Golf IV / Jetta IV :: 1998 - Clutch Engages Lower To The Floor / Shifter Stuck In Gear
98 Jetta TDI hydraulic system ... We just received this vehicle from my mother in law, who is not driving any more. It's a cream puff--79,000 miles, beautiful condition. Problem is the clutch engages lower and lower to the floor, and eventually the shifter gets stuck in gear. The brake pedal slowly sinks to the floor when at stops on hills. Our mechanic tells us these two are connected because both the clutch and brake run off the same hydraulic system.
1st time he said the fluid was filthy, and he emptied the system and put in clean fluid. Worked for a little while and then we were back where we started. Second time he replaced a couple parts on the clutch, replaced this fluid, and this time it ran like a dream for a little over a month. Then the problem just returned. Again he says the fluid is filthy, and now we are looking at replacing the master cylinder and again changing the fluid. The theory behind why this is happening is that my mother in law let the car sit for half a year before passing it on to us. She didn't do much driving the 6 months before that either. I've done research, and this doesn't appear to be a common problem by any means on these cars.
GTI 337/20th Anniversary :: Clutch Pedal Stuck In Place - Could Not Put It In Gear
So last night I was driving home from work, and at a red light while i was waiting to go i had my clutch down when light turned green i tried to go and noticed i could not put it in gear and that my clutch pedal was stuck in place. i didn't know what to do so I checked my shifter plate everything looked fine so went to look at the pedal and i pulled it forward and it came lose. I started it up everything was fine and back to order. This morning going to work same thing happened again, I don't know what is going on and what could be the cause?
View 5 RepliesAccent LC (2000-05) :: When Clutch Is In Gear Stick Will Not Move In Any Direction / Completely Stuck
Bought a 2001 hyundai accent 1.3 si petrol manual 2 weeks ago. After pulling off today, i went to go into 2nd gear, and I couldn't move the gear stick. I parked up and turned the engine off, then started the ignition again. When the clutch is in, the gear stick will not move in any direction, its completely stuck, but when the clutch is out, the gear stick will move in all directions.
View 6 RepliesGolf V R32 :: Clutch Is Stuck And Car Stalls Out
My car just cuts off sometimes when coming to a stop while in manual mode. It's like the clutch is stuck and it stalls out.
I ran vagcom thinking it might be dsg related but it came up fine. I do however have this....
Golf VI R :: Clutch Pedal Stuck To The Floor On Several Occasions
So over the weekend my clutch pedal stuck to the floor 2 times and would not come all the way up on several occasions. It has since then stopped doing it. I am wondering if I should bleed my clutch or not. Flush and change fluid?
Just concerned it may turn worse.
Golf IV R32 :: Stalled When Put Car In Neutral And Took Foot Off The Clutch / Now Stuck Is Reverse
I came home last night and rolled into the driveway. With the car in neutral I took my foot off the clutch and the car stalled. I get in the car this morning to go to work, and it's still happening. I put it in reverse to see if it will drive.....and now it's stuck in reverse.
I can't get it into any other gear or neutral..........even when the car is off. I've unattached the linkage, and the shift knob moves freely.....so I don't think it's that. I found these old threads (one even mine)
[URL] ...
[URL] ....
[URL] .....
So I'm lead to believe that the master/slave cylinder is acting up again. Also, how can I get it into neutral so I can at least get it towed and stop blocking my driveway?
Golf IV / Jetta IV :: 2001 Gti VR6 Stuck In Reverse / Clutch Won't Fully Disengage
My 01 GTi (12v VR6) was having some trouble shifting into, and out of, first and reverse so after a bit of research I decided to try adjusting the shift linkage as it seemed like a possible easy fix. After doing that I tried backing it up in the driveway and after a couple of shifts to different gears it ended up getting stuck in reverse. When I pushed in the clutch pedal to let it roll forward I noted that it seemed to be resisting rolling forward despite the steep incline. Once it reached a less steep incline it stopped rolling forward completely, so I'm thinking that it probably won't come out of gear because the clutch won't disengage all the way.
