Chevrolet - HHR :: 2010 - Clunking From Front Suspension On Rough Road / Slow Speeds
2010 chevrolet HHR clunking from front suspension, rough road, slow speeds. Is this typical of worn sway bar bushings or something more expensive?
View 1 RepliesPassat (B5) :: Clunking Noise In Front Right Suspension At 67,000 Miles
My 2002 Passat Wagon (2.8L, FWD) has started developing a clunking noise at 67,000 miles in the front right suspension. Based on forum search here, it sounds like a common problem with the control rods, tie rod ends, ...
I looked at the control arm kits available at ECS Tuning. Is this a DIY job for someone with only moderate mechanical skills? I have never performed front end suspension work before. How difficult is it? Special tools needed?
If I had it done (both sides, upper and lower) at an independent repair shop, how much might I expect to pay?
Lastly, is it best to replace all the parts (as provided in these kits), rather than isolating the part that is currently causing the clunk and just replacing what needs to be replaced?
Passat (B5) :: 1999 - Clunking / Popping Noise From Driver Side Front Suspension?
We have a 1999 Passat GLX 2.8 auto. I recently put on a new inner and outer tie rod as well as a lower forward control arm. The issue that we are experiencing is that when accelerating or braking hard there is a popping/clunking noise coming from the driver front area. When accelerating or braking normally/ smoothly it is fine. But, as I said accelerate or brake hard it will make a single pop or clunk and that is it, just once when braking hard or accelerating quickly.
View 2 RepliesPassat (B6) :: Noise From Front Suspension When Going Over Small Bumps On Roads At Low Speeds
I'm getting ready to do some maintenance such as flushing the brake fluid, new air filter, and changing spark plugs. I've noticed lately a noise from what I'm assuming is my front suspension that can be heard when going over small bumps on roads at low speeds. It sound like a squeaky spring, almost like something needs to be oiled. I'm still on stock suspension with close to 80k on the clock, so I was wondering if there is anything in particular I should look for when I'm messing around the wheels bleeding brakes, or if there is a common procedure to lubricate something so the noise stops. I can hear it from inside the cabin so I imagine you can hear it from outside the car.
View 3 RepliesPassat (B6) :: Thumping Vibration At Certain Speeds From Front Wheels
My 08 passat seems to shutter or vibrate at higher and lower speeds. It comes from the wheels(front). At first I thought my wheels aren't balanced, but the VW dealership said everything is fine.???huh.. they roadtested it and nothing...but others that drive with me totally notice it..Major road noise because of it.
They also sold me winter tires and rims and they wore out after 25k same noise?... "Broken beads".... they said i hit a pot hole.. I don't think so.... So what do you think? Rotors? if so how much am i gonna get jacked ..
Golf VI R :: Front Suspension Clunking Over Bumps?
Aside from the clutch and gear changing noise, recently I've been noticing something that sounds almost like a rattle when going over bumps, say a series of filled potholes on a highway where they just slightly bump to move your wheel around, it's not that deep thumping you would expect to hear but it sounds like something is loose in terms of the suspension.
Happens on the front and seems like its coming from both sides. To me it sort of sounds like they forgot to tighten something up when they removed the shipping "blocks"/spacers, but I am not exactly sure what to check. I really do not want to visit the dealership at only 600 miles on the clock ...
Golf IV R32 :: Clunking Sound From Right Front Suspension When Going Over Bumps
I have a clunking noise from the right front suspension when going over bumps. I've replaced the Strut bushings that were collapsed, the control arm bushings that had play and the noise is still there. There is no play in the links. There is a slight noise in the sway bar bushings when struck with a rubber mallet. I hate to keep replacing parts chasing down this noise.
View 9 RepliesSaab - 9-3 :: Right Front Suspension That Has Been Making A Clunking Sound
Today, I took my 2007 Saab 9-3 2.0T with 67,000 miles on it to a local mechanic to check the right front suspension that has been making a clunking sound when hitting potholes, etc. I was told that the right front coil spring is broken. This afternoon, I looked on line on some of the Saab discussion boards and saw that for cars up 2006 that there was an extended warranty offered for 10 years and 120,000 miles due to multiple cars with this problem caused by an, allegedly, faulty design that allowed the springs to corrode and fail prematurely in snow belt states that salt the roads.
