Ford Super Duty (1999-2016) :: Coolant Smell After Driving / Radiator Leak
About a week ago I began smelling coolant after driving my 2012 F350 6.7. Yesterday I noticed a small amount of coolant on the ground and decided to take it to the dealer. As soon as I told the Service Manager what was going on he said......"You need to leave it......there is no doubt in my mind it needs a radiator". They pressure tested and and sure enough it does. He said they are replacing about 2-3 a month but there is no recall.
Here is where it gets fun. Apparently radiators fall off at 36,000 miles and are not included in the 100,000 Power Train Warranty. It gets better. The Radiator is on national back order for 5-6 weeks.
Ford Super Duty (1999-2016) :: 2001 F250 - Heater Not Blowing Hot
2001 F250 5.4. The heater will blow warm air at idle and on the second highest setting, once you start moving or turn the fan up to full blast it instantly cools off. The coolant level is fine. The engine runs at a normal temp.The blend door does work. I just replaced the thermostat, and both hoses for the heater core are hot.
View 4 RepliesFord Super Duty (1999-2016) :: Heater Blowing Cold Then Truck Overheated And Pushing Coolant Out Of Cap
My '01 Super Duty 5.4 has an overheating/heater problem that the dealer can't seem to fix. I noticed my heater was blowing cold then a few miles later it overheated pushing coolant out of cap. Next day drove fine to Ford dealer who replaced my heater core, thermostat, reservoir cap and a hose. Drove it for a day till the exact original symptoms occurred again with a gurgling sound in dash. Dealer kept for a week pressurizing system but no leaks found. Replaced my thermostat again and gave it back. I drove it 300 miles over a week before the exact same symptoms occurred. Brought back to dealer who said that air was in the system, added a bunch of coolant and supposedly got all the air out. Same symptoms still. Brought back to dealer that finally changed the water pump they said had a leak. Guess what, same symptoms. Heater will work fine for days then it will blow cold, then hot, then cold and sooner or later truck will overheat then just as fast cool down and heater will work again. Still hearing gurgling. Dealer said I don't have a HCV.
View 6 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Heater Core Replacement
I recently replaced my heater core on 2001 F250. Would be a simple job if it weren't for the quick connects on the hoses. Any tool to take these apart on the truck where space is limited?
View 1 RepliesFord Super Duty (1999-2016) :: 2014 F250 - Heater Noisy And Not Working Well
I bought the wife a truck a few weeks ago and she said the heater wasn't working well and was noisy. So I hoped in it at lunch today and she was right, barely any heat output and its noisy coming from behind the passenger airbag.
View 1 RepliesFord Super Duty (1999-2016) :: F250 V10 - Heater Hose Inlets Or Outlet?
99 F250SD V10. There are two connections on the heater core at the firewall. Is there an 'inlet' and an 'outlet' or does it not matter? Put a cummins in the truck, the V10 has been out for a while and cant remember which one is which.
View 5 RepliesFord Super Duty (1999-2016) :: 2008 F250 - Heater Core Replacement?
Started to attempt to replace the heater core in my 08 SD 6.4. Didn't know the entire plenum has to come out in order to replace it. How to remove the plenum? My buddy is a Ford tech but I just am not getting what he is telling me and there is next to nothing coming up when I try to search.
View 2 RepliesFord Super Duty (1999-2016) :: V10 - Coolant Leak Where Heater Core Tube Goes Into Intake At Rear Of Engine
I have a leak where my heater core tube goes into the intake at the rear pass side of engine. I have read that this part is pressed in. I dont want to remove the intake since i just paid $400 to have a new gasket kit put on. My question is can I bypass this tube with a hose from the water pump like in this video?
FORD 4.6 , 5.4 , 6.8, HEATER HOSE UNDER INTAKE REPLACEMENT THE EASY WAY !!! - YouTube....
If I can do a rubber hose like in the video I was to make sure that the tube just goes through the intake and that it does not supple coolant into the intake??
Ford Super Duty (1999-2016) :: 2012 F350 6.7L - Coolant Smell When Walking Around The Front Of Engine
I have a question on the 2012 F-350 with 6.7. I have found after mid to long drives when I shut the truck down I can smell coolant when walking around the front of the engine. Seems more so from the driver side but i have yet to see any leaks or wet spots on the ground. I had the water pump and lower rad hose replaced last year under warranty and though it might have been residue but after a year and still smelling it it has to be something else. I only have 30,000km's left under warranty so if I need something replaced it should be soon
View 8 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Heater Blow Warm For The Most Part
Sunday I bought a 2001 f250/5.4 to replace my 91 f250. I didnt drive it yesterday, but this morning on my drive to work the heater was very weak, it seemed to blow warm for the most part, but was barely pushing air even on high. I flipped it over to A/C to see if it blew any harder and it did. Does the blower motor need replace? if so why does the AC blow harder than the heater?
