Ford Super Duty (1999-2016) :: 2008 F350 - Loss Of Turbo Suddenly At High PSI
Bought a 08 F350 with the 6.4 Liter, with 80k mikes on it. Was traveling up an incline. Both Turbo's were engaged, when suddenly I lost boost, and PSI dropped all the way down. They barely create any pressure now. Checked intake, also checked boots too inter cooler. All seem fine. After driving it for about five minutes at low PSI, a check engine light came on. It was a sudden loss of power.
View 13 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Rattling Sound When Engaged In Front Wheel Drive
This must have been asked before but I couldn't find any thread about it. Have a 2006 F350 that makes a rattling sound when engaged in front wheel drive. Sounds a bit like a loose ball from a ball bearing (or a small stone) rolling around. What might be causing this?
View 3 RepliesFord Super Duty (1999-2016) :: 2003 F350 - Low Power / Screech From Turbo On Acceleration And Declaration
2003 6.0 F350... Under full throttle from take off goes about 20 mph just revs at 2500 let off the throttle in feather it shifts and acts like it wants to go just not allot of power sometimes. In neutral won't rev past 2700 rpms I do hear a screech from the turbo on acceleration and declaration. Also if in tow haul the truck won't shift at all. I can get it up to speed but even the smallest incline drops to 50 mph then takes bout 2 miles to get it back up to 65 mph or if I go downhill.... turbo makes the noise the whole time sometimes goes into passing gear in have to let off in it kinda my the truck hop in this is at 60 +mph. Only thing I have really tired was fuel filters and checked at plugs and boots.
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F350 Back Fired And Blew Off Turbo Hose
This is and 6.0L 04 135000 miles. I was pulling a load up a hill when the turbo back fired this was no fart hose blew off at bottom of rad, hose clamp was gone. I reattached hose but now I have lost some power and getting poor fuel mileage. I think turbo is making a howling noise at higher rpms I pressure tested the system does not seem to be any leaks, I'm assuming there something wrong with the turbo, but is it possible the hose clamp was sucked into the rad?
View 2 RepliesFord Super Duty (1999-2016) :: 2006 - No Turbo At Idle
I have a 2006 6.0, edge programmer, and egr delete. I had the hpop replaced back in July. I have a straight piped exhaust system as well. I have always noticed a loud whistle at idle from the turbo but yesterday when I started it there was not whistle at all. When I drove it it would still build boost but not like it used to. I have to really get on the throttle to build boost like it should. Is it my turbo going bad?
View 2 RepliesFord Super Duty (1999-2016) :: 2006 - Won't Build Turbo Pressure?
Got a 2006 6.0 won't build turbo pressure had to previous codes a p0098 and a p0405 I replaced the egr valve and the mafs codes went away but still no boost
View 9 RepliesFord Super Duty (1999-2016) :: 2005 - Sound Like Compressed Gas Cylinder Blowing Up - Blown Turbo?
Did I just blow up my turbo or what? I'm kinda new to diesels, I just purchaced a 2005 F-250. Today I was pulling my rv out of Devils Den State Park in Arkansas, beautiful place. There is a steep grade coming out, my truck was seeming to be having a kind of hard time, then a loud PFFTTTT sound. That is the best I can do for writing sounds. It sounded like a compressed gas cylinder blowing up! The pulling power went to nothing and the turbo gauge went to 0. It sounded fine at idle, other gauges were fine. I'm guessing my turbo is DEAD, what say you?
View 4 RepliesFord Super Duty (1999-2016) :: 2003 F350 - Minor Coolant Leak
03 f350 5.4. Very minor coolant leak at the moment. Valley behind water pump looks a little damp and leak has shown a little on the passenger side block above the starter. Shows on the tranny bell housing and hits the y pipe every once and a while. I am thinking its the hose that runs under the intake manifold but wanted to check in here for some wisdom. Can it be bypassed or rerun without pulling everything.
View 12 RepliesFord Super Duty (1999-2016) :: F350 V10 - Leaking Coolant From Rear Of Engine
My grandfathers 99 F350, started suddenly, do not know if it was while sitting or while driving. Its more of a stream than anything else. Coming from the rear, cannot see where, appears to be toward the vee of the engine, not inside the bellhousing. The firewall insulation is damp from coolant. Doesnt start until engine starts warming up.
Is there something commonly replaced back there? Didnt want to yank the intake in 20* weather for exploratory surgery. Is not the heater hoses. Idk if the EGRs are cooled on these, thats about my only idea other than freeze plug, coolant tests good down to -20ish, hasnt been below zero in weeks (prior to leak). Not familiar with any of the modular engines.
Ford Super Duty (1999-2016) :: 1987 F350 - Coolant Leaking Regularly?