View 3 RepliesSedan :: Clunking Noise In Front Suspension Only Sometimes When Turning
So I got a steering problem and it's got me going crazy. I have a 06 g35 sedan lowered about an 1.5 inches. It's been about 5 months since I lowered it, lately I've been herring clunking noise in front suspension, not all the time but only sometimes when I turn. The other day my steering got really stiff and when I turn the steering won't return to the center. My Power steering isn't making any noise and I'm good on fluid. A lot of people say my ball joints but don't they usually make a lot of noise when they go bad ?
View 18 RepliesGolf IV / Jetta IV :: Clunking Noise From Front Suspension
I am trying to find origin of clunking noise, but it is difficult to do as there is no visual signs and no excessive movements in any components.
Little bit of details and video. Noise occurs when moving rapidly steering wheel on stationary car with running engine. Not noticeable when at speed. Wheel is not vibrating and cv joints not clicking. Very tiny free movement in steering wheel about 1mm, but I am not sure if that is related maybe a completely different issue there. Mot tester make an advisory note that steering system slightly rough, but its not that useful to find an issue.
[URL] ....
Ford Brakes/Suspension :: Clunking And Rattling In Front End
I have had a clunk in the front end that started out as a light clunk that was sometimes noticeable. It has now turned into a clunk that can be heard very often. It sounds like a hollow clunk. I'll try to explain it so it makes sense...If I'm going over a bump or speed bump or something like that it doesn't really do it noticeably. If I'm driving a get to a place where the road is uneven or there is a hole or pothole and the front end seems to "fall into the hole", then the sound is very audible, and I can feel it slightly in the steering wheel and under my feet in the drivers floorboard. So, I've had the front end checked out 4 times and between what they said to do and what I've read on here...here is what I've done so far......
Changed end links with moog end links
Changed sway bar bushings with moog bushings
Undid the bushing mounts from the front frame and wired the sway bar up to keep from flopping around. No change in sounds
Didn't get rid of the clunk....
Had front end shop check out truck... They said ball joints were ok, no play in them. They did say that they could feel some "clicking in the pitman arm pivot" when turning the wheel. Like something was loose in box.
I've changed shocks and bearings.
I can grab a hold of the passenger outer tie rod at the adjustment sleeve and rotate the tir rod and it will rotate around in the socket and hitting on the insertion point and make a metal thud sound.
Again, took into shop and they said that would be normal b/c the tie rods have to have that to keep from binding up in front end.
My thinking is that if the tie rod rotates that much, then it is rotating the drag link which in turn puts stress on the pitman arm which in turn has either broken or sheared the pinion shaft inside the box and then when I go over a hole, it moves and all of the above is put into motion.
Shop (Ford) basically called me an idiot and that wouldn't be the cause.
So, now onto my thoughts and questions....
Radius arm bushings
Axle bushings (????? how many and where are they all located)
tie rods and drag links..
Elantra MD (2010-15) :: 2011 - Clunking Noise In Front Suspension
I have been frustrated with my Elantra's handling from the time I purchased. I feel that the car is setup poorly and has design/OEM part issues.
I have improved the rear-end "hop" issue by replacing the OEM rear shocks with the KYB Gas-A-Just's -- a big improvement in handling the bumps. But the rear-end solid axle on such a light car is just crap...
I have developed quite a bit of 'clunking' noise in the front suspension.
I am considering replacing the front-end shock-strut assemblies with KYBs -- I'd love to hear if it made a big difference. Also wondering if I should change-out the 'sway bar link' while replacing the shock/struts.
I'm just so frustrated with the way this car handles (I've driven Subaru's, Honda's, and VW's) compared to other cars. I feel it's a combination of low-quality OEM suspension parts, rear solid axle, light weight, crappy electric steering settings, and tires that are too wide and too low-profile for such a light car. (I have the limited with 17 wheels).
