Ford Super Duty (1999-2016) :: F350 V10 - Leaking Coolant From Rear Of Engine
My grandfathers 99 F350, started suddenly, do not know if it was while sitting or while driving. Its more of a stream than anything else. Coming from the rear, cannot see where, appears to be toward the vee of the engine, not inside the bellhousing. The firewall insulation is damp from coolant. Doesnt start until engine starts warming up.
Is there something commonly replaced back there? Didnt want to yank the intake in 20* weather for exploratory surgery. Is not the heater hoses. Idk if the EGRs are cooled on these, thats about my only idea other than freeze plug, coolant tests good down to -20ish, hasnt been below zero in weeks (prior to leak). Not familiar with any of the modular engines.
Ford Super Duty (1999-2016) :: 1987 F350 - Coolant Leaking Regularly?
I'm a total beginner and am slowly nursing an '87 F350 7.5L back to running condition as a plow/farm truck. It regularly loses coolant, even on very short trips around the farm and I figured that radiator needed to be replaced. Today I was hooking a snow plow up and had it running for about 15 minutes when light grey smoke started to come out of the vents in the cab. Looking at the engine, I noticed a lot of coolant leaking out from below the heater housing. The coolant was dripping out of what looks like a protruding bit of pipe a where a hose should be attached. What am I looking at here?
View 4 RepliesFord Super Duty (1999-2016) :: 2012 F350 6.7L - Coolant Smell When Walking Around The Front Of Engine
I have a question on the 2012 F-350 with 6.7. I have found after mid to long drives when I shut the truck down I can smell coolant when walking around the front of the engine. Seems more so from the driver side but i have yet to see any leaks or wet spots on the ground. I had the water pump and lower rad hose replaced last year under warranty and though it might have been residue but after a year and still smelling it it has to be something else. I only have 30,000km's left under warranty so if I need something replaced it should be soon
View 8 RepliesFord Super Duty (1999-2016) :: 2013 F350 - Oil Leaking From Engine
I have a 2013 f-350 with 58,000 miles. I'm a general contractor and drove my truck to a very nice home with decorative concrete. After I left the customers house they called my office to say I left oil stains on their driveway. I looked under the hood and noticed motor oil leaking on the front left side of the engine. I told the customer we will take care of the stain. I've never had a diesel motor leak this soon on me.
My mechanic told me to go to a Ford dealer so I did. The dealer told me that this is not covered under the warranty as it is a oil pump/brake vacuum. THE MOTOR IS LEAKING OIL. I told the dealer that the motor is leaking oil and I have a warranty that I signed up for. He told me that Ford considers this issue the same thing as an alternator.
Ford Super Duty (1999-2016) :: 2011 F350 - Fluid Leaking In Through The Firewall
2011 F350 with fluid leaking in through the firewall. Does the Hydro booster have to be replaced or is there a gaskets or seal on the rod that goes to the brake pedal?
View 14 RepliesFord Super Duty (1999-2016) :: 2011 F350 - Pinion Seal Leaking?
Pinion seal on my truck is leaking. At auto parts store they gave me National seal part number 4278. It does not fit it is too small.I went back and other seal they have is too big. What is the part number?
View 11 RepliesFord Super Duty (1999-2016) :: Head Gasket Leaking Into Coolant System
To all those folks that said I had a head gasket putting pressure into my cooling system and causing it to overheat, you were right. It is a 2003 F250 with 80000 5.4 l. I have had to replace mexhaust manifold bolts on left side (horrible job, couldn't get one out). Back fenders are rusted out, under the extended cab rusted, doors are rusting at the bottom. My friend/mechanic said it was time to get rid of it. I don't really have thousands of $$ for a different one, but also, replacing the head gaskets are in the thousands for a repair bill. I have looked at used 2008 250 4 door and they are 20000+++ sheesh, but a new one is out of the question. Do I get the gasket situation repaired?
It does not act up all the time, some times it never overheats, sometimes it will. Somewhat infrequent ( I had one mechanic look at it and he tried 3 different times, and it did not overheat. Temp gage will peg, coolant resevior will overflow, but is not hot (100 degrees). I dont have the really have the money to put into a newer model, but I am worried about being nickeled and dimed to death after dumping a couple of thousand into a head gasket, plus I suppose I need to have the other side manifold gasket/bolts checked too. It seems like low miles to be having issues, yes I realize all will rust, but this year, as evidnet in our area, was really suspect-able to rust.
Not worried about the body, is it worth it to spend 2500 for head gasket repair, or trade up a couple of years, less miles, etc. My worry is, I already had to fix 1 exhaust manifold gasket, know head gasket to fix a cooling issue, do I cut my losses and move to another truck, or spend the money for repairs. I don't really have money for either but want to make a good decision. Truck has not been abused and has been serviced as scheduled. Had to put on new brakes and rotors, as would expect, and ball joints too. Oil looks fine, no contamination, and coolant is clear. Will the head gasket get worse? As I said before, it is intermittent, but I don't trust it for long trips.
Ford Super Duty (1999-2016) :: Coolant Leaking From EGR Unit - Gasket Replacement
Having some coolant leaking from the EGR unit in my 2011 super duty.. Dealer says it's a 14 dollar part, but labor is a few hours to replace.. Not sure I see how that can be, but I wanted to ask on Here to see how long this should take..
