Passat (B5) :: Brake Wear Sensor Keeps Going Off?
My brake wear sensor keeps going off even though my brake pads are fine. I guess there is a short in the line somewhere. I know you can loop the indicator at the brake pad but if I have a short in the line this will not work I have had someone look for the short but after a couple hundred dollars they were not successful. Can you have the dealer turn off this indicator in the computer so it no longer reports the status of your brake pads?
View 2 RepliesGolf IV R32 :: Automatic Windows Connected To Rain Sensor?
Any way to connect the windows to roll up if the rain sensor detects rain drops? Just thinking that this would be a nice cool feature to have if there is a way to do it.
View 12 RepliesGolf/GTI VI :: Uneven Front Brake Pad Wear - What To Do
I noticed this yesterday when swapping out my wheels. What could be the causes?
Pass side
Drivers side
Golf V R32 :: Front Brake Discs Wear Out Differently
My R32 is ~5700 miles and today I realized that Front brake discs wear out differently. Left one is OK but right one is scratched more deep and different than the left one. So they are not equal.
View 5 RepliesCamry :: 2008 - Squirrels Eating Wire Connected To Sensor?
I have a 2008 XLE Camry. I have/had problems with squirrels eating wiring in my vehicles. I checked my Camry the other day and noticed the wires were eaten off a sensor.
The damaged connector is behind the engine cover and located on the left side of the black plastic cover directly behind the engine cover.
The connector is white plastic, has two thin wires black and black/white. This connector is attached to a large yellowish nylon base on the end of this black plastic cover between the engine cover and firewall.
What is the purpose of this connector. Everything works on the car although gas mileage dropped off about 2, which could be attributed to this winter blend ethonol.
Ford Aerostar :: Uneven Brake Pad Wear / Increased Brake Dust On Wheel
97 4.0 ext. As the title says the right front pads wear more than the drivers side. Have replaced calipers pads and rotors during recent overhaul. Noticed increased brake dust on wheel on rf front. Could the metering valve under master cyl be the culprit. Abs and brake lights work as normal.
View 4 RepliesAccent MC (2006-11) :: Noisy Front Brake Calipers
Since I have this car i noticed that the brake calipers (especially the front) are very noisy. This problem is caused by caliper's floating guides that become loose and the entire brake caliper shakes. I asked at a kia mechanic who answered to me to change the calipers support. For my trusted mechanic is useless because, according to him, this type of support have this problem (he tell me that also others car have this problem like older nissan micra) and sooner or later would return noisy.
Some time ago with greasing the floating guides i temporary solved but drying up over time the problem come back.
5 Series :: 1992 - Front Brake Calipers Locking Up
Fairly recently acquired 1992 525i, 101,000 miles. Love the car and driving feel, don't mind putting the effort in but do not know where to start. She needed some work including both upper and lower control arm bushings. Replaced those over the last couple of weekends. This week the front brake calipers are locking up adding significant drag to the car, overheating the front brakes, smells and feels hot. Rear brakes appear to be fine. Seller had replaced brakes within the last 5,000 miles. I thought maybe he did not 'grease' the caliper guide pins and components, so I tried that and all was well for a few miles then back to the same locking brake calipers.
Is this brake caliper, brake cylinder, master cylinder or ABS related? Do I need to bleed the system? I cannot not imagine how but could replacing any of the front suspension components have had anything to do with this? I read on one thread about an interconnection (power assist) provided by the power steering pump and that 'over filling' the PS reservoir could cause such a problem. I did add fluid to the reservoir recently but the level is between the marks on the cap dip stick.
If caliper, or cylinder related is this DYI? How about the ABS? I have been looking for some good links to address this problem and repair procedures but no luck as yet.
Ford Excursion :: 2002 - Brake Calipers Seizes Too Often
I have two 2002 ford Excursions, both with 7.3, one 2WD and one 4WD. I have replaced ALL brake calipers with lifetime warranty Napa semi-calipers. It is sometimes an intermittent problem, I might have smoking brakes on one wheel (mostly the rears) one day and it will work fine for weeks or months and then do it again. It seems that about 1X per year I end up having to replace the calipers as they seize up and cause the brakes to smoke and cooks the caliper piston boot to a crisp.
I use high temp brake caliper grease (not sure if it is silicone based) and bleed the brake system about 1X per year because I thought the brake fluid was absorbing too much moisture. The slide pins come pre-greased, but I always check and re-grease them. Could I be putting too much grease onto the slide pins, Hydrolock?
I live in high humidity, in the middle of a rain forest near (about 5 miles away) a live volcano, Kilauea, on the island of Hawaii. Our area is very wet and we have acid raid and acid air (H2SO4 volcanic smog in the air) which corrodes everything, corroded pistons getting stuck?
