Golf VI R :: New Clutch - 1st Gear Stuck

Car: 2012 Mk6 Golf R
Mileage: 43,000 km
Software: UM stage 2 loaded

Related mods:
- diesel geek short shifter
- Emmanuel design, Sachs SRE stage 2 SMf clutch kit
- Tyrol sport deadest rigid collar kit (probably not related)

Background info:
Clutch installed at 40k km.
0-500km stop and go traffic
500-505km punched it bc a 350Z pissed me off*
506-1200km highway and not very aggressive twisters
1200-3000km hwy and city mix

First 0-500km I babied the clutch. No issue
501-505km I punched it a bit hard. Felt great. No issue
506-1200km hwy there, no issue. Closer to the 1200km mark the issue surfaced
1200-3000km was able to repeat the issue and adjusted diesel geek ss and re-bled the clutch in attempt to resolve it

Issue:
- from dead stop, 1st gear gets locked in at 2-4k rpm
- either I rev up beyond 4k, drop below 2k rpm to unlock it
- if I man handle n yank it out of 1st, gears grind
- only happens when the car is fully warmed up and fully running at optimal temperature for at least 10-15 minutes
- diesel geek ss readjustment
- re-bled the clutch (no topping off the clutch lines)

Issue was improved, however, I'm experiencing this locking issue again. Less frequent and less predictable. Attempted to replicate the issue, only happens if it's stop and go traffic-jam speed. Was unable to focus on an rpm range.

View 5 Replies

Golf IV R32 :: Whole Car Jerks - Getting Stuck In 5th Gear

Yesterday I jump on the freeway, shift to 5th and the whole car jerks. Happened again later that night. After that I was more focused when shifting to 5th and it hasn't done it since. Could it be this B&M short shifter that the last owner installed? I also noticed since day one that when the car is cold it doesn't like going into first sometimes, meaning I can't throw it all the way to the left and then up to get to first. It's more like a little to the left and then up but when the car is warmed up I can throw it all the way to the left.

View 3 Replies

Golf IV / Jetta IV :: Error Code - Car Stuck In 3rd Gear

Damn car is stuck in 3rd gear! Hooked up scanner and the screen just says error! I have to keep the scanner in the vehicle, hooked up, just to drive the car. That's just so it'll shift as its supposed to! Now it's not letting me pull the code out, in order for me to erase it! It just keeps saying "error".

View 1 Replies

Golf IV / Jetta IV :: 2003 - Transmission Stuck In 3rd Gear

I've had my 03 VR6 6-speed for 12 years. It's been a second car for the last 5 or so, but regularly used. Friday morning the car got stuck in 3rd gear. The stick will only move from neutral position and down towards 4th gear. I've inspected the short shifter under the hood and the bushings under the shift boot. I did not find anything that diesel geek (the short shifter company) had me check for.

I brought the car into a local shop I have never used before (my usual shop closed), and today they called me saying its a transmission issue. I have not given them permission to open anything up. I am going to take the car home for now.

I have had to repair a broken 1-2 gear fork before. And at that time I had the 3-4 gear for replaced as well.

I should also mention, I similar issues on a quick drive i took the car on the night before. I thought it was just me acclimating to the shifter/lower power of the car as I hadn't driven it for a while. The point is, it drove fine afterwards and it drove fine for a 40 minute city drive to work the next morning.

View 5 Replies

Golf IV / Jetta IV :: Shifter Got Stuck And Won't Budge Out Of 5th Gear?

I'm having an issue with my clutch and I'm really in a hole. Two days ago I was driving my car and everything was fine. Later in the day the shifter got stuck and would not budge out of 5th gear. Eventually it popped out. Driving like normal again and then yesterday I was on my way home from work and all hell broke loose. I was a mile away from my house and the car would not shift into any gear without a fight.

I also at this time lost my clutch pedal. It went really soft but did come back up.. it would not engage however. Limped it the rest of the way home and took a look at it. What I came across was a full brake/clutch reservoir, no leaks around the slave, and I didn't see any leaks around the master. I will say that after the car sat for about 10 mins the pedal felt normal again but quickly went soft after a few pumps.

2.0 AEG 5spd. Trans code DZQ if any of that would be relevant..

View 3 Replies

Golf IV / Jetta IV :: 2001 VR6 Manual Transmission Gets Stuck In 3rd Gear

I just picked up another GTi and knew the transmission was iffy when I bought it. I had to deal with the serpentine belt tensioner which is now new and also a new waterpump since it was wobbling.

I've already drained and replaced whatever oil was in there with VW G60 Gear Oil which is what my Dealer here told me to put in and it shifts smoother now but still has the same issue. I also did the Shifter Cable adjustment to see if that was the problem but that only made it easier to shift but it still got stuck.

Basically what happens is when driving I shift into 3rd gear and when I go to shift out of 3rd it comes out of gear but it's like it hits a brick wall and will not go into the home position. I was hoping the adjustment and new oil would work but it hasn't done anything.

View 2 Replies

Passat (B5) :: Hard Downshifting From 2nd To 1st Gear

My car is downshfting kinda hard from 2nd to 1st I guess, it's just before I stop. What's causing this? It's a 2002 V6 4Motion.

