Ford Excursion :: Water On Carpet At Right Rear After Rain - Weather Stripping Broke?
Every time we get a hard rain, I end up with water on my carpet right at the rear of my Excursion. I'm thinking the weather-stripping has broken down. What is the source for it? All I can find is door weather-stripping.
View 3 RepliesFord Excursion :: Again Got The Message - Emissions Not Ready?
So I took my truck to get inspected/emissions done... And the emissions not ready message came back. What in the.... He said maybe put 100 miles or so on it from when I replaced the battery. Is that the answer? I've never seen such a thing.
View 14 RepliesFord Excursion :: 2004 - Emissions Light Popped On
I've got a 2004 6.8L Excursion (about 124k mileage). Was gassed up yesterday, today the emissions light popped on. I checked the fuel cap and it was on tight. Any other easy things to check before I head down to Advanced Auto to see if they can pop it on the diagnostic machine?
View 5 RepliesFord Excursion :: Loose Wiring Under Hood
What is this supposed to go to? Found it just flopping around under the hood while we were replacing a fuse.
View 7 RepliesFord Excursion :: Hood Release Cable Replacement?
So in order to get my hood to open, I have to pull the hood release lever in the cab, go pull up on the hood itself, then pull the release lever again, and pull on the hood to get it to finally pop. Is this a cable perhaps going bad? Or another issue I need to fix?
View 14 RepliesFord Excursion :: 2005 V10 - Loose Connector While Looking Under The Hood
I recently bought a beautiful 2005 6.8L V10 Excursion with ~90k miles. While looking under the hood, I noticed a loose cable. See attached pictures. Where it may have come off?
View 2 RepliesFord Excursion :: 4 Random Dead Ended Wires Under Hood?
What do these 4 random dead ended wires under the hood go to.
View 3 RepliesFord Excursion :: Screech / Squeal Coming From Under The Hood While Driving
On the way home tonight, the Ex started to make what I can best describe as a screech/squeal. It sounds a little bit like a pulley spinning against a stuck belt or a motor that ran out of grease. I heard it 4 times and it lasted about a second or 2 each time. It seems to be coming from under the hood. The only common variable between all of the occurrences is a speed between 5 - 20 mph.
Belt has been replaced recently, when I looked under the hood all pulleys were spinning normally. The only thing I can think of is maybe it's the re-manufactured power steering pump that I put in after the redhead box install or the a/c compressor. When the compressor is running it makes a ticking noise. Maybe it's finally done and the screech is it starting to spin up when it engages the pulley?
Ford Excursion :: Removing Wires From Under Hood Fuse / Relay Box
Well, it's starting to look like I may have to build my underhood harness from bits of multiple harnesses. I found a 2000 Excursion harness, but the engine plugs and wires were hacked off during engine removal.
After in-depth study of wire diagrams, it looks like I can just get a pickup harness and combine it with the aforementioned damaged Excursion harness to get what I need- and do it for about 50 bucks.
I also notice that there are a few Ebay sellers who just sell the fuse/relay box with the wiring harness hacked off of it. So my question is- how do you remove the wires (including the terminal ends) from the fuse/relay box? I've fiddled around with my burned up parts and can't seem to figure it out.
Ford Excursion :: 2002 - High Pitched Squeal Under The Hood
My 2002 PSD X with 258K miles has a high pitched squeal in the engine compartment. I only had a minute to look at it as my wife was leaving with it. But, I was able to stick my head under the hood and it seems like it is coming from the front of the engine. Trying to pinpoint where the squeal is coming from with all of the other engine noises is tough. I suspect one of the bearings up there like idler pulley, tensioner pulley, alternator, AC compressor, water pump. The alternator has about 70K miles. The other items I don't know.
View 5 RepliesFord Excursion :: V10 - Engine Knock / Loud Noises Coming From Under The Hood
The wife drove the Excursion (V10) to work today and it ran normal and didn't have any loud noises coming from under the hood. When she started the engine to return home it immediately started knocking. This is not a ping, but a knock. Not a loud heavy knock, but much louder than a ping. It has a fast frequency, seems too fast to be a rod knocking. The frequency is similar to a valve issue, but the knock seems to be too heavy for lifters. Oil looks good. Just changed out 2 weeks ago. Truck is driven everyday.
