Ford Super Duty (1999-2016) :: F350 - Coolant Leaking At The Front Seam
I recently did the water pump and hoses due to seeping around the water pump gasket. While there, I decided to replace the overflow reservoir as well - old and slightly discolored. I'm now on my 3rd overflow reservoir - they are all leaking at the front seam. I don't think I have a blown headgasket or injector issues - no signs of white smoke ever, and there isn't any oil or fuel in the coolant. I've also tried a new cap, but it's starting to leak before I build any noticeable pressure - I can back off on the cap and don't get much pressure released. So - just bad luck on parts from Ford? All were OEM from different Ford dealers.
Pics - hard to see on here but go to Imgur to zoom in. [URL] ...
1999 F350 7.3 CCLB Dually. Stock except for DP Tuner and Gauges.
Ford Super Duty (1999-2016) :: 2012 F350 - Front Brake Replacement
Any good info on front brake replacement parts to get better braking out of these beasts? My pads are now needing replacement but I would like to get better performance than that of factory parts....
View 1 RepliesFord Super Duty (1999-2016) :: F350 V10 - Leaking Coolant From Rear Of Engine
My grandfathers 99 F350, started suddenly, do not know if it was while sitting or while driving. Its more of a stream than anything else. Coming from the rear, cannot see where, appears to be toward the vee of the engine, not inside the bellhousing. The firewall insulation is damp from coolant. Doesnt start until engine starts warming up.
Is there something commonly replaced back there? Didnt want to yank the intake in 20* weather for exploratory surgery. Is not the heater hoses. Idk if the EGRs are cooled on these, thats about my only idea other than freeze plug, coolant tests good down to -20ish, hasnt been below zero in weeks (prior to leak). Not familiar with any of the modular engines.
Ford Super Duty (1999-2016) :: 2012 F350 - Hellwig Front Sway Bar Installation?
Installing the Hellwig 1 1/4 inch Front Sway Bar on their 11 and up F250 or F350 SRW Pickup?
My 2012 F350 Super Cab LWB XLT 6.7L seems to have quite a bit of sway in the front end. This is especially true moving slowly such as turning into service stations or other off angle turns. The truck only has the FORD OEM puny Rear Anti Sway Bar but the front seems to accentuate sway. The Truck has Rancho 9000XL Shocks, Timbren Enhanced Suspension System as well as Torklift Quick Release Stable Loads in the rear.
The Truck I have is not overloaded but it does carry an Eagle Cap 950 Camper pretty much full time. True the Campers now days are tall so some sway is expected. I just want to reduce the apparent front end sway and wonder if others have used the Hellwig Sway Bar in the front.
Ford Super Duty (1999-2016) :: 2003 F250 - T-Stat Stuck / Puking Coolant In Front Of Engine
I have an 03 F-250 6.0 Lariat with almost 200,000. The other day my t-stat started sticking and popping at 220 and then would go back to normal. Now it won't pop and it's puking coolant in the front of the engine. Would just a bad t-stat cause this or do I need to do my water pump as well.
View 1 RepliesFord Super Duty (1999-2016) :: 2003 F350 - Fuel Smell In The Cab?
I have a 2003 F 350 Diesel. When the heater is on, I can smell diesel fuel through the vent. This happens mainly when I am at a stop sign and the fan is on high. I did some research on this forum and found some others with a similar problem. The question I have is it seems like some said it was the cracked injector cups or a leak at the reservoir on top of the motor where the filter is. What I wasn't sure of was the symptoms. If it is a crack injector cup, would the smell be all the time and not just when I am stopped at a stop sign? Or would it be intermittent as well? It is definitely not exhaust smell. It smells like fuel. If it is the gaskets in the reservoir, I think I will do the blue spring replacement cause that seemed to improve a couple things based on the treads of the forum. I do see drips on the pavement every once in a while at the front of the truck towards the passenger side of the truck. Not all the way to the side near the tire, but off center on the passenger side. Is there anything that could be leaking fuel on that side of the motor?
View 4 RepliesFord Super Duty (1999-2016) :: F250 V10 - Smell Coolant When Heater Is On
I got my 1999 f250 super duty v10 about a month ago. It had 200,700 some miles on it. It's now at 201,865. My issue is when I turn on my heater I smell coolant. It's kinda strong. No leaks that I can see. Not in the ground or in the cab or from what I can see of the heater core. It only smells when the heat is on, no smell on the cold setting. It sat for months before I bought it from a dealership. What it could be? Ok now it sounds like I have the ticking death sound. The one people have said happens when spark plugs are about to fail. So I guess new plugs are in order.
View 8 RepliesFord Super Duty (1999-2016) :: 2012 F250 - Oil Dripping On The Underside Of Front Of Engine
Ok so I bought this 2012 f250 and I had a couple questions.
1. I checked the Frame for rust n it was fine. I didn't look at the other parts until I got it home. It does have some light to moderate rusting on other areas under the engine compartment. Ex axle, drive shaft, some of the steering components. Exhaust Manifold is pretty rusty though. What can I do about that?
2. I noticed a little bit of oil, not dripping, on the underside of the front of the engine. I do have an extended warranty so i hope it will cover that. It's pretty extensive of a warranty. I took some pics of the area where there is oil. What could it be?