View 1 Replies

Touareg :: Bang When Downshifting From 5th To 4th Gear

I have been having this problem for the better part of a year, about 80% of the time when my transmission tries to downshift from 5th to 4th gear I hear a loud thud/bang which shakes the vehicle. The other 20% of the time the donwshift is smooth. I have tried manually shifting and get the same result. The problem does not seem to be getting worse. I have adjusted my driving and when accelerating in 5th gear at moderate speeds I accelerate just enough to keep tranny in 5th, so I don't get the thud.

View 4 Replies

Passat (B6) :: Rough Downshifting From 5th To 4th Gear

I've just had my 2006 B6 fixed last monday....something with throttle body , fuel pressure sensor and transmission "flashed" since it was downshifting rough from 5th to 4th. Today while cruising on the highway at first "open gas cap" showed up so i pulled over turned engine off then back on, light was gone, then on may way from work engine light came ON out of nowhere so i have another appointment to have them look at it this coming sat.

View 4 Replies

Passat (B5) :: 2000 V6 Shaking When Downshifting From 3rd To 2nd Gear

Just bought a 2000 passat v6. I have owned a 99 passat 1.8t for 5 years and has had little to no problems. When I first was driving my newer v6 I noticed that when im downshifting from 3rd to second especially it has shaking feeling in the front end. Wasn't sure if this was a transmission problem or an axle problem.

View 14 Replies

Elantra MD (2010-15) :: Downshifting From 5th Gear To 1st While Braking

The downshifting while braking is very obvious during braking, I can literally feel the gearshifts going down from 5th Gear to 1st as I brake. I have driven a wide range of cars but haven't experienced this earlier. Is there any modification that can be done or added to change this and make it smoother like usual cars?

View 28 Replies

Lexus IS 2014+ :: Two Beeps When Downshifting Into Second Gear

I've noticed that when I downshift into second gear, either going down a hill to augment braking, or setting up to take a corner quickly, I will occasionally hear two quick beeps (in the cabin) which are not very loud. This seems to happen when I'm using the paddles to downshift.

I assume that this is some sort of driver's aid, but for the life of me, I can't figure out what it's for.

View 4 Replies


Lexus GS 2013+ :: Transmission Clunk When Downshifting From 2nd To 1st Gear

Heard a clunk and then have the car feel like something from the inside is trying to stop it when using the paddle shifters in manual mode. Specifically when downshifting from 2 to 1. By the way I did a slight throttle blip, I have done this before with very smooth results but this time it really scared me, I though the transmission broke for a second; when the car did what it did.

View 6 Replies

Passat (B6) :: 2007 - Downshifting Around 2nd / 3rd Gear Is Pretty Hard

I have an 07 and in S mode the car does a pretty hard when down shifting around 3rd/2nd gear. if there is a fix for it? I'm going to talk to the dealer about to see what they say.

View 10 Replies

Chevrolet - Aveo :: 2007 - Cannot Get In Or Out Of Gear When Tried Downshifting On The Freeway

My wife's 07 Chevy Aveo was towed home Tuesday. She tried downshifting on the freeway and suddenly she couldn't get it in or out of gear. I was able to get it in all gears but the clutch engagement was all wrong. there didn't seem to be any slip zone, it just jumped at 1/2 pedal. I found the clutch master cylinder leaking slightly under the boot so I changed it and bled the system, no change. I had backed the car out of the garage onto the upward sloped driveway which required a lot of RPM's. Later I couldn't get it out of gear and cannot disengage the clutch, even to allow it to roll. I also changed the slave cylinder, still no luck. I changed the clutch, throw out bearing, and had the flywheel resurfaced last April.

View 19 Replies

Ford F-150 (2009-2014) :: Hard Downshifting Between 2nd And 1st Gear

My 2009 downshifts hard between 2nd and 1rst gear. Real distinct when stopping at a stop sign. I have 81,000 on it. I looked at older forum's and they said flashing the computer would assist. Just curious if it works for a vehicle with that many miles on it, or if it may be a more serious problem.

View 5 Replies

Golf IV / Jetta IV :: 1998 - Clutch Engages Lower To The Floor / Shifter Stuck In Gear

98 Jetta TDI hydraulic system ... We just received this vehicle from my mother in law, who is not driving any more. It's a cream puff--79,000 miles, beautiful condition. Problem is the clutch engages lower and lower to the floor, and eventually the shifter gets stuck in gear. The brake pedal slowly sinks to the floor when at stops on hills. Our mechanic tells us these two are connected because both the clutch and brake run off the same hydraulic system.

1st time he said the fluid was filthy, and he emptied the system and put in clean fluid. Worked for a little while and then we were back where we started. Second time he replaced a couple parts on the clutch, replaced this fluid, and this time it ran like a dream for a little over a month. Then the problem just returned. Again he says the fluid is filthy, and now we are looking at replacing the master cylinder and again changing the fluid. The theory behind why this is happening is that my mother in law let the car sit for half a year before passing it on to us. She didn't do much driving the 6 months before that either. I've done research, and this doesn't appear to be a common problem by any means on these cars.

View 2 Replies

Golf IV / Jetta IV :: 2000 - Limp Mode / Stuck In 1st Gear And Error Code Of P0730

I have 1 month left on my AAMCO rebuilt transmission. I took it in a few weeks ago when it went into "limp mode" (Stuck in 1st gear). Eventually, they got an error code of P0730, which I believe is electrical-related. All was pretty good but then today, driving @ high speed on the interstate, I could not get into 4th gear...

View 1 Replies