Toyota - Corolla :: 1993 - Cracked Exhaust Manifold
I have a 1993 Toyota Corolla 1.6L with 200K miles. It is a sweet ride, but about every 2 or 3 years, the exhaust manifold cracks. I have replaced it several times, installing new gaskets, and carefully following the torque specifications on all of the bolts, but eventually, it cracks again.
View 18 RepliesGolf IV / Jetta IV :: Exhaust Manifold Is Cracked?
I have a 2001 Jetta 2.0L standard transmission I believe my exhaust manifold is cracked looking for a replacement. There is a local guy selling one off a 2001 golf wondering if that would work on my car..
View 1 RepliesGTI 337/20th Anniversary :: Manifold Cracked While Installing Exhaust?
Just received my discount GHL exhaust. and Discount it is. To boot some friggen how the manifold is now cracked? and I wonder if the warranty will cover the broken manifold?
View 11 RepliesCivic - Honda :: 2000 - Cracked Exhaust Manifold
I have a 2000 honda civic lx with a cracked manifold. Is this a serious repair..pricey wise? I understand its very important to get it fixed.. Firestone quoted it around 500. I've found inexpensive exhaust manifolds online.. and looking it up on how to repair, most of the articles say that it is an easy fix..
View 3 RepliesFord F-150 - 1997-2003 :: Passenger Side Exhaust Manifold Cracked
2003 F150 5.4 4x4 supercrew ,76k miles
Recently the passenger side exhaust manifold cracked on my truck. I bought this truck about two years ago with 58k on it and currently have 76k miles. I remember getting the carfax report and being relieved to see that it had exhaust manifold replaced in July of 2014 at 49K miles along with a new EGR tube. I called the shop that worked on the truck to see if he could confirm that both manifolds were replaced since carfax only said manifold & egr tube. The shop manager confirmed that both manifolds were replaced and he told me that they were most likely manifolds from napa according to the part number.
Now, my question is, what's the best brand to replace the manifolds with? Should I just go with OEM and spend the extra $130 per side? I know the manifolds are a common problem with these trucks but only lasting three years and 27K miles just seems ridiculous to me.
I'm hoping that when I get around to actually doing this that they wont be to bad because of how recently they were replaced. For now I just cleaned the area with a wire wheel and used the inferno metal repair. Seems to have done the job but I don't expect it to last long, just another month or two until I move to a place where I can actually work on my vehicles.
Ford Super Duty (1999-2016) :: 2008 - Cracked Exhaust Manifold
My '08 S.D. (5.4) has a cracked exhaust manifold, which I've heard is fairly common. Crappy Ford design. The local dealer has them in stock (imagine that, just like the 'non-bad' coil caps from some years ago, that they were instructed by Ford to keep at least 10 on stock at all times) for the passenger and driver's side. What are the part numbers?
View 10 RepliesFord F-150 - 1997-2003 :: Exhaust Manifold Gasket Cracked - Ticking Sound?
If the exhaust manifold gasket is broke / cracked will it making a ticking sound?
View 5 RepliesFord Super Duty (1999-2016) :: 2008 F450 - Driver Side Exhaust Manifold With A Cracked Abd Broken Bolt
I got a 08 ford f450 sd in the shop with a cracked abd broken bolt in the driver's side exhaust manifold, any tips tricks on getting it out,I have everything loose but I can't for the life of me get the egr cooler out of the way to access the top bolts to the manifold so I can replace the manifold, or a link to a service manual would be great.
View 3 RepliesToyota - Camry :: 2002 - Leak On Exhaust Manifold
I have a question regarding a leak i have in the manifold of my toyota camry 2002 2.4 cylinder. the engine check light is coming up and after a check on the mechanic there is a leak in the manifold where the catalytic converter is attached. when you put your hands near the pipe, you can feel air coming out. See the image attached.
The link is in the part mark as X. The catalytic converter is the one which is circled. [URL] ....
Toyota - Landcruiser :: 2004 - Exhaust Manifold Rattle Intermittently / Goes Away At Higher Rpm?
2004 Landcruiser excellent condition 77K. Exhaust manifold/heat shield type rattle, intermittant but >50%time. ONLY when in Drive and at Idle at 6000rpm. Goes away any higher rpm. NO rattle in Park or Neutral.
