Golf IV / Jetta IV :: 2003 Suspension Creaking / Clunking Noise
How to diagnose this creaking/clunking noise in my 03 Jetta TDI. It's only coming from the passenger side, and I primarily notice it at low speed on relatively uneven roads. I can replicate the noise by pushing up and down on the front passenger side corner.
For context, this started after I just recently replaced my front and rear suspension, plus some steering parts. I replace all four struts with Koni yellows, front CA bushings (with R32/TT), ball joints, tie rod ends, front strut bushings and bearings, and passenger side CV axle. In response to the noise, I also just did the front sway bar bushings, which definitely needed it, but didn't change the noise. I also removed the CV axle and re-greased the inner CV joint--to no avail.
Also, when I have the hood open and push up and down on the front of the car, I can see the cup where the top strut nut goes into will go up and down separate and apart from the body. The driver's side stays in line with the body when I try to the same on that side. Also, that cup is tight on the passenger side, whereas it will spin fairly freely on the drivers side. So, this has lead me to think that perhaps I didn't torque either or both of the top or inner strut nuts on the passenger side.
Here's a (fairly crappy) video of the noise/strut cup .....
Golf IV / Jetta IV :: Clunking Noise In The Front On Both Sides
At low speed driving and hitting a small bump I hear a clunking noise in the front on both sides. But when driving at faster speeds and hitting a bump it makes no noise at all. I can't seem to figure out what it is.
View 5 RepliesGolf IV / Jetta IV :: Clicking / Clunking Noise From Front End?
I've been having a problem with a popping/clicking sound coming from my front end for some time now. 2 days ago I replaced the top strut mounts thinking they were worn and this was the source of my problem, however, the noise persists.I have raised the car and have tried to physically move the wheels, up, down, left, right, but I get no play in any direction.
When the sound happens: If I go over small bumps in the road, or depressions, or speed bumps at slow speed I hear what sounds like a metal on metal sound, but muffled, not a clang, but a pop sound. I can induce it by stepping hard on the brakes, as the car lurches forward I get the sound. After stopping, when the weight moves back again I get the sound again.HOWEVER, I do NOT get the sound from acceleration. I have tried putting on the parking break and trying to take off, but I don't get the sound. The sound is their wether or not I'm in gear.
What could this sound be? My possibilities include:T ie-Rods, Axles, Transmission (loose bolts), broken engine mounts, loose subframe, or perhaps my control arm bushings (but they were replaced with poly bushings about 30k miles ago)
Golf IV / Jetta IV :: 2002 - Clunking Noise Coming From Front End
Ok so im going to try my best to explain this. Last week my passenger side motor mount broke the bolt snapped off and my engine fell on the ground and cracked the oil pan, too make a long story short someone put the wrong bolt in it and I fixed it with the right bolt. When the engine fell and the pan cracked i immediately shut the car off and coasted to the side of the road. I checked all bolts on the car to see if anything was loose but nothing was. But now when i start to take off i hear a clunk from the front end and i do not know what it is or could be. It is not the axles there is two brand new ones in it and have been checked. What it could be?
Car is a 2002 MK4 Jetta Wagon 2.0 .....
Golf VI R :: Front Suspension Clunking Over Bumps?
Aside from the clutch and gear changing noise, recently I've been noticing something that sounds almost like a rattle when going over bumps, say a series of filled potholes on a highway where they just slightly bump to move your wheel around, it's not that deep thumping you would expect to hear but it sounds like something is loose in terms of the suspension.
Happens on the front and seems like its coming from both sides. To me it sort of sounds like they forgot to tighten something up when they removed the shipping "blocks"/spacers, but I am not exactly sure what to check. I really do not want to visit the dealership at only 600 miles on the clock ...
Sedan :: Clunking Noise In Front Suspension Only Sometimes When Turning
So I got a steering problem and it's got me going crazy. I have a 06 g35 sedan lowered about an 1.5 inches. It's been about 5 months since I lowered it, lately I've been herring clunking noise in front suspension, not all the time but only sometimes when I turn. The other day my steering got really stiff and when I turn the steering won't return to the center. My Power steering isn't making any noise and I'm good on fluid. A lot of people say my ball joints but don't they usually make a lot of noise when they go bad ?
