Ford F-150 - 1997-2003 :: OD Off Light On The Shift Selector Blink / Service Engine Soon Light Comes On
I have a 1999 F-150 w/ 4.2 V6. and auto trans, truck has 219,000 miles on chassis but only 25,000 on engine and 10,000 on trans. I've been getting obd codes p0705 and p0715. I replaced the position sensor on outside of trans. but I continue to get the codes off and on again. I noticed that the O/D "OFF" light on the shift selector blinks simultaneously when the "service engine soon" light comes on. I've noticed that there is no low gear unless I have it in D from a dead stop, and not even when downshifting manually.
View 1 RepliesFord F-150 - 1997-2003 :: 2001 - Overdrive Off Light Blinks In D?
2001 f-150 XLT V6 auto.
176k miles & original engine/transmission.
What does this mean?
Volvo :: Check Engine Light Blink But Never Got Steady / Fuel Pressure Error Code
I had a Check Engine Light a couple months ago, and I took the car to the garage to have it checked out. They told me they got a Fuel Pressure Sensor malfunction code, and that the sensor had to be replaced. I did so myself, an it is ridiculously easy, and the car worked fine. I noticed the Check Engine Light blinked a couple of times while I was driving, but never got steady. A couple of days ago, it did. Out of a bad gut-feeling, I purchased a ODBII scanner, and I scanned the car myself. I got the same error code as the garage did, but the sensor should be fine.
View 5 RepliesFord F-150 - 1997-2003 :: Starts Fine Then A Day Later It Won't / Acts Like Not Getting Fuel
We have a 2003 Ford F250 Super Duty, gas engine. This will start fine, then a day later, it won't. Wait 30 minutes, then it starts.
Starter and battery are fine. It acts like it isn't getting fuel. Fuel pump? Filter? What else might cause this?
Ford F-150 - 1997-2003 :: 2001 - Engine Light Come On With Code P1132?
too it to see what's maiking engine light come on code P1132 comes up. what's that mean?
View 6 RepliesChevrolet - 1500 :: 2001 Acts Like Running Out Of Fuel When Gas Tank Is Over Half Full
I have a 2001 Chevy Silverado with the 4.8L V-8 engine. It acts like it is running out of gas ( the gas tank is over half full). The truck has sat for about 6 months in this condition without being started here in Sacramento, CA. I then replaced the fuel filter and for a few minutes it started and the engine ran fine (without actually driving it). A few days later I started it again and it now again acts like it has fuel starvation, it will rev up briefly then act like it is running out of fuel. I know the fuel pumps are the Achilles Heel of these trucks, but before I try changing it I was wondering if there might perhaps be another problem such as the new fuel filter plugging up quickly or possibly an electrical problem. I've always heard these fuel pumps either work or they don't work, nothing in between. This problem is intermittent but big enough the truck is not driveable. Is there any way to get a good take on the problem before diving into the fuel pump replacement and hoping that solves the problem ?
View 5 RepliesFord - Explorer :: Overdrive Light Will Blink Once In A While
My 2000 Explorer overdrive light will blink once in awhile no hard shifting, no slipping, i also pushed the overdrive button while it was doing this and it went out of overdrive , trans has been service, I know this is a common issue with explorers . I understand that it could be caused by a number of issues. I haven't had the codes pulled yet.
View 4 RepliesFord F-150 - 1997-2003 :: Crank Over But Acts Like Stuck - Engine Will Not Turn Over
I am working on a 2000 f-150 XLT 5.4L 4x4 Automatic. It tries to crank over but acts like its stuck. things done: New starter, new battery, fixed connections. I can turn the crank counter clock wise but won't turn clock wise. Not sure if i should say the engine is bad or could trans be stuck? Heard 5.4L's have timming chain issues. Is that true? Point me in a direction and i'll go forth.
View 14 RepliesFord F-150 - 1997-2003 :: OD Light Will Start To Blink When Trans Gets Hot
I have a 1998 f 150 v8 4.6 ltr xlt. A mechanic told me that if my tranny gets hot the OVERDRIVE LIGHT will start to blink. It sounds strange to me, should I have a guage installed? I will be towing a trailer this summer.
View 8 RepliesFord Fuel System :: 2003 F150 - Service Light Randomly Comes On / Code For Left Bank Running Lean
2003 f150 supercrew with 166,000 miles on it. Daily driver. Service light randomly comes on and when code reader was put to it shows "left bank running lean." Will clear it and will randomly come back on. Truck seems to be running fine. No issues engine. Bad sensor? Or bad injector? Maybe way to test?
View 1 RepliesFord F-150 - 1997-2003 :: 2001 - Low Moan At 70 MPH Come And Go - Overdrive On / Off Indicator Flashing
I'll start with truck specifics. 2001 Ford Expedition, 5.4, automatic, 141,000. We just got the truck 4 months ago, second owners. Seemed reasonably maintained, other than Ball joints.