View 11 RepliesFord Excursion :: Smoke Started Coming Out From Under The Hood - Trans Fluid Leaking
I have a 2000 2wd with the 5.4 in it. I tow a travel trailer and loaded is 6500lbs. Today leaving the campground I had to climb an extremely steep hill as soon as you left the campground. No time to build speed. The old Ex made it, but I was definitely worried. The truck ran fine the rest of the 2 hours home. I went to back my camper into its spot to store, and smoke started coming out from under the hood. When I crawled under it, tranny fluid was leaking on the ground. A pretty steady drip. I let it cool down, added fluid and drove around. Didn't leak anymore. Did the tranny just get hot and had to burp? The drip was coming from where the tranny connects to the motor.
View 8 RepliesFord Excursion :: Trans Fluid Leaking Out Of Bell Housing Onto Y-Pipe / Smoke Coming From Under The Hood
A little background info...up until about 6 months ago my 01 Ex V10 was a grocery getter for the wife; only got a few thousand miles a year for the most part. Since we moved from Washington state to Texas it has turned into my daily driver (after a 2500 mile drive towing 8k trailer).
A couple of weeks ago we were running errands and after we got home there was smoke coming from under the hood, but I couldn't pin point it. I let it be because I figure it would let me know when something was really wrong. A few days later it did it again but this time I found the problem; transmission fluid was leaking out of the bell housing onto the y-pipe. I did my research and come to find out it is most likely the front pump seal that got soft from overheating. So my buddy and I drop the transmission and replace the seal. Put it all back together and everything seems great.
Another week goes by and we have driven the Ex fairly extensively around town and even took a couple short day trips and everything is great. Then as we are turning onto an on ramp to get on the highway I give it gas to speed up and all of a sudden the RPMs climb like it dropped into neutral. I had enough momentum that I got over onto the shoulder and started to check thing under the hood. Looked like I was low on trans fluid; ok so I added a quart. Put it in "D" and still nothing. Then I try "1", "2", "R" and they all work fine.
Golf IV R32 :: Gears Stripping / Cracking?
I know that the transmission becomes a problem when you start making big power with the R but I'm trying to find out what actually breaks. Is it the gears stripping or maybe even the case cracking? I saw a thread a while ago about someone making stronger gears but now I can't find it. How well that turned out? Any solution to the tranny problem other than to just be easy in the lower gears?
View 5 RepliesPassat (B5) :: Stripping Of Windshield Completely Disintegrated With Heat
I have a 98 Passat 1.8T with 99,000 miles on her. The stripping on the either side of the windshield has just about completely disintegrated from the desert heat in Vegas. I have tried searching all over the internet but I can't find exactly what I need.
View 2 RepliesCamry :: Extreme Heat Without Stripping The Head Bolt Threads?
Extreme tempertaures in NJ this week.Can this car handle this extreme heat without stripping the head bolt threads? Less than a minute after I start my car in this heat my fan turns on, yet the temp gauge is still below the middle mark..Can this car handle 90 degree + temps (also have A/C) on?2006 Camry Le 60K Miles--replaced coolant around a year ago.
View 10 RepliesElantra MD (2010-15) :: Stripping Noise Whenever Turn On A/C Or Blower For Windshield
I have had noise problem under dash or wherever it may be. I am not sure where the exact location because I can't pinpoint it out. I hear the noise whenever I turn on A/C or blower for windshield. Basically, anything which is related to air will make noise. It's like water striping noise. Something like cold water drops on hot metal. You can hear the noise at night clearly but during the day, it is hard to hear but still is hearable. Besides that, the car is quite. The Hyundai service has changed my blower but the noise is still there. The service man said it was hard for them to know what caused the noise but they had no clue right now.
View 8 RepliesCorolla / Matrix 2009-13 :: Trunk Seal / Weather Stripping Replacement?
How to replace in a 2009 corolla s, the oem trunk seal/weather stripping that goes around the trunk, I am already got the new weatherstrip Toyota part # 6446102130 ...
View 4 RepliesFord - Econoline :: 1997 - How To Open Hood With A Broken Hood Latch
I have a 1997 Ford Econoline conversion campervan that I don't use very often. I need to open the hood to jump start the battery. Last time I opened the hood I did not notice anything wrong with the hood or the hood release latch inside the cab. Now when I pulled the hood release latch inside the cab, nothing happens to the hood at all (the hood does not open at all).
Is there a way I can open the hood or do I need to tow it to my mechanic?