View 18 RepliesPassat (B5) :: Clunking Noise In Front Right Suspension At 67,000 Miles
My 2002 Passat Wagon (2.8L, FWD) has started developing a clunking noise at 67,000 miles in the front right suspension. Based on forum search here, it sounds like a common problem with the control rods, tie rod ends, ...
I looked at the control arm kits available at ECS Tuning. Is this a DIY job for someone with only moderate mechanical skills? I have never performed front end suspension work before. How difficult is it? Special tools needed?
If I had it done (both sides, upper and lower) at an independent repair shop, how much might I expect to pay?
Lastly, is it best to replace all the parts (as provided in these kits), rather than isolating the part that is currently causing the clunk and just replacing what needs to be replaced?
Golf IV R32 :: Clunking Sound From Right Front Suspension When Going Over Bumps
I have a clunking noise from the right front suspension when going over bumps. I've replaced the Strut bushings that were collapsed, the control arm bushings that had play and the noise is still there. There is no play in the links. There is a slight noise in the sway bar bushings when struck with a rubber mallet. I hate to keep replacing parts chasing down this noise.
View 9 RepliesElantra MD (2010-15) :: 2011 - Clunking Noise In Front Suspension
I have been frustrated with my Elantra's handling from the time I purchased. I feel that the car is setup poorly and has design/OEM part issues.
I have improved the rear-end "hop" issue by replacing the OEM rear shocks with the KYB Gas-A-Just's -- a big improvement in handling the bumps. But the rear-end solid axle on such a light car is just crap...
I have developed quite a bit of 'clunking' noise in the front suspension.
I am considering replacing the front-end shock-strut assemblies with KYBs -- I'd love to hear if it made a big difference. Also wondering if I should change-out the 'sway bar link' while replacing the shock/struts.
I'm just so frustrated with the way this car handles (I've driven Subaru's, Honda's, and VW's) compared to other cars. I feel it's a combination of low-quality OEM suspension parts, rear solid axle, light weight, crappy electric steering settings, and tires that are too wide and too low-profile for such a light car. (I have the limited with 17 wheels).
Sonata NF (2006-10) :: Clunking Noise Around Front Suspension / Wheel Arch
I have a 2005 NF V6 Sonata Elite - for some time now there has been a sporadic clunking noise in and around the suspension or front drivers side wheel of my car. It got a lot worse a week ago when I took the car off sealed roads for a short distance, almost sounding like a CV that had gone. However a mechanic checked the car over a few days ago and found the CV was fine, as was the driveline. It seems to clunk more when turning, and when I put the power on or off. I also detect a slight vibration or hum coming from the area concerned when taking gentle bends at moderate speed on smooth roads. I can assume the wheel bearings are fine, although the mechanic I went to perhaps isn't very familiar with the make/model of car. They went around the suspension and tightened some of the struts, which made a small improvement I think, but the car is still making the noise. What was the cause of the noise if known?
View 4 RepliesFord Excursion :: Clunking Noise In Front End Only Happening During Suspension Travel
I have a noise in the front end that is only happening during suspension travel. It is really bad on bumpy roads. I thought it was my sway-bar end links but they are a year old and tight. I have checked the shocks and they are tight. It sounds like a clunking noise. Could the front drive axles be making this noise while not locked in?
View 14 RepliesPassat (B5) :: 1999 - Clunking / Popping Noise From Driver Side Front Suspension?
We have a 1999 Passat GLX 2.8 auto. I recently put on a new inner and outer tie rod as well as a lower forward control arm. The issue that we are experiencing is that when accelerating or braking hard there is a popping/clunking noise coming from the driver front area. When accelerating or braking normally/ smoothly it is fine. But, as I said accelerate or brake hard it will make a single pop or clunk and that is it, just once when braking hard or accelerating quickly.
View 2 RepliesGolf/GTI VII :: Clunking Noise While Pulling Away - Suspension?
