built into it. If i just leave the fitting loose, will it cause me any problems. It is a plastic can on each end and i suppose it to have contact with the radiator passages.
View 7 RepliesFord F-150 - 1997-2003 :: Rebuilt Tranny Shifts Hard When Going From 2nd To 3rd And 3rd To 4th
I just had my tranny rebuilt it doesn't shift hard all the time but it does from time to time going from 2nd -3rd and 3rd -4th I thought being new it may need to soak up some fluid so the bands can swell so I ask the shop that rebuilt it that question he said they soaked them as they rebuilt it so they should be swollen already then he proceeded to tell me it was electrical is he telling me the truth because the ck engine light isn't showing any faults and if it was electric shouldn't that have been fixed in the shop while it was being rebuilt if it was interior electronic?
View 1 RepliesFord F-150 - 1997-2003 :: Shake / Shudder When Accelerating Around 45 - 55 MPH
My trucks been doing something weird. When accelerating around 45-55 mph, a couple seconds after it shifts to 3rd, it does a weird type off shake/shudder. Feels like I hit a small bump in the road. Also when coming out of a cruise to accelerate, it will Make a very violent clunk and then speed up. I'm thinking it's a problem with my torque converter but my mechanic says transmission and my buddy says rear end lol. I dropped the pan and there was some shavings but nothing huge and it was the first time it was ever dropped. After 90k miles.
View 14 RepliesFord F-150 - 1997-2003 :: Tranny Fluid In Slip Yoke - Dissolve It?
I have the dreaded slip yoke clunk, I used the FORD SPEC PTFE lube and it works for a while until the tranny fluid that makes its way onto the slip yoke dissolves it!! Replacing the slip yoke with an updated one?
View 10 RepliesFord F-150 - 1997-2003 :: Tranny Fluid Behind Driver Side Tire
I have a 97 f150 4.6 and I recently noticed a lot of tranny fluid behind my driver side tire. It looks like its a line coming from just underneath my radiator. What line this could be/how to replace? I was hold it was my tranny coolant line I believe but I can't remember..
View 4 RepliesFord F-150 - 1997-2003 :: 2001 - Shudder And Surging Upon Acceleration
When I first bought my 2001 f150 a few mos ago there were no problems but I did notice once in a while it would give one little shudder when id accelerate. now all the sudden it shudders after around 20 mph all the way up to whatever the speed limit is. Then it smooths right out until I have to accelerate again. if I punch the gas and kick it down it will clear up but then it feels more like a surging going on.
I had the cruise set at 70 the other day and I had to slow down to merge to around 50 and when I hit resume it really started shaking bad and the service engine soon light flashed on and off for a few minutes then went off and hasn't came back on again. I took it to advance auto and no codes showed up. they said its probably the torque converter but after reading multiple forums I am not so sure now.
Ford F-150 - 1997-2003 :: 1999 V6 4.2L - Rear End Shudder / Vibration
I have a 1999 F-150, 4.2L V6 with 206,000 miles that recently developed a rear-end shudder/vibration. According to my door jam axle code (27) and the axle tag (3 37), I have what appears to be a conventional rear differential, even though most of my research would indicate this rear-end is for the F-250. In any case, and based on other online research, I changed the differential oil with a 75W-140 synthetic and added 4oz of a friction modifier. Now the vibration appears to be worse. It primarily vibrates when taking off from a stop, whether turning or not.
I have felt the vibration at speeds up to 60mph, but it is more noticeable at lower speeds. The vibration also seems to diminish after driving the truck for longer periods of time, particularly if at highway speeds. In other words, when I drive to and from work, which is about 30 minutes each way of mostly highway, the vibration is barely noticeable once I exit the highway and slow back down to 35-40mph. When feeling the vibration, if I decelerate, the vibration immediately ceases, but starts again when I accelerate. It's not as noticeable if I accelerate harder, but I generally don't do that. The gears inside the differential didn't have any noticeable wear, chips or slop/play. What may be plaguing my usual trouble-free F150?
Ford F-150 - 1997-2003 :: 1998 - Shudder / Hesitation At Certain Speeds
Just bought a 1998 5.4l F-150 Lariat. 136,000 miles.
Question about the overdrive button on trans handle. When I push the button, I don't see any light turn on (or off) and I don't feel any change in the gear ratio or increase/decrease in rpm's. I assume since the button in there marked "overdrive" that the vehicle in fact was equipped with it. Could it be a bad button, fuse, or ?
Also, it just started the shudder/hesitation at certain speeds that I see a lot on these threads. Seems like that is a coil issue as the description in many threads is exactly what I am experiencing to incl the rotten egg/fuel odor. However, it started the same day (not same time, later same day) I decided to push the overdrive button while checking out all the things on the truck.
Ford - Explorer :: Tranny Shudder / Whine Coming From Under The Truck When Turning Into Driveway
First off, I just traded another vehicle for a 97 mountaineer, 5.0 v8 AWD with about 171k miles on it. Runs and drives real nice, but on occasion under normal acceleration i get a slight shudder when it shifts into high gear. The tranny fluid does look and smell a bit old, but not burnt. I plan on changing it if you think it would fix the problem and not cause more.
