Ford Super Duty (1999-2016) :: 2005 - Torque Specs For Crankshaft / Cylinder Heads And Camshafts?
What are the torque specs for the crankshaft,cylinder heads and camshafts for a 2005 f550 v10 6.8?
View 2 RepliesFord Super Duty (1999-2016) :: 2003 - Sway Bar Bushings Specs?
What are the specs for the sway bar bushings that go in the retaining bracket for a 2003 ford f250? went to advanced auto last night to get some got mine off my truck and the one they gave me was a little too small for my sway bar and the retaining bracket.
View 2 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Air Only Comes Out Of Vent?
I recently purchased a 2012 f350 power stroke. Love the truck but went out this morning and the air would only come out of the vents. I couldn't get anything out of the defrost or the floor vents? Truck is out of basic warranty so want to see if I can figure this out myself or if it needs to go in the shop.I've looked for a fuse but didn't see anything that ran an actuator door.
View 5 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Leak In High Pressure System
I recently came a cross a no start issue with my truck. It is 2005 ford f350 6.0 ... Found out I have a leak in the high pressure system. When I was taking out the bolts out from the manifold I stripped out two bolts. I know ford part # w301383 is the ford bolt. But I was thinking why use that same bolt and had have that issue again later.
View 1 RepliesFord Super Duty (1999-2016) :: 2008 F350 - Check Charging System Message
I have a 2008 f350 6.4 (105,000 miles) and I am randomly getting the check charging system the batterys have a standing voltage of 13.8 and 13.9-14v (read from the ecu with scanner) both at idle and under a load. I also checked the alternator and its making 13.8-14 all the batteries are tight and there is no corrosion.
View 1 RepliesFord Super Duty (1999-2016) :: 2012 F350 Truck Won't Start
I have a 2012 Ford F350 I've been looking to install a compressor on. I've poked a hole in the gasket that runs wires through the firewall and cut the tips off of a couple of the accessory wires. Went to go get some more parts and now the truck won't start! The lights and radio turn on when the car is turned on but the starter doesn't even click when I try to start it. What should I look at?
View 7 RepliesFord Super Duty (1999-2016) :: 2012 F350 - How To Disable DRLs
How do I disable the day time running lights on 2012 f350?
View 4 RepliesFord Super Duty (1999-2016) :: 2006 F350 - HVAC System Is Melting / Blowing Scalding Hot Air
I was recently on a trip pulling my 32' Travel Trailer, and out of the Hvac system started blowing scalding hot air and soot and smoke into the cab. I pulled over to check things out and could find nothing wrong. When the turbo kicks in it blows even hotter. I could find nothing wrong at the time. As I got back on the road again it started again a few miles down the road.
I made it home and started checking things out. Around the dash, airbag, glove box, on the window , headliner and carpeting, is covered in soot and smoke. the computer is now telling me that ALL the doors are ajar, power locks and key fob do not work, 3/4 of the window switches do not work and 1 window does not work now. I removed the glove box and the panel underneath it to look at the HVAC system.
What I saw about made me cry. The Plastic that houses the HVAC system had started melting and the HVAC hoses have melted. I have still not found the reason for any of this to happen. Also when I got the truck a year ago the Turbo would spool up around 1800 to 2000 RPM. Now it does not spool up until around 3000 to 3250 RPM.
HVAC system and hose
HVAC system housing
Glove Box and Vent
Air bag and Vent
Ford Super Duty (1999-2016) :: 2012 F350 4x4 Diesel - Rough Ride
I have a 2012 Ford F350 SRW 4x4 Diesel. Love the truck and has been great. I have 20" Tires and the ride on this truck is really rough. I know its now a Cadillac but to change tires or suspension components to get a smoother ride. I was thinking about going to 18" rims and getting a big all terrain tire. Maybe taking a leaf spring off in the rear. Going to air suspension. Different tires maybe. I dont need the load rating since i sold my fifth wheel.
View 13 RepliesFord Super Duty (1999-2016) :: 2012 F350 - No Defrost / Stay In Vent Only
I have a 2012 F-350 SRW with a 6.7 diesel. The other day I went to push the defrost switch and noticed it does not work. All the lights work in the switches, and the temp control works, but no matter what I push, defrost or floor, it stay in the vent only. Anything I can check??