After doing reading I think my issue might be suspension related. Whenever I engage the clutch at a normal rate I get a rubbing/clunking noise coming from the driver side. I can feel it thru the gas pedal and it sounds like a card in a bicycles spokes. If I engage the clutch extremely lightly I don't get the noise at all. This only happened AFTER I had my H&R Sport Springs installed. Could it be a strut mount? Engine Mount? The car only has 4500 miles on it. I'm extremely confused.
View 4 RepliesTiguan :: 2012 - Clunking / Rattling Noise Coming From Front Passenger Side Suspension Arm
I just purchased my first VW, a 2012 Tiguan SE in Night Blue Metallic. The level of fit and finish, handling, and general feel are miles ahead of my old '04 Jeep Liberty.
Anyway, I've had the car for about 250 miles and have noticed a clunking/rattling noise coming from what sounds like the front passenger side suspension arm. The noise is fairly quiet but seems to consistently happen when turning left over uneven pavement.
I plan on taking it to the dealer this weekend and it is only a minor annoyance, but a shame since the rest of the vehicle is so quiet and refined.
Ford Super Duty (1999-2016) :: Crunching / Clunking Noise Coming From Passenger Front Suspension
2012 truck, started making a noise today. I cannot tell what it is, but seems to be coming from the passenger front suspension, its a crunching/light clunking sound, happens when going over bumps, when the truck pitches one way or the other turning, and coming to a stop....
Truck has 6k miles, I did a quick visual inspection this afternoon, didn't notice much, but the sway bar endlink looked a bit odd though, not sure if normal, its gota little bend too it and seems to just contact the vac line mounted behind it, seemed unusual...
Maybe its its just one of the crappy rancho branded shocks is junk?
Golf IV / Jetta IV :: Front Right Clicking / Clunking Sound While In Neutral
I have a 2004.5 Jetta GLI 1.8T. 96K miles.
The sound just started a couple of weeks ago and is becoming more prominent. On cold starts (like in the morning or after sitting for a while), the front right of the car makes a repeated clicking/ clunking sound while in neutral. However, the second I apply any gas, the sound goes away. Only when my engine is idling at around 700-800 rpms does it make the sound. After driving the car around for about 10 minutes or so ("warming up"), the sound eventually goes away and comes back on the next cold start.
Yesterday, my ABS light came on and never went away. I have no idea if there's any relation. May be a separate issue. I've tried searching for a diagnosis with no luck. Thoughts on what I might be hearing?
Golf IV / Jetta IV :: Hollow Clunking In Front Driver Side
Recently my car has had a hollow clunking noise and it seems to be coming from the drivers front side. It doesn't really make the noise if I hit a pothole or something in the road. It does it when I'm driving down a bumpy road or sometimes even a smooth road. I thought it was my top strut mounts and bearings. I replaced them and the noise went away for about 2 weeks but it seems to be back. I was thinking maybe sway bar bushings? Could my new parts I just installed be bad already?
View 3 RepliesGolf IV / Jetta IV :: Front End Clunking When Side When Accelerating / Decelerating
I am currently having a clunking noise coming from the front driver's side when accelerating from a stop or decelerating to a stop. It seems to happen only at low speeds and only on the driver's side. No strange vibrations or noise when turning or when going over bumps. I am thinking strut mounts or possibly trans mount.
View 24 RepliesGolf IV / Jetta IV :: Front End Clunk Almost Every Time When Suspension Flexes
So I've always had a clunk coming from the front end of my car since I bought it last year. It happens almost every time the suspension flexes. I'm pretty sure my steering is okay as I can turn the wheel quickly and/or forcefully back and forth with the car either on or off and there is no noise; the steering feels solid.
Here is the list of things I have done so far:
-Poly sway bar bushings
-Poly end link bushings
-Poly dog bone bushings
-Cup kit (Springs and shocks)Upper strut mounts & bearings
-Ball joints
-Raxles
After a quick look at my Bentley manual, it seems the only things left to do are control arm bushings (most likely in my mind) and sub frame bushings (less likely). Is there anything else I should check for possible causes that I'm missing?