Golf IV / Jetta IV :: 1.8T 5 Speed Manual Transmission Won't Go Into 1st Gear
2004 Jetta 1.8T w/5 speed manual transmission. Bought the car this way, mostly for a parts car, but everything else runs and drives good, so if it wasn't for this issue it would be a decent driver.
Won't/can't select first gear. Seems like there is no "spot" for first, or that the shift mechanism has no where to go., locked out. All the rest of the gear selections work perfectly. Tried the cable adjust ritual, but it was fine-as I suspected. The shift assembly works/moves perfectly from the tranny end and the shift lever end. Not a synchro, it won't go in stopped, moving, running or shut off.
So, what's the probable best guess or best way to come to a diagnosis? Shift tower parts broken somewhere, or something like a shifting fork bent broken? Seems like if it was internal there would be other gear selections that would be affected. Any links to some diagrams?
Golf IV / Jetta IV :: 2001 VR6 Manual Transmission Gets Stuck In 3rd Gear
I just picked up another GTi and knew the transmission was iffy when I bought it. I had to deal with the serpentine belt tensioner which is now new and also a new waterpump since it was wobbling.
I've already drained and replaced whatever oil was in there with VW G60 Gear Oil which is what my Dealer here told me to put in and it shifts smoother now but still has the same issue. I also did the Shifter Cable adjustment to see if that was the problem but that only made it easier to shift but it still got stuck.
Basically what happens is when driving I shift into 3rd gear and when I go to shift out of 3rd it comes out of gear but it's like it hits a brick wall and will not go into the home position. I was hoping the adjustment and new oil would work but it hasn't done anything.
Golf IV / Jetta IV :: Manual Transmission Fluid Change On Older MK4?
So I recently bought my 03 VW Golf TDI, and have it in the shop this morning to get the wheel alignment done, balance my winters, fuel/cabin filter changed, as well as an oil change. I am now wondering whether or not to give them a call to change the transmission oil as well...
But.. the vehicle has alot of km's on it (358K) and I keep reading that it would do more harm then good? Is this true? Doesn't make any sense to me, but the car could shift more smoothly I think if I do it, and I have yet to see any tran fluid change in the previous owners records in quite some time..
Jetta - Volkswagen :: Manual Transmission - Can Only Use 2nd / 3rd And Reverse Gear
93000 miles 5 speed manual transmission only lets me use 2,3 and reverse gear. I took good care of that car and dont think transmission should go out that soon/
View 7 RepliesVolkswagen - Jetta :: 07 2.5 With Manual Transmission - Engine Rpms Surge
Why does my engine rpms surge from 1k to almost 3k when i put it in neutral or push my clutch in ?
It's an 07 2.5 jetta with manual tranny...
Jetta - Volkswagen :: 2003 - Manual Transmission Stuck In Neutral
My car is a 2003 Volkswagen Jetta GLI, I was on my way somewhere when slowing down i put my car in neutral and began braking. Going faster than i thought i shifted into first gear at about 40mph. At that moment i felt rattling in both the gear stick and the clutch pedal, i tried to shift again in case it was just a hiccup and my gear stick was stuck in neutral, i couldn't switch into any gears.Now when my car is off is the only time i can move the gear stick into the gear slots. And i also lost a lot of pressure in the clutch pedal but it does not stick to the floor it returns to normal position after a moment or so.
View 6 RepliesJetta - Volkswagen :: 2009 - Manual Transmission Hard To Shift
Long time listener first time poster. My wife has a 2009 Vw jetta 2.5 with a manual transmission that is very hard to shift. It has 80,000 on it and has had the clutch replaced once. She told me that she never had any problems shifting until she let it sit for two weeks while she went to cape cod. I have driven it myself and can confirm that there is an issue. Sometimes it just will not go into gear. No grinding noise at all and very very stiff when moving the stick shift laterally from first to fifth. Not actually shifting from 1-5 just moving the stick across the range it feels like cement. I have already changed the transmission fluid and used the Vw oem oil. I also removed the shift boot and lubed all the moving parts with a high quality grease. Tomorrow I am going to bleed the clutch slave and have a good look at the shift linkage. Is their something I am missing?
View 5 RepliesJetta - Volkswagen :: Manual Transmission - Hard To Shift Between Gears
I went on vacation for a week and left my car at my parents house. I came back and now it has become extremely difficult to shift between gears. It's nearly impossible to get the car into reverse, extremely difficult to get it into first, makes a thud when pulling it out of first, is semi difficult to get into 2nd, but only a mild nuisance to get into 3rd through 6th.
For more information, the car is a 2012 Volkswagen GLI with just shy of 40,000 miles. The car ran just fine before I went on vacation and the car was not moved while I was on vacation. I did notice that a little ticking kind of sound when I had the car in neutral with no clutch. So the throw out bearing was starting to wear, but it was a very slight. But I haven't had any other problems.