I've done some searching around and from what I've read so far it sounds like it could be a worn or damaged clutch fork, the hydraulic lines, master or slave cylinder, or even a broken clutch plate. What I don't want to do is pull the transmission and clutch, only to find that it was something much easier to fix.
Golf IV / Jetta IV :: Clutch Pedal Stuck To Floor With Fluid Underneath Car
I have a 2003 Jetta GLI. Thus morning driving into work my clutch pedal stuck to the floor. I was able to pull it back it and make it to work, but when i got to work i noticed fluid dripping from underneath my car.
View 4 RepliesGolf/GTI VI :: Clutch Pedal Is Losing Pressure / Stuck At The Bottom And Refuses To Bounce Back
Just a heads up to all MKIV GTI owners out there, new and old. If you feel like the tension on your clutch pedal is deteriorating get it checked earlier rather than later. Because if the slave cylinder malfunctions and leaks you will be faced with a big repair bill due to the fact that the slave cylinder is located inside the tranny. Secondly because of this design, which I think is very stupid, it leaks onto the clutch assembly and can get on your clutch plate. At that point you should replace the clutch plate to prevent any further damage that might be caused by slippage. The clutch plate should not come in contact with any fluids or it will compromise the functionality.
View 2 RepliesGolf IV R32 :: Clutch Would Not Go Into Gear
Just bought my first r 32 recently , had previously owned a 20th anniversary GTI, anyway guy i bought the car from mentioned the awd system was not working , recently was driving and clutch would not go into gear in addition to the haldex or awd not functioning . The clutch also kinda "stuck" to the floor .. Also I noticed some fluid on the undercarriage the day I brought it home . I'm pretty sure the car was beat on but there aren't many available up this way , and honestly I know I'm prob gonna spend some to get her road worthy again , Also felt like the car was operating in rwd for some reason and traction control light is on.
View 3 RepliesGolf IV R32 :: 02m Clutch Does Not Slip In Any Gear
So long story short, my clutch is not disengaging all of the way, but only sometimes.... I have replaced clutch, flywheel, slave cylinder, new stainless steel clutch line and new clutch master cylinder all within this month. The same issue has been occurring prior to replacing all of this and also after replacing all of this. I've bled the system (with a power bleeder) more times than you can count on both of your hands so there is no way there is air in the system.
More details : The clutch doesn't slip in any gear. Stop and go traffic in first gear is really the only time I notice it not disengaging. I can't pull it out of 1st gear when it happens so I have to shut the car off to get it out of first gear. When it's stuck in first gear with the clutch pushed in (on a flat surface) and I let off of the brake the car creeps forward. Not at full speed like if I were to release the clutch pedal all the way but its still semi engaged enough to make the car move.
Replacing everything theoretically should have fixed all issues, but it hasn't. The only thing I didnt replace was this piece of the factory clutch line.
Tomorrow I am going to take the stainless steel clutch line and run it straight to the clutch master cylinder bypassing that weird silver box and hope that fixes it. As a side question what does that silver box do anyways?
Golf/GTI VI :: Clutch Was Slipping When Hit Third Gear
So I have a stage 2 endurance clutch and light weight flywheel on my car. I had not really gotten on it of late until yesterday. I was getting on the highway and really got on it. When I hit third gear it felt like my clutch was slipping. I have only had it on the car for like six months and about 10,000 miles. It could be worn out all ready? And after the incident yesterday I pushed the clutch in and held it to let it cool down a bit after it did it held fine even in higher Rpms didn't feel like any kind of slipping. Pulled very strong. This morning after having all night to cool off (and I mite just still be freaked out a bit) but it seemed to feel different, like a possible slip at 3,000 Rpms but again I mite just be freaking out about nothing. What does a master cylinder or slave cylinder going out feel like?
