Ford A/C :: 1995 - Compressor Failure / Replacement
95 Bronc with a compressor failure. It sat up about a year and when i put it back on the road the AC Clutch failed so I replaced it in the hopes that maybe it was just a clutch. With the new clutch is made progressively louder racket so I stopped using it until the other day when the new clutch failed (I briefly turned it on).
I think it is time to replace the compressor. In researching the compressors I noticed that there are varied makes so I have a question as to which brand compressor to buy. Here are my options:
O'Reilly - Motorcraft - Assume FS10 - 283.99
Autozone - Ready Aire - FS10 - 235.99
Autozone - Compressor Works - FS10 - 179.99
Autozone - Compressor Works - SD709 - 247.99
Autozone - Denso - FS10 - 259.99
NAPA - Visteon - FS10 - 301.00
NAPA - (unknown) - SD709 - 409.00
ACKITS - Unicla - FS10 - 236.35
Do I get the FS10 or the SD709 (I assume Super Duty)? How can I identify which compressor my Bronc came with from the factory (FS10 or SD709)? I live in Texas so strong cooling is imperative. Should I even consider buying a remanufactured compressor (the ones listed above are all new)?
I typically stay away from getting parts from Autozone because I have found the parts that they sell to generally be of poor quality.
Santa FE SM (2001-06) :: AC Compressor Replacement - Shaft Seal Is Leaking
After 9 solid years of service, my a/c compressor finally failed. According to the shop, its leaking at the center seam of the compressor. If the system is charged, then the compressor will operate until the low pressure switch shuts it down. My question is this: Can this compressor be rebuilt? If so, where can I get the parts (I'm assuming the shaft seal is leaking).
Also, a quick search on eBay provides several compressors that fit my car; however, some of them are listed as HS-17 compressors and others are HS-18. My car (according to the A/C sticker on the hood) says I have an HS-18 compressor. Are these two interchangeable? I'm asking because if the current compressor can't be rebuilt, then I will have to buy either a reman. or new unit.
Car: 2002 Hyundai Santa Fe, GLS, 2.7L V6
Prius (2004-09) :: A/C Compressor Out And ABS Actuator Failing After Hybrid Battery Replacement
A few weeks ago, I received the triangle light in my 2007 Prius with 125k miles on it. When I took it to the dealer, they said that the hybrid battery needed to be replaced. A new battery was ordered & installed by the dealer, which took a couple weeks as the battery wasn't in stock. When I picked up the Prius this week, within driving it a couple miles, it was apparent the A/C wasn't working. I took it right back to the dealer who said they'd look into it. When the Service sales guy started it again, it made a very strange noise as well, which it never did before. The dealer has come back and said that not only has the A/C Compressor out but the ABS actuator is also failing. They are saying this has nothing to do with the battery replacement but both these items were working fine before having the battery replaced
View 1 RepliesFord F-150 - 1997-2003 :: A/C Compressor Not Engaging After Suspension Belt Replacement?
I have a F150, 97, 4.6L. I changed my Suspension belt, and now my A/C compressor is not engaging. This has happened before, and when I took it to the shop, they called me and said the A/C works just fine. They did not tell me why the A/C stopped engaging or what they did. I tried to locate a relay fuse, but I can't find it.
View 5 RepliesFord Super Duty (1999-2016) :: AC Compressor Bearing / Pulley Removal For Replacement
Need to replace the ac compressor bearing/pulley on my 2001 f350 7.3. My question is do I need a special tool like a pulley puller or is there another way to remove pulley? I already have the clutch assembly removed as well.
View 1 RepliesPassat (B5) :: AC Compressor Will Not Engage
The AC in my 2004 V6 4-matic wagon has not worked since the dealer had it in their shop last. Coincidentally, neither does the outside temp display on the dash. I tried one of those recharge kits with the cans but the pressure guage registers 90 PSI when I hook it up, more than enough according to the instructions. So it seems the system is charged and it looks like the compressor will not engage. Could the temperature problem and the AC be related? Manual says it only kicks in when the outside temp is hot enough so I figure how will it know if its hot enough if the temp probe is not working? (unless there is another probe somewhere) ...
View 7 RepliesPassat (B6) :: AC Compressor Tied Up / Hot Air Comes On
I bought my early b6 in january and now that it's getting warm I tried the A/C an nothing but hot air comes out. I took it over to my brother shop and he said the compressor is tied up. These things aren't cheap! With 61k on the clock I doubt that the dealer would cover it.
View 20 RepliesPassat (B5) :: AC Compressor Would Switch Off When Car Stopped
My AC is no longer running. Last summer it would struggle to get cold, but when in motion it did pretty well - just not freezing cold. Last few weeks it seemed like the compressor would switch off when stopped. Then past week, I hit the AC button (light comes on, fan switches to low, and the relay clicks) but it sounds like the AC compressor isn't engaging. The dryer is frosty to the touch, but the low and high ports in the bay are warm/hot. I checked the pressure and it was through the roof. I vented some (I know I know) out, but all that came out mostly was air with a bit of the refrigerant squirt once or twice during the vent. Still no success. Should there be air coming out of the low pressure port?