This afternoon, my wife and I were cruising along on this warm 90 degree summer day, out running some errands and having a good time ( we both had today off) about 70 miles from home. When we pulled into one of our spots, I noticed a few drips heading in the direction of under the truck. i simply thought the AC, which had been running full blast for an hour, was dripping, not a huge deal. didnt think twice, a few drops, no biggie. We ran a few other errands, then got back on the highway going 70 MPH. I heard a low moan at 70 that would come anbd go, I thought I may have had a tire howling on the road or possibly the start of the shifted belt. Noise was intermittent, but went away after a few minutes of driving. another mile or two down the road, I noticed the rear window seemed oily. Suddenly, things began to click, oil blow on the back window, funny noises, drips, something was leaking.
My eyes darted to the gauges, everything was holding up as i made it to the nearest exit another few miles away. As I hit the exit, i noticed the overdrive on off indicator flashing at me on the shifter stalk. I roll to the stoplight at the end of the ramp, suddenly, the tranny slips. There was no slipping on the highway. the truck did get a grip and get me from the light a few hundred feet ( there was a line of traffic behind me) to a parking lot where I could stop and inspect. as i shut it off and peeked under, fluid was pouring out of the bellhousing of the transmission. i called pops, he brought down the truck and trailer and we winched it on, dragged it home.
So, now the truck in in my garage, on the lift (yes, im spoiled) and I'm surveying the damage. oil leaks seem to be directed only from the bellhousing area, other places only have blow by residue on them. Fluid is a little dark, but not burnt smelling, and within tolerance. I see darker fluid at work when I do transmission flushes all the time.
So, now the questions. First off, I would be guessing that the front pump seal decided to go out, does that sound correct to you gentlemen? I'm going to start digging in on removing the transmission tomorrow, and hopefully get it out by the weekend. Also, from the fluid condition, do you think I got lucky, or do you think I did damage to the transmission?
As for knowledge and resources, I'm a mechanic, I do mostly brake, suspension, exhaust, and maintenance work (oil changes, tranny flushes, other stuff like that) so I do have a decent knowledge base, and while I have swapped transmissions before, I dont have a huge knowledge of tier inner workings. I do have access to a scan tool, and other diagnostic instruments, but as i stated before, not a full working knowledge.
Ford F-150 - 1997-2003 :: 2001 - Running Rough When Cold / Stalling Out When Coming To A Stop Light
2 questions regarding our 2001 F150 Supercrew. My 2 questions are:
My 2001 Ford F150 Supercrew (5.4L, 230,000 miles)has the check engine light on with the code reader telling me that it is the P0174. The truck would run rough when cold (usually in the mornings) and sometimes it would get close to stalling out when coming to a stop light. So we would quickly put it in park and give it some gas to rev it up a bit. After the truck gets warmed up, it runs great with no hint of the rough idle. Since this all started I have changed out the PCV valve and replaced the PCV hose (including the elbow). I have also replaced the Idle Air Control unit but that didn't really make a difference.
We then experienced a cylinder #4 misfire which we resolved by changing out the cop with a new Motorcraft unit. The misfire went away but we still had the problem of running rough at idle to the point of stalling out at stops when the engine is cold. A few weeks ago we cleaned the MAF sensor and that seemed to work. The truck doesn't run as rough now (when cold) at stop-lights, but occasionally it will still have the loping idle. We cleared the check engine code and it stayed off for about a week before returning.
I don't know what else to check other than trying to see if there is some type of vacuum leak, but I don't have access to a smoke machine nor would I know how or where to hook one up. Removing and cleaning the throttle body would work? What could be causing the trouble, or what I should do to further isolate or troubleshoot the problem? I saw a you-tube video on the F150 intake manifold gasket possibly being the problem and although I hope that isn't the trouble with my truck, if it is then I will have to deal with it. We need the truck to get to work and the car is now due for a registration renewal, but we can't get a California smog certificate with the check engine light on.
Ford F-150 - 1997-2003 :: 2002 - Overdrive Light Blinking Off And On
My overdrive light is blinking off and on. When I accelerate normally, the truck starts stumbling? (don't know a better word) some, sort of like a clogged air filter or fuel filter. I am going to take it to a transmission shop because its a little beyond me, but don't want to get ripped off.
View 10 RepliesFord F-150 - 1997-2003 :: Overdrive Light Comes On When Put Shifter In Gear
I got a 1999 f150 if you put shifter in gear the overdrive light comes on. When you put it back in park the light goes out.