Santa Fe (CM - 2007-12) :: Clunking Coming From Front Suspension When Go Over Bumps
I can't find the obd port on my new 2007 SF. Also there is a clunking coming from the front suspension when i go over bumps, what is the most common cause of this?
View 13 RepliesPassat (B6) :: Getting Clunking / Rattling At Low Speeds?
So I've got a clunk/rattle going over bumps at low speeds. It sounds like its coming from the front, and for the longest time I just wrote it off as a loose engine cover. Well at the latest dealer visit they finally got it on right and still, the clunk. Some info: it's only over bumps/potholes at lower speed (~35 or lower) and its not under acceleration. It doesn't favor a side when I'm turning, and it's like a clunk that rattles, if that makes sense. A mount/bushing?
View 13 RepliesSonata NF (2006-10) :: Clunking Noise Around Front Suspension / Wheel Arch
I have a 2005 NF V6 Sonata Elite - for some time now there has been a sporadic clunking noise in and around the suspension or front drivers side wheel of my car. It got a lot worse a week ago when I took the car off sealed roads for a short distance, almost sounding like a CV that had gone. However a mechanic checked the car over a few days ago and found the CV was fine, as was the driveline. It seems to clunk more when turning, and when I put the power on or off. I also detect a slight vibration or hum coming from the area concerned when taking gentle bends at moderate speed on smooth roads. I can assume the wheel bearings are fine, although the mechanic I went to perhaps isn't very familiar with the make/model of car. They went around the suspension and tightened some of the struts, which made a small improvement I think, but the car is still making the noise. What was the cause of the noise if known?
View 4 RepliesFord Excursion :: Clunking Noise In Front End Only Happening During Suspension Travel
I have a noise in the front end that is only happening during suspension travel. It is really bad on bumpy roads. I thought it was my sway-bar end links but they are a year old and tight. I have checked the shocks and they are tight. It sounds like a clunking noise. Could the front drive axles be making this noise while not locked in?
View 14 RepliesSanta FE SM (2001-06) :: Small Clunking Noises In Front End At Low Speeds?
I figured out what was causing my small clunking noises in the front end.. They were faint, but you could hear them at low speeds..
Front sway bar bushes and end links.. Replaced mine with auto7 bushes and moog endlinks.. They didnt "feel" loose or wobbled but replacing these parts got rid of my clunks..
Only downside was the bushes are really hard to replace, need to remove the rack, subframe, etc..
My car has about 150k miles, and the bushes were a little oval..
Passat (B5) :: Clunking From Suspension - Symptoms Of Control Arm Failure
I have a quick question about the control arms on the B5. I have an 01 Passat GLX 4motion, the was previously my mothers. She had the upper arms (iirc) replaced around 60k but not all of them. I got the car with 64k from her, and it now has 92k of mostly highway miles. I have a few clunks from the suspension but nothing crazy, and considering the shocks and dampers are probably shot i cant seem to tell if its the arms or the shocks.
View 1 RepliesHonda - Accord - Suspension :: Clunking Sound From Front When Go Over Wavy Pavement Or Dips
I have a 2002 accord 4-cyl with a 5-speed with 89,xxx miles. Just a few months ago, I noticed a clunking sound coming from the front suspension when I go over certain bumps. "Certain" bumps are usually wavy pavement or dips (not wide dips, but short/concise ones), and sometimes certain speed bumps. Sometimes the sound happens regardless of the types of bumps though, but the aforementioned ones usually bring the noise quite consistently. The sound hasn't really gotten worse, but it hasn't been getting better either.
A while back when I had my timing belt done, the mechanic stated that one (or more) of my engine mounts were worn. Is it possible one or more of my engine mounts is the source of this issue (from the engine "rattling" around in the compartment. I'm not sure if that's even possible, just a hypothesis) or is it purely suspension. PS. The sound isn't quite a sharp metal on metal sound. Its more of a "thump" or "clunk" coming from the front end (left or right) as if its bottoming out or a bushing or spacer has worn off. Its just loud enough to drive me crazy, and sometimes I can feel it through the floor.