Golf/GTI VI :: 6th Gear RPMs For Manual Transmission
What RPMs do you see in 6th gear, say at 60mph or 80mph? Consumer Reports claims the RPM at 60mph is 3020!
So I went to vw.com to look at the gear ratios for a reality check. The site lists two final gear ratios for the manual. "Final I" is 3.94 and "Final II" is 3.09. When do you get one versus the other? With a final gear ration of 3.09, I get roughly 2400RPM at 60mph. But with a ratio of 3.94, I indeed get about 3000RPM at 60mph or 4100RPM at 80mph!!! That's absolutely insane.
Golf/GTI VII :: Grunt From Manual Transmission On Upshift
About 1500 miles on my GTI and I have been noticing on upshifts, just as I release the clutch, I get a short grunt from the transmission. It's very brief, but consistent in lower gears. it's not terribly loud (may not hear it with the radio on but definitely will with the radio off).
It doesn't seem to impact the drive at all so I'm not stressing about it but I will want it looked at if it poses a risk to the drivetrain... Never had anything like it with my last stick ('02 e46).
Golf IV / Jetta IV :: 1.8 / 5 Speed Manual - First Gear Won't Turn On
I have a 1.8 Jetta and I realized yesterday that my first gear won't turn on what could be the problem..
View 5 RepliesGolf IV / Jetta IV :: 2002 GTI / Manual Shift - No Reverse
When you sit in the car and put it in reverse it wont go in.
If you stick your hand in the engine compartment, push down on the golf club looking linkage and shift it into reverse it goes right in and you are able to back up the car.
So my question is which linkage may need fixing or replacing or adjustment. The shifter linkage in the car? the linkage on the golf club thing or any parts in between.
Golf IV / Jetta IV :: Lost Reverse On Mk4 Manual 5spd
My Mk4 Tdi Golf has a couple of times lost reverse gear. It has the 5 speed manual box, and I found that the gear change mechanism on top of gearbox seemed to have a plastic channel to keep a vertical shaft inside a round housing.
I'm finding it difficult to describe, but I have managed twice to push it back down after quite a struggle, and reverse gear change worked for a while.
Golf IV / Jetta IV :: Manual Shifter Hangs Up And Won't Self Center In Neutral?
It's been going on for awhile now...shifter hangs up to one side or the other instead of self recentering when put in neutral. I have checked the interior and there is no dirt of grime on the white nylon ball that the shifter floats on and it was also lube with some white lithium spray (liquid wrench). Checked under the hood. All connections are good and solid and free from any obstructions. Trans fluid was changed 10k miles ago. Not sure what else to check.
View 3 RepliesGolf IV / Jetta IV :: Noisy Manual Trans In Reverse / Whining In 1st And 2nd Gear
I have an 04 Jetta 1.8T that I recently acquired and have a problem with a noisy manual tranny. Reverse is a bit noisy (more than usual) and when I get on it in 1st and 2nd gear it sounds like an awful whining noise. I have been told it could be either a bad throw out bearing or input bearing? BTW this thing shift perfect, like butter, no grinding at all.
View 4 RepliesGolf/GTI VI :: Manual Transmission - Rattling Noise When Clutch Pedal Is Not Engaged
I currently own an mk6 gti with a manual trans... as of late I've been noticing a rattling noise when the clutch pedal is not engaged.. once engaged the rattling stops completely .. it seems to be getting louder and louder .. I am worried this could eventually turn into something worse than just a rattling noise .. i had a friend mention it could be the "throwout bearing" ..
View 9 RepliesGolf/GTI VI :: Manual Transmission - Shift From 3rd To Neutral (bypassing 1st And 2nd) When Coming To A Stop?
On a manual car, I know it's not the best thing to go from neutral, completely bypass 1st gear, and shift to 2nd gear. As well as 3rd to 5th bypassing 4th. However, is it the same for downshifting into neutral or another gear? Will it hurt the transmission to go from 3rd to neutral (bypassing 1st and 2nd) when coming to a stop? I do know that shifting from 4th to 2nd gear and bypassing 3rd will harm your tranny. I just want to double check if I'm right...
View 24 RepliesGolf IV / Jetta IV :: 2001 / VR6 - Water In Gas
I just bought a 2001 Jetta with a VR6 with water in the gas. So far I've drained the tank (got probably 20oz of water out of the 3gal of gas) and put in fresh gas, replaced the fuel pump and the spark plugs. When I disconnect the return line I'm now getting nice clean gas but it will not fire. Although it will fire on ether. Anything else i should do? I have the full version of VCDS and am not getting any codes.
View 2 RepliesGolf IV / Jetta IV :: Water Leak Into Cabin
While washing the Tdi lately I've noticed water leaking into the cabin from a point just overhead the dead pedal. Where this leak may be originating from?
View 6 Replies