View 14 RepliesFord Super Duty (1999-2016) :: 2010 F250 Diesel - Heater Blows Cold Air
The heater blows cold air from the driver side only. Very cold. Vey hot on passenger side.I have read that this is likely a blend door issue. Comments? Fluids are full. I hear slight noises from under the dash like "click click" like a door is trying to activate?? Truck out of warranty. If it is the door I heard the driver side is not as tough to install. Again comments? Instructions?
View 2 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Oil In Coolant
I bought the truck today (cheap) know it had this issue, oil in coolant no coolant in oil, ATF was not apparent on dip stick I'm told truck over heats.
2003 f250
5.4
400,000 + miles
I saw no bubbles in coolant tank when running... Need some things to check to narrow it down....
Ford Super Duty (1999-2016) :: F250 - Coolant Reservoir Was A Bit Low
I just purchased a 2007 Ford F250 5.4l V8. I noticed the coolant reservoir was a bit low so I went out and bought some Prestone extended life universal coolant, distilled water and a hydrometer. The current Coolant I have is a yellow/gold colour, which I believe is motocraft brand. I added 150ml 1:1 of distilled water and coolant. After that I tested the temperature rating and it was off the gauge (the previous owner obviously added just coolant and no water). My plan was to drain the radiator half way and refill with distilled water. But, how to do that I came across a lot of forums saying you can't mix Prestone ELT with Motocraft coolant or it will eat away at your engine as well as create a thick goo. Is this true? Will such a small amount (75ml) cause this effect? Do I have to do a radiator flush now, or can I just continue with my plan of draining it half way? The old coolant looked pretty clean. Do you think the Prestone anti freeze has already done any damage?
View 14 RepliesFord Super Duty (1999-2016) :: F250 - Diesel Smell In And Out Of The Cab On Cold Start
When I cold start my 99 F250 7.3L PowerStroke extended cab long bed manual, I get diesel smell in & out of the cab. What is causing it?
View 3 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Exhaust Smell In Cabin Air?
2003 6L 250 SD. Always smells of exhaust on the cabin. If there is snow it gets much worse.
View 2 RepliesFord Super Duty (1999-2016) :: F250 - Surging - Heater Controls Default To Defrost When Driving
My truck at idle sounds like it has aftermarket cams and the exhaust coming out of the tail pipe smells really rich. when driving down the road my heater controls default to defrost. Also when I fill up with gas it takes forever to get it to fill all the way. I am lost on where to begin with the problem [ I did check the tank vent hose and their is no blockage] Possible vacuum issue?
View 10 RepliesFord Super Duty (1999-2016) :: 2011 F250 - Heater Start Blowing Cool Air After 15 Minutes Or So?
My 2011 F-250 just started having a weird heater problem. My truck heater gets up to temp just fine but after cruising down the highway for about 15 minutes or so it starts blowing out cool air. I can turn the controls to defrost and back again and it blows warm, not hot but warm then cool again. It just started a couple of days ago. Temp gauges show normal temp also.
View 8 RepliesFord Super Duty (1999-2016) :: F250 - Smell Of Gas / Hole Rubbed In A Small Hose
Need the fuel system diagram or schematic for my truck.
1999 250 superduty v-10 Ser# 1FTNF20S1XEC67940
Every time I run it I smell gas. I changed the f/p 6mo ago. While I was working on it I noticed there was a hole rubbed in a small hose. I assumed it was a return line (smelled gas before too) and when I fixed it the smell went away until lately. I dropped the tank,yesterday and didn't see any problems. Just need to find out what hoses go where so I can replace the hoses??
Ford Super Duty (1999-2016) :: 2001 F250 Will Not Start When Cold If Forget To Plug In Block Heater
Cold no start goes nowhere. I have a 2001 7.3 that will not start in the cold if I forget to plug it in....like last night. I have to plug in the block hater and give it a while before it will start. I tested the glow plug relay,it works fine. I can not find a test for the fuel bowl hear, and I'm not one to throw parts until I accidentally fix it. Any test procedure for the fuel bowl heater? Why this POS is so bad in the cold? Glow plugs tested fine at diesel shop in December, and this problem has been around since before that.
View 14 Replies