View 1 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Running Temps For Trans
What are the normal running temps for the tranny of a 2012 f350 6.7?
View 3 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Front Brake Replacement
Any good info on front brake replacement parts to get better braking out of these beasts? My pads are now needing replacement but I would like to get better performance than that of factory parts....
View 1 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Tailgate Step Installation?
We just purchased a new 2012 F 350. Love it, however when shoping forgot about getting one with a step. Have found step and handle available (OEM) but need to know how hard/easy to install it on our current tailgate. I gather from another post the handle part is easy but what about the step itself?
View 2 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Can Install Upgraded Message Center?
Found some threads on this but mostly for the 05-07 models. I am wondering if it is possible to install the upgraded message center (right above the steering column) into the dash of a 2012 F-350 XLT that has only the 2-line text message center?
View 1 RepliesFord Super Duty (1999-2016) :: 2012 F350 Misfiring When Driving During A Snow Storm
While driving into town during a recent snowstorm, my truck started to misfire quite badly. The check engine light started to flash and then remained on as I went to the auto parts store. The code indicated cylinder two misfire. I don't a few things of dry gas in the tank and let it run for a few minutes which seem to solve the problem.
Since then, however,every time the engine gets even a little bit wet it starts to bark again. It usually lasts a few minutes then goes back to normal. Typically, I would have replace the plug wires. When I lifted the hood of my truck I realize I knew nothing about it.
Ford Super Duty (1999-2016) :: 2012 F350 - Hellwig Front Sway Bar Installation?
Installing the Hellwig 1 1/4 inch Front Sway Bar on their 11 and up F250 or F350 SRW Pickup?
My 2012 F350 Super Cab LWB XLT 6.7L seems to have quite a bit of sway in the front end. This is especially true moving slowly such as turning into service stations or other off angle turns. The truck only has the FORD OEM puny Rear Anti Sway Bar but the front seems to accentuate sway. The Truck has Rancho 9000XL Shocks, Timbren Enhanced Suspension System as well as Torklift Quick Release Stable Loads in the rear.
The Truck I have is not overloaded but it does carry an Eagle Cap 950 Camper pretty much full time. True the Campers now days are tall so some sway is expected. I just want to reduce the apparent front end sway and wonder if others have used the Hellwig Sway Bar in the front.
Ford Super Duty (1999-2016) :: 2012 F350 - Road Armor Bumper Installation?
I am installing a set on a '12 F350 for a customer. I already had to go buy an additional hardware in order to get the back bumper on correctly...and now I'm looking at the front bumper and I swear I don't have the parts I need to install it. It appears to be missing some brackets. There were NO instructions with them (apparently a chronic problem with Road Armor) and I can't possibly imagine it bolting to the flimsy brackets that hold the factory bumper (fairing would be a better word for it) in place.
View 6 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Clunking / Crunching Sound In Steering Only When Cold Outside
So, I have this problem that comes back when the temperatures drop below about 20 degrees F. The truck is a 2012 F350 diesel with 15k miles and has done it since it had 3,000 miles on it. When turning in an intersection, or just moving the steering wheel left to right, it makes a clunking sound up in the front steering area and you can feel it a little as well. I have taken it to the dealer and they tightened the body mounts, but that did nothing. Once it warms up, the sound is gone.
This, coupled with the rear end clunking loudly over every bump and pothole when it is cold out, makes this truck a real noisy/annoying vehicle in the winter.
Here is a video of the steering noise, it is louder in person: [URL] ....
Ford Super Duty (1999-2016) :: 2012 F350 - Creaking Noise With Hill Start Assist?
I own a 2012 F350 dually King Ranch with 6,600 miles on it as of today. I noticed that on slight inclines, I can see and feel the hill start assist feature activating and working as before. I was not towing anything today. Starting today though, I hear this loud creaking noise both in forward and reverse directions with quite a bit of shutter from front of the truck lasting one to two seconds as I transition from the brake to accelerator. I checked the front hubs to make sure that they are not in locked position. I tried activating 4WD auto mode, then deactivate it to 2WD mode as I watched the diagram/figure on the dashboard. Nothing would make the loud creaking noise and shutter go away. Is there anything else I can try, or should I take it back to my Ford dealer again (now for another different reason. I had problem with injector #8 failure with CEL come on earlier this week which appears to be fixed for now)???
View 13 Replies