Lexus GS 2006-11 :: GS430 Front Brake Calipers To GS300 AWD
Tons of information on this and its possible. What? I'm still learning the search feature.
View 1 RepliesAccent MC (2006-11) :: Noisy Front Hub Bearings
2009 accent sedan has had an issue with noisy front hub bearings? I had my Accent in for an alignment today and also had the shop check for a humming noise that seemed to be coming from the front end. The humming varied with speed. The technician said it was a noisy hub bearing. He said that the bearings were both tight and had no play in them. I was told just to monitor the noise, as the bearings were tight. Just had the transmission fluid changed too. (Used genuine Hyundai fluid) The noise doesn't seem to be transmission related, as the transmission shifts perfectly with no noise. Also, the level of the noise changes on turning the wheel in either direction.
View 3 Replies5 Series :: 1992 - Front Brake Calipers Locking Up
Fairly recently acquired 1992 525i, 101,000 miles. Love the car and driving feel, don't mind putting the effort in but do not know where to start. She needed some work including both upper and lower control arm bushings. Replaced those over the last couple of weekends. This week the front brake calipers are locking up adding significant drag to the car, overheating the front brakes, smells and feels hot. Rear brakes appear to be fine. Seller had replaced brakes within the last 5,000 miles. I thought maybe he did not 'grease' the caliper guide pins and components, so I tried that and all was well for a few miles then back to the same locking brake calipers.
Is this brake caliper, brake cylinder, master cylinder or ABS related? Do I need to bleed the system? I cannot not imagine how but could replacing any of the front suspension components have had anything to do with this? I read on one thread about an interconnection (power assist) provided by the power steering pump and that 'over filling' the PS reservoir could cause such a problem. I did add fluid to the reservoir recently but the level is between the marks on the cap dip stick.
If caliper, or cylinder related is this DYI? How about the ABS? I have been looking for some good links to address this problem and repair procedures but no luck as yet.
Santa FE SM (2001-06) :: Fast Rusting On Front Brake Calipers?
I've replaced the front brakes twice now on my 2004 2.4L Manual Santa Fe.
Each time the dealership has commented on some excessive rusting of the calipers, and this last time around one had actually seized and they had to cut it off.
When I got brand new ones put on I noticed they were nice an shiny silver. Within 3 weeks there were full rusted...and still are. I don't get it??
2004 Santa Fe .... Is it possible something is dripping from somewhere that is caused this premature rusting?
Ford F-150 - 1997-2003 :: Sticking Front Brake Calipers
I have a 99 150 4 wheel drive..5.4 ..auto...110.000 mile.....notice when driving in town in hot weather....when you are on and off the brake petal a lot....stop and go..etc.....the truck starts to hop or bounce....some....I got out ..and notice the right or passenger side front brake seems a lot hotter than the drivers side......but ...when it does that....the steering wheel doesn't pull to one side...when changing pads before ..notice no one side worse for ware than other...thinking it must be sticking brake calipers....they don't do this say on interstate driving even when on and off the petal some...
View 1 RepliesFord - Mustang :: 2001 - Brake Malfunction - Front Calipers Won't Release
I have a 2001 mustang GT. I have 2 front calipers that are sticking. I changed both calipers twice, new brake hoses, bled all the wheels and the master cylinder. Why the calipers won't release?
View 19 RepliesLexus LS 2007+ :: Noise From Front End / Brake Area When In Reverse Like Calipers Are Loose
Heard clunk (technicdal term) noise when you are in reverse and press the brake pedal. It is coming from the front end/brake area. I did not see a service bulletin for this.
View 10 RepliesAccent MC (2006-11) :: 2008 - Front Brake Chirp Noise
I've got a strange noise coming from the front brakes. It's not the wear indicator, and it's not a worn out rotor.
When I apply the brakes firmly, they work great. No noise, good stopping power, the pedal is nice and firm. As soon as I let off the pedal, there's a little chirping noise, like a tiny bird in my wheels... I've looked at the pads and rotors, and there's no obvious sign of damage or wear.
My guess is it's the caliper pins or piston making the noise. I'm happy to take it apart and lube it, but what kind of lube is specified for this? Moly grease? Lithium grease? Some kind of oil? And do I apply it only to the caliper pins, or to the piston as well?
I looked on HMA service, but I can't seem to find anything to address this specific problem.
Accent MC (2006-11) :: Noisy Clutch And Brakes
I am getting a lot of noise from the clutch and brakes on my 2008 accent.
First the clutch: the noise is coming from the clutch release cylinder under the hood, at the front of the engine bay. I've tried lubing the cylinder, but it didn't work. Is there something else I can try, or do I need to replace the release cylinder to get back to a quiet clutch? Would a rebuild work? Is it even possible to get a kit to rebuild a clutch release cylinder?
I checked the hmaservice website, but the troubleshooting didn't have any mention of the clutch noise. I've seen plenty of references online to people having similar problems, but I haven't found any specific solutions (besides the standard "take it in and get it fixed" response). I'd love to take care of this problem without going to a garage.
That's been going on for a while, but the brake noise is new. It's a squeak noise that happens only as I release the brakes when the car is standing still. It's fairly quiet now, but I want to make sure that it's not going to lead into a bigger problem down the road.