I have not tried other brands of calipers because I cannot afford to keep buying new brands, I just trade in the toasted calipers at Napa for no charge. I have replaced all the rubber brake hoses and i upgraded to DOT4 (not silicone based) blue racing brake fluid that has a very high wet and dry boiling point. I am thinking of investing in stainless steel calipers, but those are pricey.
Touareg :: Brake Squeaking - Calipers Does Not Fully Disengage From The Rotors
After coming to a complete stop & starts driving again, I notice that the brakes squeaks a few turns & then stops. It seems that the brake calipers does not fully disengage from the rotors.
2006 Touareg V6 Silver
IS F (2008-2014) :: Cleaning Brake Calipers Without Removing The Wheels?
I just noticed that my black brake calipers look dull. I used my finger to check it and behold, the shine is back. Is there anyway i can clean the brake calipers without removing the wheels?
View 13 RepliesSanta FE SM (2001-06) :: Fast Rusting On Front Brake Calipers?
I've replaced the front brakes twice now on my 2004 2.4L Manual Santa Fe.
Each time the dealership has commented on some excessive rusting of the calipers, and this last time around one had actually seized and they had to cut it off.
When I got brand new ones put on I noticed they were nice an shiny silver. Within 3 weeks there were full rusted...and still are. I don't get it??
2004 Santa Fe .... Is it possible something is dripping from somewhere that is caused this premature rusting?
Lexus GS 2006-11 :: GS430 Front Brake Calipers To GS300 AWD
Tons of information on this and its possible. What? I'm still learning the search feature.
View 1 RepliesPrius (2010-12) :: Brake Pads Rattling In The Calipers When Hit Bump
Gen III 2010, 6800 miles. Silver. Fuzzy dice. Pads are still rattling in the calipers when I hit bump when foot is not on brake. It sounds like hell! ...like major suspension components are loose, although I know they are not. Two Toyota dealers have told me this is normal, and no danger. ...no dealer fix.
View 7 RepliesFord F-150 - 1997-2003 :: Sticking Front Brake Calipers
I have a 99 150 4 wheel drive..5.4 ..auto...110.000 mile.....notice when driving in town in hot weather....when you are on and off the brake petal a lot....stop and go..etc.....the truck starts to hop or bounce....some....I got out ..and notice the right or passenger side front brake seems a lot hotter than the drivers side......but ...when it does that....the steering wheel doesn't pull to one side...when changing pads before ..notice no one side worse for ware than other...thinking it must be sticking brake calipers....they don't do this say on interstate driving even when on and off the petal some...
View 1 RepliesFord Excursion :: Vibrating Rotors - Brake Calipers Replacement
Front caliper replacements--fwd? Person I bought this from said they'd just relined the brakes before I got it. After having it a week, I randomly checked torgue on lug nuts...a whopping 80 ft lbs. So now I have the vibrating rotors. When I back up I hear scraping like a bad set of bicycle brakes against an out of round rim. The pads are pretty thick. I bought new rotors and pads but I wonder if I shouldn't get calipers as well. This X likes to bite me in the butt--something simple is always about 5 times more complicated than anticipated.
View 1 RepliesPrius (2010-12) :: Brake Calipers Noise When Hitting Road Bumps
So my several month old Prius II has developed a metal on metal sound when I'm hitting various road bumps.. it's a "clack" sound emanating from my wheel well area that is heard when the windows are down.. I've taken it in twice and the first time they couldn't figure it out... second time they said they drove mine and a brand new Prius which also has the same sound and said it was the brake calipers. Funny thing is, I never heard this noise until after about 2k miles on my car.. They also would NOT disable my reverse beep sound or seat belt beep saying it was a safety feature and shouldn't be disabled.
View 19 RepliesFord - Mustang :: 2001 - Brake Malfunction - Front Calipers Won't Release
I have a 2001 mustang GT. I have 2 front calipers that are sticking. I changed both calipers twice, new brake hoses, bled all the wheels and the master cylinder. Why the calipers won't release?
View 19 RepliesGTI 337/20th Anniversary :: Calipers Making Clanking Noise - Brake Stiffening Kit?
So I noticed a few months ago that a clanking noise came from the front of my GLI when I hit bumps. This noise went away if I had my foot on the brake, so enough vortex searches came up with loose caliper carrier pins.
I ordered the brake stiffening kit last month, but have yet to install it. Now just the other day, I heard this crazy noise come from my brakes entering my garage. It was like a loud 'click" when I engaged the brakes hard enough and I could repeat it many times. I know, I am silly for not getting the kit installed sooner, but I want to make sure that this 'click' is likely related to the carrier pins before I go taking the brakes apart in my garage.
I only ask because my car has 95k on it and is possibly on original suspension, so bushings and mounts might be starting to go.