View 1 RepliesGolf IV R32 :: Stuck In 3rd Gear - No Downshifting?
Yesterday I took the R out to grab some food on my lunch break. Didn't drive like a lunatic or anything, pulled into T-Bell parking lot and the car didn't want to downshift. Ok Weird. coasted in, parked, and put it in neutral and let out the clutch and the car stalled like it was still in gear. Go to leave and the car doesn't want to go into reverse. Thats when I realized something had gone seriously wrong.
Basically the car is stuck in 3rd gear. I can get the shifter to engage into reverse but the car tries to creep forward like I have the e-brake on. It doesn't go into any other gear but 3rd or 4th, but even when the shifter is in the 4th position its still in 3rd gear. Even when the shifter is in the neutral position its in 3rd gear. I limped the car home. I've looked into it a little bit and I'm leaning toward the 3/4 shift fork being broken. I know this won't be a cheap repair.
I think if it is the shift fork I will be upgrading the the one piece steel versions.
Golf IV R32 :: Whole Car Jerks - Getting Stuck In 5th Gear
Yesterday I jump on the freeway, shift to 5th and the whole car jerks. Happened again later that night. After that I was more focused when shifting to 5th and it hasn't done it since. Could it be this B&M short shifter that the last owner installed? I also noticed since day one that when the car is cold it doesn't like going into first sometimes, meaning I can't throw it all the way to the left and then up to get to first. It's more like a little to the left and then up but when the car is warmed up I can throw it all the way to the left.
View 3 RepliesGolf VI R :: Clutch Clicking While Shifting Between 1st, 2nd And 3rd Gear
Last couple morning here in Michigan we've seen temps in the low to mid 30's. The last two mornings when I shift between 1, 2 & 3 I'm hearing a clicking noise coming from the clutch when engaging the gear. After a few minutes, once it warms up, the clicking goes away.
I am @ stage 1+ W/VWR intake, but I'm not expecting clutch troubles from that.
Golf/GTI VI :: 2010 - Clutch Slippage In 6th Gear
My GTi has little over 18k on the clock and it will be a year old on Thursday. Coming back home from work last Friday i floored it @ around 3 rpm in 6th, and i got clutch slippage.
View 24 RepliesGolf/GTI VI :: Clutch Slipped A Bit On Highway In 6th Gear
I have a 2010 GTI and I got the APR 93 octane chip about 6000 miles ago. The other day I pushed the gas to pass a car on the highway in 6th gear and it sounded like my clutch slipped a bit. It made me quite nervous as the car only has 10,000 miles on it. I'm hoping maybe it just got glazed over a bit.
All of my other cars had manual transmission so it's not my driving skills and I don't beat on my car either. My last 2002 GTI had 150,000 miles on it when I sold it and 140,000 of those were chipped. Never once did that clutch slip.
Golf IV R32 :: Clutch Pedal Went To The Floor When Get It Into Gear
So my clutch has been acting up lately. When it sits for a few hours the clutch engagement point seemed to creep down but over the course of 35 minutes of driving would work its way back up again. Today it was unusually low and wouldn't let me get it into gear. I tried pumping it a few times and realized it wasn't coming back up all the way, I pulled it up and then tried again and it just dropped right to the floor where it now sits. Fortunately I was at work and can hang here until my ride arrives, and will just wait until late tomorrow night to drive it to my shop without stopping...
My guess is I need a new clutch master cylinder. I have plenty of fluid in there although its a bit old so I'll be changing that when I change the cylinder. Could it be the slave cylinder? If so is it a bear to change that? (do I need to drop the trans?)
Golf/GTI VI :: Drop In Clutch - 5th Gear Slipping
So I got my stage one flash yesterday and I noticed 5th gear slipping already. I don't plan on getting a k04 upgrade, maybe stage 2 down the road. so I am looking into the drop in clutches, preferably this one [URL] .... I am just trying to find out some reviews from people who are currently running drop in clutches and the issues that they have come across.
View 8 Replies