View 8 RepliesFord Excursion :: 2001 V10 - Intake Manifold May Be Cracked
What are signs the intake manifold may be cracked? 2001 V10 Excursion....
View 4 RepliesFord Exhaust :: Exhaust Manifold Leak Due To Broken Rusted Bolts
I have a 97 Expedition with the 5.4 engine and 160k miles. Recently while having other work done I was told that I had an exhaust manifold leak due to broken rusted bolts.
View 3 RepliesFord Exhaust System :: Exhaust Manifold Leaking / Louder Than Normal Knock When Accelerating
Leaking exhaust manifold? The truck has a much louder than normal "knock" when accelerating. At first I thought and had some bad fuel in the tank. I eliminated that with a full take of good fuel and some STP but the "knocking" continued. Then I thought that perhaps it wasn't firing on all cylinders but it felt like it had full power. I took it to my mechanic and he said it as a exhaust manifold leak. He said that he has never replaced the exhaust manifold but that it was a "nightmare" and expensive. He also said that it's not a safety issue but on the long run the leak would cause the truck not to pass its emission test. He said the problem was with rusted bolts that would be difficult to remove.
View 12 RepliesFord Exhaust System :: Exhaust Leak At Manifold Where Donut Gasket Meets The Catalytic Converters
My truck just started running really loud when it's cold and the leak goes away when it warms up to operating temperature.I did a little bit of investigating and I have found where the leak is coming from at the end of the exhaust manifold where the donut gasket meets the catalytic converters. It appears that the bolts rotted that hold the system together at the gasket. What should I do to repair this? I don't really want to replace the whole manifold because I know I'll break a stud off in the engine because everything is pretty rusty down there. I even took some pictures of the problem....
View 3 RepliesFord F-150 - 1997-2003 :: Exhaust Leak On Passenger Side / Broken Exhaust Manifold Bolts
My wife's 97 f150 4x4 had an exhaust leak on the passenger side. 7 out of the 8 bolts holding the manifold on are snapped off. 4 of them are snapped off 1/8" below the top of the hole on the cylinder head . I am I unable to get a drill in to drill these out. The other 3 I've tried welding a nut on these but they won't budge and I wring the nuts off. If I have to pull the head(something I don't want to do)can I just pull that 1 head or do I have to tear the intake and everything off?
View 1 RepliesFord 6.7L Power Stroke Diesel :: CEL With Code P2074 - Cracked Intake Manifold?
I was chasing down a P2074 CEL and thought it was a stressed wiring harness connection on the MAF.
Took it to the Ford house and they chased it for 2 days, believing it was the MAF and air filter. They told me that air filter was allowing to much air in. My thoughts was, that is was what MAF is for, to regulate the fuel based on how much air was going in.
I just found out that they are stating that an AFE dry air filter contributed to a cracked intake manifold because the aftermarket air filter made the intake get too hot.
Ford Exhaust :: Running With No Exhaust Manifold
So I needed to replace my exhaust manifold gaskets and bolts and I didn't get the project finished in time. I have school today and have to drive my truck there and it is maybe 2 miles at the most from my house. Is it ok to drive that far with them open? I will finish putting the gaskets on today when i get home and then close them again.
View 5 RepliesPassat (B5) :: Flex Pipe On Exhaust Is Cracked And Completely Broken
So the flexpipe on my exhaust is cracked and completely broken, so my passat sounds like a Mack truck. I've been looking into getting it fixed and I've been told i need to buy an entire new down pipe. Should i attempt to just get it fixed or buy a new down pipe.
View 4 RepliesLexus GS 2006-11 :: 2007 - Cracked Exhaust / Engine Idling At Low RPM And CEL Came On?
I have a 2007 GS 350 AWD and growing frustrated with some of its 'issues'. I have had the wheels replaced b/c they coating was 'bubbling' (the local dealer said this was normal...50,000 miles later this is happening again). At 60,000 miles to have frozen brake calipers replaced...never had this happen on any other vehicles, to include domestics with well over 100,000 miles, much less two of them freeze. A cracked exhaust, not to mentioned multiples recalls on a vehicle that has not even reached 75,000 miles. The engine has funny idling issues at low RPM's and the VSC and Check Engine lights came on list night but have since extinguished.
View 11 Replies