I've done plenty of disc brakes in the past, but I've never worked on drums before. I'm not even sure if the noise is coming from one brake or all four. My best guess is that it might be the caliper pins that need to be lubed, but that's a complete shot in the dark guess...
What should I be looking for when I try to diagnose and solve this annoying noise. Is it something typical that happens with drums?
Accent MC (2006-11) :: Power Steering Pump Become Increasingly Noisy
I have a 2009 Accent GLS. The PS pump has become increasingly noisy, especially when the car is first started and when the steering wheel is turned. The noise is coming from the belt and when it does this it looks like the PS pump slows down and the belt is being forced through by the water pump. I bought a new/remanuf pump; however, the PS pressure switch thread diameter is smaller than the hole in the new pump and does not fit.
I took it back and tried another pump and same problem. Looking at a pump on RockAuto, A-1 CARDONE 215473 {#571001E000, 571001G000}, this one shows a plug with a slot in the hole where the switch screws in. I am at a loss with replacing the pump when I cannot seem to find what the car came with.
Accent MC (2006-11) :: 2009 - Noisy / Grinding Rear Brakes
My read brakes have been grinding. I bought new pads to replace them. After pulling the drums I noticed that they were hardly worn. 50,000 miles on the car. They was a bunch of brakes dust in them. Cleaned the dust out and put the drums back on. It was quiet for about 3 weeks, now the grinding is back.
View 3 RepliesAccent MC (2006-11) :: Noisy Rear Seats On Shift And Bump
Experienced rattling rear seat? Basically every shift and bump the rear drivers side back seat makes a very annoying rattling sound. It seems to be coming from where it latches on. I was thinking of taping the metal hook thicker so it would be tighter on. What to do to rectify it?
View 10 RepliesGTI 337/20th Anniversary :: Front End Noisy - Brake Pads Rattling
Having trouble with front brake pads rattling? About a month ago, I replaced pads - rotors - caliper pins on my 20th GLI. I know these cars ride a bit stiff but it sounds like my front end is about to fall off. All brake parts were torqued to spec - I've gone through all T25/T30 torx front end screws etc and I just can't find the rattle??? This has only started within the last few days. Any other places to check for obvious loose bolts etc?
View 15 RepliesFord Excursion :: 2002 - Brake Calipers Seizes Too Often
I have two 2002 ford Excursions, both with 7.3, one 2WD and one 4WD. I have replaced ALL brake calipers with lifetime warranty Napa semi-calipers. It is sometimes an intermittent problem, I might have smoking brakes on one wheel (mostly the rears) one day and it will work fine for weeks or months and then do it again. It seems that about 1X per year I end up having to replace the calipers as they seize up and cause the brakes to smoke and cooks the caliper piston boot to a crisp.
I use high temp brake caliper grease (not sure if it is silicone based) and bleed the brake system about 1X per year because I thought the brake fluid was absorbing too much moisture. The slide pins come pre-greased, but I always check and re-grease them. Could I be putting too much grease onto the slide pins, Hydrolock?
I live in high humidity, in the middle of a rain forest near (about 5 miles away) a live volcano, Kilauea, on the island of Hawaii. Our area is very wet and we have acid raid and acid air (H2SO4 volcanic smog in the air) which corrodes everything, corroded pistons getting stuck?
I have not tried other brands of calipers because I cannot afford to keep buying new brands, I just trade in the toasted calipers at Napa for no charge. I have replaced all the rubber brake hoses and i upgraded to DOT4 (not silicone based) blue racing brake fluid that has a very high wet and dry boiling point. I am thinking of investing in stainless steel calipers, but those are pricey.
Touareg :: Brake Squeaking - Calipers Does Not Fully Disengage From The Rotors
After coming to a complete stop & starts driving again, I notice that the brakes squeaks a few turns & then stops. It seems that the brake calipers does not fully disengage from the rotors.
2006 Touareg V6 Silver
IS F (2008-2014) :: Cleaning Brake Calipers Without Removing The Wheels?
I just noticed that my black brake calipers look dull. I used my finger to check it and behold, the shine is back. Is there anyway i can clean the brake calipers without removing the wheels?
View 13 RepliesGolf/GTI VII :: 2012 - Brake Pad Wear Sensor Not Connected To Calipers?
I was cleaning my brake calipers and noticed that neither of my calipers have pad wear sensor connected to pads.
My 2012 GTi had sensor on the inner pad, but I cannot find one installed on my MKVii GTI. Looking for a photo of the caliper and the location of the sensor?
Prius (2010-12) :: Brake Pads Rattling In The Calipers When Hit Bump
Gen III 2010, 6800 miles. Silver. Fuzzy dice. Pads are still rattling in the calipers when I hit bump when foot is not on brake. It sounds like hell! ...like major suspension components are loose, although I know they are not. Two Toyota dealers have told me this is normal, and no danger. ...no dealer fix.
View 7 RepliesFord Excursion :: Vibrating Rotors - Brake Calipers Replacement
Front caliper replacements--fwd? Person I bought this from said they'd just relined the brakes before I got it. After having it a week, I randomly checked torgue on lug nuts...a whopping 80 ft lbs. So now I have the vibrating rotors. When I back up I hear scraping like a bad set of bicycle brakes against an out of round rim. The pads are pretty thick. I bought new rotors and pads but I wonder if I shouldn't get calipers as well. This X likes to bite me in the butt--something simple is always about 5 times more complicated than anticipated.
View 1 Replies