View 1 RepliesFord F-150 - 1997-2003 :: 2002 - Running Rough And Check Engine Light On
My girlfriend has a 2002 F-150 with the 4.6 V8 and I was going to change the spark plugs for her. She said it started running rough and it threw a code and check engine light. She took it for a scan and they told her the number 5 plug was mis-firing. I'm fairly handy and bought a set of the recommended Motorcraft plugs from Rock Auto, AGSF32PM. It also matched the number in the owners manual so I thought I was pretty safe.
Funny thing, when I took the old ones out, they were AGSF22WM's instead. My thinking is they are a colder plug than the supposedly original equipment, but I don't think they've been changed before. They looked well used but the color was good. The truck has about 135K on it.
Long story short, and to get to the question(s), Would there be any reason the factory would have put a different plug in the engine than what is listed? Am I asking for trouble going with a hotter plug than what's been in there (pinging or timing retardation/loss of power)? Am I just overthinking the whole thing and need to put it back together and drive it?
Ford F-150 - 1997-2003 :: Overdrive Light Flashes - Trans Overheating
2003 F150, 5.4 FX4, overdrive light flashes. Took to a shop they said overheating issue, but I don't understand if it is a overheating issue why does I flash at 4 in the morning when I leave for work fter sitting all night and why does it stop when I do over 70 on the highway.
View 4 RepliesFord F-150 - 1997-2003 :: Check Engine Light Started Flashing / Running Rough Then Went Off
Ok on the way the my 1997 f150 4.6 L 180,000 check engine light started flashing and running rough and then the light went off, Also we took the Aftermarket Dynomax muffler off of it earlier today if that makes any difference, it still has the Cat Converter, New Plugs and Napa Wires.....
View 12 RepliesFord F-150 - 1997-2003 :: 2000 V8 Running Rough At Idle And Check Engine Light On
I started out with my 2000 F150 with a 5.4 V8 running rough at idle. It would idle way down slow and then rev up a little over and over. On a couple of occasions it would even die when in drive or reverse. I did finally get a Check Engine light so i put it on my diagnostic program to see what was up. Here is what I got:
P1151 Lack of HO2S21 Indicates Lean
P0171 System Too Lean Bank 1
p0174 System Too Lean Bank 2
After doing some reading up I checked all my vacuum hoses and cleaned my mass air flow sensor. I then got the same codes again after a few minutes of running. So I went to the next thing that was recommended, the upstream bank 2 O2 sensor. After changing it the truck ran fine for a couple of days, no issues. Then all of the sudden it idled a little funny again and I got a Check Engine Light again. This time:
P0171 Bank 1 Lean
P0174 Bank 2 Lean
P0300 Random/Multiple Misfire
I reset the light to see if I would get the same again later. Before the light came on again I filled my truck up with gas and it seemed to be running pretty good again. Then a day or so later it set the light again. This time:
P0171 Bank 1 Lean
P0174 Bank 2 Lean
P0136 O2 Circuit Malfunction Bank 1 Sensor 2
P0156 O2 Circuit Malfunction Bank 2 Sensor 2
P1131 Lack of Switches HO2S11 Lean
P1151 Lack of Switches HO2S21 Lean
I went ahead and drove for a few days as it had gotten really cold here and I didn't feel like messing around in my shop since it isn't heated. A couple days ago I needed gas so i filled up again. Suddenly the problem was gone again. Truck ran fine idled fine no missing or odd idling at all. That lasted a day or two before it started acting a little weird again. At that point i was down about 1/8 of a tank from full. I have read that there can be issues with the fuel pump.. I am kind of wondering if that may be it now. But I haven't had to deal with this sort of issue before so I am unsure what to check next. The truck always runs fine off idle, it only seems to have the issue when it is idling. I had reset the codes the last time and i have the light on again now. I haven't checked it yet but I am sure it is going be some combination of what i have had in the past.
I have read that the IAC valve can be an issue as well. I had a problem with mine sticking a couple years ago and when it would do it you could just tap it with a wrench and it would idle up. But it never died like it does now and it would also idle a lot slower than it does. Back then I cleaned the valve and had no more issues with it. The truck has always had times when it would act weird at idle usually after slowing down after being at highway speed. The current issue happens at all temps cold or hot.
Ford F-150 - 1997-2003 :: Idling Rough And Check Engine Light Came On After Running For About 20 Minutes
I replaced the heater core in my truck this weekend. The only thing I was worried about was pulling the dash. The truck is a 1998 f150 with the 5.4.. Everything went fairy well and decided to replace the AT Shift cable as well. Got everything put back. Truck runs, no leaks, no antifreeze smell. After running about 20 minutes, it started idling a little rough and my check engine light came on.
The codes are p0136, p0156, p1131, and p1151. I know these are related to the OS sensors. My question is could it be as simple as I miss an electrical connection when putting the dash back in? Was thinking possibly somewhere on the passenger side under the kick plate or possibly something while hooking up the heater hoses? Maybe even a ground that didn't get connected back when putting the das back in?