Most of the oil is focused around there ...
Top down view ...
Ford Super Duty (1999-2016) :: Coolant Smell After Driving / Radiator Leak
About a week ago I began smelling coolant after driving my 2012 F350 6.7. Yesterday I noticed a small amount of coolant on the ground and decided to take it to the dealer. As soon as I told the Service Manager what was going on he said......"You need to leave it......there is no doubt in my mind it needs a radiator". They pressure tested and and sure enough it does. He said they are replacing about 2-3 a month but there is no recall.
Here is where it gets fun. Apparently radiators fall off at 36,000 miles and are not included in the 100,000 Power Train Warranty. It gets better. The Radiator is on national back order for 5-6 weeks.
Ford Super Duty (1999-2016) :: 2003 F350 - Minor Coolant Leak
03 f350 5.4. Very minor coolant leak at the moment. Valley behind water pump looks a little damp and leak has shown a little on the passenger side block above the starter. Shows on the tranny bell housing and hits the y pipe every once and a while. I am thinking its the hose that runs under the intake manifold but wanted to check in here for some wisdom. Can it be bypassed or rerun without pulling everything.
View 12 RepliesFord Super Duty (1999-2016) :: 1987 F350 - Coolant Leaking Regularly?
I'm a total beginner and am slowly nursing an '87 F350 7.5L back to running condition as a plow/farm truck. It regularly loses coolant, even on very short trips around the farm and I figured that radiator needed to be replaced. Today I was hooking a snow plow up and had it running for about 15 minutes when light grey smoke started to come out of the vents in the cab. Looking at the engine, I noticed a lot of coolant leaking out from below the heater housing. The coolant was dripping out of what looks like a protruding bit of pipe a where a hose should be attached. What am I looking at here?
View 4 RepliesFord Super Duty (1999-2016) :: 1997 F350 - Coolant Being Instantly Over Pressurized
I have a 1997 F350 460 7.5 automatic two wheel drive. I am having a sudden issue with the coolant being instantly over pressurized. Even when the engine is cold and I start it for a minute and then shut it off, the coolant comes under great pressure. I noticed this starting when coolant was being forced out of the overflow reservoir. The truck does not overheat.
I changed thermostat and radiator cap. This is my moving truck and we are about to go almost 2,000 miles with the truck full of our "stuff" (this has a 15' enclosed box on it to, like an old Uhaul). Anything I can do from my own driveway. I know it may be the head gasket but praying it is not. Lastly, do I dare take off with it doing this and just bring a lot of coolant with me???
Ford Super Duty (1999-2016) :: 2002 F350 V8 - Burning Smell - Smoke Coming From The Brakes
I have a 2002 ford f350 triton 5.4 V8. I just put front brake pads on my truck today. Started driving around and i could smell burning brakes. Stopped and alot of smoke was coming from my brakes on my front passenger side but nothing from the front drivers side. Replaced all the brake pads on the front. What is making them so hot?
View 8 RepliesFord Super Duty (1999-2016) :: 2013 F350 - Check Coolant Additive Message
OK, I got the message, ran the tests, all is well. Now how do I clear the message? It's a 2013 F350 6.7PSD.
View 11 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Whooshing Sound / Low Turbo / Using Coolant
2006 F350 6.0l dually. Head gasket replaced, racing studs installed, other assoc components replaced few years ago. Y pipes replaced two years ago.
3 weeks ago had oil change and service. Last week engine started making roaring sound. Hubby raised hoid and discovered coolant fill tank cap off ( sitting on battery). Shop owner came to our home and filled with coolant, about 3 gal in. We drive from Houston to Lubbock then Dallas this week. Added about another gal coolant.
Hubby thought he heard an air sound yesterday, but was slight. Today after driving for about an hour at hwy speed, after we slowed for an exit, when throttle depressed again, air noise very loud and turbo weak. Limping home.
Have had some of the flexible hoses replaced in the last year or so as well.
Ford Super Duty (1999-2016) :: 2012 F350 - Air Only Comes Out Of Vent?
I recently purchased a 2012 f350 power stroke. Love the truck but went out this morning and the air would only come out of the vents. I couldn't get anything out of the defrost or the floor vents? Truck is out of basic warranty so want to see if I can figure this out myself or if it needs to go in the shop.I've looked for a fuse but didn't see anything that ran an actuator door.
View 5 RepliesFord Super Duty (1999-2016) :: 2012 F350 Truck Won't Start
I have a 2012 Ford F350 I've been looking to install a compressor on. I've poked a hole in the gasket that runs wires through the firewall and cut the tips off of a couple of the accessory wires. Went to go get some more parts and now the truck won't start! The lights and radio turn on when the car is turned on but the starter doesn't even click when I try to start it. What should I look at?
View 7 RepliesFord Super Duty (1999-2016) :: 2012 F350 - How To Disable DRLs
How do I disable the day time running lights on 2012 f350?
View 4 RepliesFord Super Duty (1999-2016) :: 2012 F350 6.7l - EGR System Torque Specs
Replacing EGR cooler/ EGR valve. Are there torque specs going back together with the EGR system? or is there a forum that has all the torque specs id need to complete the job.
View 4 Replies