View 1 RepliesFord Super Duty (1999-2016) :: Leaking Coolant From Pipe On Driver Side
I think I have a clamp or something loose as i am dripping coolant from a black and silver hose/pipe on teh drivers side of the motor.
I can't see any clamps, well clamps i can recognize. how is this black pipe connected to the aluminum pipe? at that seam is where it's leaking.
Ford Super Duty (1999-2016) :: 2000 F250 - Mixing Coolant In The Block And Leaking Oil
I just bought a 2000 F250 SD 6.8 v10 and its mixing coolant in the block and leaking oil. I'm debating on just dropping a newer v10 in it but im just not 100% sure that this engine is shot. It runs great when there's oil in it and I can't even tell there's any problems going on for well over a couple hours after i fill it up with oil.
View 8 RepliesFord Super Duty (1999-2016) :: 2005 - Blowing White Smoke And Leaking Coolant
My truck is a 2005 6.0 with no after mods and has 73000 miles on it. It began to blow white smoke out exhaust. I changed out the egr valve and cooler. After putting back together it then blew white smoke ran it to clear out. This worked however once it warmed up it began to blow thick white smoke at 20 mph and clears up by the time it reached 30mph and white smoke shoots out at rapid acceleration. As well there is coolant leaking out under the truck from somewhere in the motor about in the center. I am looking to work on this myself as I have heard of owners taking it to shops and paying a lot of money for the prob to not get fixed.
View 7 RepliesFord Super Duty (1999-2016) :: 2003 F350 - Minor Coolant Leak
03 f350 5.4. Very minor coolant leak at the moment. Valley behind water pump looks a little damp and leak has shown a little on the passenger side block above the starter. Shows on the tranny bell housing and hits the y pipe every once and a while. I am thinking its the hose that runs under the intake manifold but wanted to check in here for some wisdom. Can it be bypassed or rerun without pulling everything.
View 12 RepliesFord Super Duty (1999-2016) :: 1997 F350 - Coolant Being Instantly Over Pressurized
I have a 1997 F350 460 7.5 automatic two wheel drive. I am having a sudden issue with the coolant being instantly over pressurized. Even when the engine is cold and I start it for a minute and then shut it off, the coolant comes under great pressure. I noticed this starting when coolant was being forced out of the overflow reservoir. The truck does not overheat.
I changed thermostat and radiator cap. This is my moving truck and we are about to go almost 2,000 miles with the truck full of our "stuff" (this has a 15' enclosed box on it to, like an old Uhaul). Anything I can do from my own driveway. I know it may be the head gasket but praying it is not. Lastly, do I dare take off with it doing this and just bring a lot of coolant with me???
Ford Super Duty (1999-2016) :: 2013 F350 - Check Coolant Additive Message
OK, I got the message, ran the tests, all is well. Now how do I clear the message? It's a 2013 F350 6.7PSD.
View 11 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Whooshing Sound / Low Turbo / Using Coolant
2006 F350 6.0l dually. Head gasket replaced, racing studs installed, other assoc components replaced few years ago. Y pipes replaced two years ago.
3 weeks ago had oil change and service. Last week engine started making roaring sound. Hubby raised hoid and discovered coolant fill tank cap off ( sitting on battery). Shop owner came to our home and filled with coolant, about 3 gal in. We drive from Houston to Lubbock then Dallas this week. Added about another gal coolant.
Hubby thought he heard an air sound yesterday, but was slight. Today after driving for about an hour at hwy speed, after we slowed for an exit, when throttle depressed again, air noise very loud and turbo weak. Limping home.
Have had some of the flexible hoses replaced in the last year or so as well.
Ford Super Duty (1999-2016) :: 2000 F350 - Leaking Oil From A Bolt On Passenger Side Valve Cover
My 2000 f350 is leaking oil from a bolt on the passengers side valve cover. it is one of the bolts on top of the valve cover. Can I just remove the bolt and put a rubber washer under it or do I need a new valve cover?
View 2 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Rear Passenger Side Is Leaking Brake Fluid
I have a 2005 F350 XL Heavy Duty 6.0L truck that has 68,XXX miles. I recently changed the rear brake pads and about a week later the rear passenger side is leaking brake fluid. The fluid is slowly dripping from the bottom caliper bolt but i am not sure if there are seals in this area. the driver side is fine and the fluid is only leaking from the bottom caliper bolt not the top.
View 2 RepliesFord Super Duty (1999-2016) :: Front Driveshaft Leaking?
What would I need to replace in order to fix this leak ?
View 5 RepliesFord Super Duty (1999-2016) :: 2015 - Front Axle Leaking A Lot?
I have a 2015 F250, cc 4X4 PSD. It has 22,000 miles on it. I notice a small quarter sized drop of oil after it is parked by the right side front wheel. It is coming from behind the dust cover and universal joint where the axle goes into the tube. I dont know how long it has been leaking. My issue is I am about 800 miles from home on a camping trip, have to go back to work Monday, and lcoal dealer here can't take it in till next week. So, if the hubs are not locked and the truck is in 2 wheel drive, the gears shouldn't be turning right? I assume it is ok to drive home. I didn't want to pull the plug and check the fluid because if any runs out and leaves a stain on the cover, I don't want ford trying to deny warranty claiming I messed with it first.
View 5 Replies