AWM 1.8t
Passat (B5) :: AC Compressor Seized After Tune-up
I recently had a full tune up at 87,000 miles. My receipt does not mention any inspection of the A/C system. 50 miles after the tune-up, my A/C compressor seized. Dealer claimed this was simply coincidence. I think there is a chance that they checked the A/C Coolant level and may have not secured the valve. I cannot find on the internet evidence that this compressor is prone to failure at just 3 years (87,000 miles).
View 1 RepliesPassat (B6) :: A/C Malfunction - Compressor Is Shot?
I took the car in today for the damn A/C.
They said my compressor is shot.
So, when I get it back I hope I will have cold A/C. I will let you know.
Passat (B5) :: No AC / Compressor Will Not Click On / Fuse Ok
I have an '04 Passat and my AC did not come on this Spring. I had it checked out and the charge is up to normal on the refrigerant but the compressor will not click on. The compressor fuse is also ok. I have access to a Vag Com that my dad has and I'm wondering if that does any diagnostic test further troubleshooting what the problem might be.
View 2 RepliesPassat (B6) :: Battery Light On - AC Compressor Seized
The car is an '06 Passat 2.0T 83k. A few weeks ago my wife came home complaining that the battery light was on, when I lifted the hood I saw that the belt was shredded and later realized the compressor seized. I replaced the parts recommended; Compressor, condenser,etc., brought it to service station that does our fleet cars and had the system vacuumed and recharged. Now the compressor will not turn on, when I push the button on the dash it lights up but no a/c, the fans dont even come on comes on. The blower and all the related switches works but no power to the compressor. All the fuses are fine, and when the guy at the service station put power directly to compressor it comes on and works fine, he also said the pressure sensor/switch checks out fine. I even changed the controller on the dash, but nothing.
View 11 RepliesPassat (B5) :: 2000 - AC Compressor Makes Squealing Noise
All was fine with it until a month or so ago. Now, after the car is first turned on and the AC is turned on, it makes a terrible squealing sound. The moment the AC is turned off it stops. If the AC is left on, it will generally make the noise for a good 20 seconds, stop, and then repeat that a couple more times(and the noise will cease for as long as the car is on).
I popped the hood and took a look (I'm assuming the compressor is on the lower left), and when the AC is off it spins fine. However, when the AC is turned on, the fan starts up, then it visibly stops spinning and really struggles to spin, causing the noise. Do I need a new compressor?
Passat (B5) :: 1999 - AC Compressor Clutch Pulley Locked Up
99 AC compressor clutch pulley locked up. I replaced the serp belt because it failed, then noticed the AC outer pulley was locked up. I could turn the inner clutch assembly with the 14 mm nut with no problem. So do I need to replace compressor, or can clutch assembly. be repaired on car?
View 4 RepliesPassat (B6) :: 2006 - AC Stopped Blowing Cold / Compressor Is Always Engaged
The A/c stopped blowing cold on my 06 Passat 2.0t. I checked the pressures on the low side of the system and it was 100 psi with a cold engine and 130 when hot. Obviously this is too much. It seems as if the compressor is always engaged even when the a/c is off (every part of the a/c pulley is always spinning the little nut sticking out of the center of the pulley spins as well not but im not sure if that's how it is when the compressor isn't engaged).
View 17 RepliesPassat (B5) :: W8 - Oil Cooler Replacement
How to replace the oil cooler on a W8 6 spd wagon. Dealer says $1K plus labor. Is it possible to do it with average wrench turning skills? Also, does Bentley cover the W8 in the normal Passat edition?
View 2 RepliesPassat (B5) :: ABS Module Replacement?
Looking for info on replacing ABS module themselves? I was wondering how difficult this job can be.
View 4 RepliesPassat (B5) :: Transmission Replacement Is Required
I purchased a 2002 VW Passat Wagon two months ago. Upon Purchasing the Car the dealer notified me I would need to purchase a "Torque Converter." I failed to do so. Before I changed the oil, the car was running great! And, after the oil change. The car began to act up and the transmission would kick back!
After, I took it to a local dealer. They told me "Transmission Replacement is required," and Internal Slippage and Fluid Burnt.
I just don't understand, how the transmission began to act up after I changed the oil.
I can reverse the car great, and shift to drive.
Passat (B5) :: Stop Light Is Out - Replacement?
One of my stop lights is out. Do you have to remove the entire light assembly from inside the cargo area of a wagon to replace the stop light? I tried searching for stop light replacement info without success. Any links or pictures available showing how it comes out?
View 5 Replies