Also, I think the ball joints are shot. The camber is in on the front tires and i get some pretty good clunks when I go over bumps in the road. Steering wheel is tight. I jacked it up and tried wiggling the tires but i couldn't get them to move like that. I'm assuming ball joints still though right? And if so, how hard of a job is that for a DIY'er?
Also i noticed a bit of a whine coming from under the truck when turning into my driveway. Transfer case I'm assuming? What could cause a slight whine and how do i fix it? I plan on changing the fluid in that too.
Ford 6.0L Power Stroke Diesel :: 2006 - In Tow Mode Tranny Clunk And Shudder?
2006 long bed with LS diff sometimes gets a fairly robust CLUNK! sound and feel when decelerating with tow mode engaged. It only happens once per 20 trips and only about a mile down the road, and it only happens once in a blue moon. It definitely is the rear end making the noise and brief shudder. Otherwise the truck runs extremely well.
I had the pumpkin off and fluid changed with Ford friction modifier added at about 100,000 miles. Truck is at 160,000 now. I just got done with a trip in the mountains of Idaho carrying a truck camper and used tow/haul mode extensively for engine braking and climbing, worked like a champ. This was just one trip of many this summer. This is about the only thing wrong that happens on my truck, but usually occurs before I get very far from the house. Should I just forget about it?
Ford F-150 - 1997-2003 :: Slow Shifting Into Reverse / Shudder Under Load
I have a 03 f150 2wd with the 4.6l. Recently it has been slow shifting into reverse(about 2 full seconds) and when it finally gets in reverse it shudders when it comes under load. The fluid is full and not burnt...
View 1 RepliesFord F-150 - 1997-2003 :: 4R70W - Shudder At Speeds Between 45 And 50 When Trying To Accelerate Mildly
99 F150, 4x4, 5.4L, 4R70W trans.
I am experiencing a shudder at speeds between 45 and 50 when trying to accelerate mildly - it usually occurs after slowing down from a higher speed.
It is similar to the bucking that occurs when you do not downshift a manual trans.
I am guessing that it is the torque convert clutch staying locked or the tranny staying in OD too long. The shudder will go away if I give the truck enough throttle to downshift or simply push the overdrive off button - which forces it to downshift to drive.
What is the probable cause?
Ford F-150 - 1997-2003 :: Trans Shudder When Come To A Stop Like The Converter Is Still Locked Up
I have a 02' f150 v6 67,000 miles. When I come to a stop, the trans shudders abit like the converter is still locked up. It then goes to stall in a few seconds. this does not happen all the time, fluid is clean. I understand there is a simple fix for this, or is this normal?
View 1 RepliesFord F-150 (2009-2014) :: 2012 FX4 Shake And Shudder In Tranny Driveshaft Passing Through 1500 RPM
I've got a 12 FX4 SC 6.5' w/Ecoboost. After 1K miles I began to develop a shudder/shake in the tranny-driveshaft passing through 1500 rpm. 4 dealers, 6 overnights and 2 escalations, I finally am told there is a design problem in the pre Jan 12 trucks. Fixed with frame mod to manufacturing process after Jan, but no solution for current owners with the problem. I replaced my 07 FX4 SC with this truck and loved it for the first 1K miles. Now I hate driving it, especially in traffic (lots of cycles through 1500 rpm).
View 5 RepliesFord F-150 - 1997-2003 :: CEL Code P0707 - Tranny Started To Slip / OD Light Flashing
I have a 97 f150 (built 96 as 97 model), 4.2l 4x4, auto tranny. Here's the problem, when I turn my key forward to run position my starter kicks on and starts the truck, and stays engaged. I have a constant 14v at the signal wire on the starter relay (yellow red stripe). Also tranny started to slip, od light flashing. I replaced ignition lock cylinder, ignition/ starter switch, starter relay, starter, and today transmission range sensor (neutral safety switch 8 pin), same problem. Cel code that I had 2 days ago was P0707 tr sensor low input.
View 8 RepliesFord F-150 - 1997-2003 :: CEL Code Signifying A Cylinder 3 Misfire - Shudder / Hesitation
I will add as many details as possible :
2000 f150 4x4 offroad package
5.4L with 131k on it
new Dorman intake manifold
new Global Automotive (Ebay) COPs
New Motorcraft spark plugs
About 1500 miles ago I started throwing a code signifying a cylinder 3 misfire. The truck would bog down real bad and then after 5-6 seconds of no power it would return to normal. I tried replacing the COP (both with new and then with one from another cylinder) and plugs but no resolution. So I talked to the local ford service manager and he said it sounded like intake manifold problems.
Replaced the intake manifold and no more codes were being thrown.
1500 miles later and today the truck started having a hesitation/shudder when I was sitting in a drive-thru. I put the truck in neutral and park and neither solved the issue. With the earlier issue, when I would put in neutral and increased rpm, the issue would resolve.
I pulled out of the drive-thru and the hesitation was consistent no matter what the rpm or speed. The truck feels almost sluggish and lacks power. The hesitation is like 2x/second. When accelerating its almost like the rpms and speed hesitate, jump, hesitate, jump.