I'm a total beginner and am slowly nursing an '87 F350 7.5L back to running condition as a plow/farm truck. It regularly loses coolant, even on very short trips around the farm and I figured that radiator needed to be replaced. Today I was hooking a snow plow up and had it running for about 15 minutes when light grey smoke started to come out of the vents in the cab. Looking at the engine, I noticed a lot of coolant leaking out from below the heater housing. The coolant was dripping out of what looks like a protruding bit of pipe a where a hose should be attached. What am I looking at here?
View 4 RepliesFord Super Duty (1999-2016) :: F350 - Coolant Leaking At The Front Seam
I recently did the water pump and hoses due to seeping around the water pump gasket. While there, I decided to replace the overflow reservoir as well - old and slightly discolored. I'm now on my 3rd overflow reservoir - they are all leaking at the front seam. I don't think I have a blown headgasket or injector issues - no signs of white smoke ever, and there isn't any oil or fuel in the coolant. I've also tried a new cap, but it's starting to leak before I build any noticeable pressure - I can back off on the cap and don't get much pressure released. So - just bad luck on parts from Ford? All were OEM from different Ford dealers.
Pics - hard to see on here but go to Imgur to zoom in. [URL] ...
1999 F350 7.3 CCLB Dually. Stock except for DP Tuner and Gauges.
Ford Super Duty (1999-2016) :: 1997 F350 - Coolant Being Instantly Over Pressurized
I have a 1997 F350 460 7.5 automatic two wheel drive. I am having a sudden issue with the coolant being instantly over pressurized. Even when the engine is cold and I start it for a minute and then shut it off, the coolant comes under great pressure. I noticed this starting when coolant was being forced out of the overflow reservoir. The truck does not overheat.
I changed thermostat and radiator cap. This is my moving truck and we are about to go almost 2,000 miles with the truck full of our "stuff" (this has a 15' enclosed box on it to, like an old Uhaul). Anything I can do from my own driveway. I know it may be the head gasket but praying it is not. Lastly, do I dare take off with it doing this and just bring a lot of coolant with me???
Ford Super Duty (1999-2016) :: 2013 F350 - Check Coolant Additive Message
OK, I got the message, ran the tests, all is well. Now how do I clear the message? It's a 2013 F350 6.7PSD.
View 11 RepliesFord Super Duty (1999-2016) :: 2012 F350 6.7L - Coolant Smell When Walking Around The Front Of Engine
I have a question on the 2012 F-350 with 6.7. I have found after mid to long drives when I shut the truck down I can smell coolant when walking around the front of the engine. Seems more so from the driver side but i have yet to see any leaks or wet spots on the ground. I had the water pump and lower rad hose replaced last year under warranty and though it might have been residue but after a year and still smelling it it has to be something else. I only have 30,000km's left under warranty so if I need something replaced it should be soon
View 8 RepliesFord Super Duty (1999-2016) :: 2013 F350 - Humming Sound When Key Is In Ignition
I've noticed that when I insert the key in my 2013 F250 I hear a humming noise, if I pull the key out it goes away. What is this noise? It seems to do it as long as the key is in, but is quiet enough that you can only hear it when there isn't a lot of back round noise.
View 14 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Stuck In 4X4 Low
I am off to work tomorrow 800 Mile drive and I cant get this thing out of 4X4 Low. Tried driving (inching) back and forth. Got front end up on jacks to try to free up driveline... Is there any way to Manually put in 2WD. I just don't have time to run to town and get parts (new switching motor) if that is what the issue is?
View 7 RepliesFord Super Duty (1999-2016) :: 2001 F350 - ABS Light Comes On - Metal Grinding Sound
2001 f250 7.3 crew
So, Saturday my abs lite comes on. Later that day I hear metal to metal sound for a couple of secs then it stops. Then the next day while driving I get intermittent sounds that sound like I'm dragging metal down the pavement. I see nothing but I'm thinking hub bearing. (Needle)
I remove the hub assembly from the knuckle and can find nothing wrong. I even picked up a new hub just on case. Now I'm stumped. Can't figure out what the sound was or is. Axle has a little play going into the housing but figure it would have due to the only thing holding it in place is the hub.
The only thing left in the area that could make the sound is major --the actual gears to to the front end. If the bearing isn't causing the metal grinding sound I've no other idea other than that....
Ford Super Duty (1999-2016) :: 2006 F350 - AC Pump Cycles When Off
20 06 F350 6.0l ... Recently noticed when my climate control selector switch is on the off position, the a/c vacuum pump cycles for a few seconds then stops, then cycles, then stops.. Does this until it's changed to a different setting. Pulled the connector behind the selector and plugged the black hose and it stopped. Re-connected it and could hear site leaking so I kinked the white hose and it stopped. I have also lost my MAX a/c that is now defaulting to defrost. Is there a part number just got the hose selector, or a way to fix the existing one?
View 4 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Using Remote Start?
I just bought me a 2006 Ford F350 Lariat. A sticker in front of the radiator says says that my truck is equipped with remote start. How would I go about using it? I only have one fob. If it is in fact something that I can utilize I have seen guys on youtube program their fob to do it by clicking three times.
View 2 Replies