Ford 7.3L Power Stroke (1999-2003) :: Fuel Filter Bowl Drain Valve Replaced - Emission System Warning Light
I just changed the drain valve on the fuel filter bowl. All went well and no more leak, but now I am getting an "emission system" warning light.
After I replaced the valve, I filled the fuel bowl with diesel fuel. Was there any other priming that needed to be done (if any)? What the emission system warning light may mean?
2002 F250 7.3L 4x4.
Ford 6.0L Power Stroke Diesel :: Water In Fuel Light On After Changing Fuel Filter?
Changed fuel filters today. Now my water in fuel light is coming on. But the truck is not running any different no sputtering or anything. ????? Could this be human error
View 14 RepliesFord 6.7L Power Stroke Diesel :: Oil And Fuel Filter Warning
While driving from SD to Chicago today 2 warnings popped up at the same time saying to change the oil and fuel filters. Had both done 2500 miles ago. Am I right that the Dealer just didn't reset these? I thought these were measured by miles and driving habits.
View 8 RepliesFord 6.7L Power Stroke Diesel :: Got Warning Message - Low Fuel Pressure?
Driving back from the funeral and get a Low Fuel Pressure Warning message PPP up in the info display. No CEL's etc thrown (yet?). I have PM23A anti-gel in the tank already but stopped for diesels no poured more in. At the same time, I hear what sounds like an electronic motor making a whirring noise in the dash around the area of the under-hood fuel filter. Also sounds like there is the same noise from the back fuel pump. I assume it's the fuel system starving? Calling the dealer now, but going to continue pressing on cautiously until the truck tells me otherwise.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Water In Fuel Warning
I was about 2 miles from my home today when the Water In Fuel Warning appeared on the dash. I drove home and got everything read to drain the water separator. I crawled under the truck and the wiring harness was unplugged from the filter housing and wrapped around the rest of the harness. I just last week had both fuel filters changed during a routine oil change.
It appears the dealer left the wire unplugged. I drained some fuel just to be safe and as expected found no water. I plugged in the wire and started the truck. The warning went away. Here is my question: Has this event set some stupid bit or trigger in the ECM that Ford can use later to deny a claim? I called the dealership and talked to a tech who said "no". The service manager is supposed to call me tomorrow.
Ford 6.7L Power Stroke Diesel :: Water In Fuel - Warning Light Came On
Not another dumb "water in fuel" post... I had the warning light come on the other day, so I got under to drain the filter. Not much water came out before the diesel, but I let some diesel drain anyway to be sure. What was strange though, was the electrical connection was off. I must have hit something somehow and pulled it out? What I'm wondering, because of the little water that came out of the filter, would the light have come on from the plug getting pulled out?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Water In Fuel Warning Kept Coming On The Dash
On my 2006 6.0 the water in fuel warning kept coming on the dash. After going draining a few times and a few tanks later I knew something wasn't right so I bought a new sensor. When I pulled the old sensor out, it was full of gunk that was like a white jelly. I probably could have just cleaned the old sensor but I put the new one in anyway. My issue went away for a few months when the WIF alert came back. I pulled the sensor out again and sure enough it was gummed up. I've decided to pull that little panel door off and clean the inside. I have a few questions:
1) Can that oring be purchased separatly?
2) Can I just reuse my oring if it still looks good?
Ford Excursion :: Fuel Filter - Water Drain Valve Broken Off
Have had my Excursion for a few weeks now. Took it to the dealer for some maintenance on the brakes. Had them do oil and fuel filters while it was there. Dealer calls to tell me that the water drain valve had broken off when they tried to drain water and the needed to replace the housing. Picked it up today and this is what they found when they pulled off that assembly...
View 11 RepliesFord 6.7L Power Stroke Diesel :: Cleaning Exhaust Filter Message
I got a 2 second "cleaning exhaust filter message" on my drive home tonight in my new truck with about 500km. I completed my drive and pulled off the highway into my yard. I don't know if it had finished cleaning yet but I unloaded the bed and then got back in the truck and drove another mile or two until the fuel economy was normal normal again.
The reason I did this was the underside of the truck was clicking and pinging as it cooled. You could smell the heat. Is it necessary to drive to complete this cycle? Or could I have just pulled in and shut it off. I'm sure it would finish on the highway in the morning. Other then the fuel economy increasing I couldn't tell anything else was going on.
Ford 6.7L Power Stroke Diesel :: Exhaust Filter Over Limit Message And CEL Came On
At the end of hauling ny 5th wheel on a 2 hour drive I received the exhaust filter over limit message and engine light came on. It's a 2015 f250 super duty with 11500 miles. I called the dealer when I got home and he recommended changing the air filter. I did that and then drive 1000 highway miles on a vacation, mostly hauling the 5th wheel. The only light/message I get is the check engine light. The truck will not attempt to regen. P2002 and p24a2 problems.....
View 8 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Filter Clogged Message On Display
My truck started to display exhaust filter clogged and cleaning exhaust filter multiple times today. The cleaning exhaust message stayed on until I hot OK and then it comes back later. Not sure what this means?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Flashed Message - Clean Exhaust Filter?
We have had our Ford 6.7 diesel for a week today and on the way home I am pretty sure it did a regen. It flashed up and said "clean exhaust filter, then the miles per gallon dropped to down around 11 from 15.5 rather quick. The truck smelled really hot and we drove it for about 35 miles to home and MPG started going up and now it's ok. The thing that stumped me was that the truck only has 620 miles on it vs 6.7 miles it had when we bought it last weekend.
View 11 RepliesFord 6.7L Power Stroke Diesel :: Drive To Clean Followed By Cleaning Exhaust Filter Message
I've been having frequent, low speed, short trips lately and have been seeing the 'Cleaning Exhaust Filter' message pop up. Given that I have only been mere minutes from my destination in each case, I thought 'good luck with that'.
Today I see the 'Drive to Clean' message, followed by the 'Cleaning Exhaust Filter' message which stayed on (I have been used to it appearing for only a second or two.)
It should all be fine tomorrow though as I have a longer trip planned.
Ford 7.3L Power Stroke (1999-2003) :: New Fuel Bowl Drain / Water Separator Failure After 3 Weeks?
Had the ole factory fuel separator/bowl drain start leaking on me about a month back. So i ordered and installed a new one, issue fixed. Well last night the fuel leak started again, I looked everywhere and i cant see anywhere else it may be leaking at. I felt the underside of said piece and it didn't feel wet, but the valley is full of fuel.
I got in there and tightened the 4 bolts down some more, they were tight but i got a some turns on em and am hoping i either didn't tighten it down enough or they maybe backed out some. Now just gotta see if that solves the problem, again.... the replacement is a doorman, the o-rings were bigger/thicker than the factory orings on the old part, of which the o-rings were shot.
Like I said once i replaced the part the leak stopped for 3 weeks until last night. If the tightening of the bolts doesn't solve it where should I look next? I have an FRX mod but i checked all that and its dry as a bone around all the fittings by the bowl and the heads. No indications of leaks anywhere around any of the FRX assembly.
Ford 6.7L Power Stroke Diesel :: 2012 F250 - Cleaning Exhaust Filter Message Every 100 Miles Or So
New to Diesel trucks, have a 2012 F250 with 4000 miles on it. for the first 3000 miles I would see regular messages about "Cleaning Exhaust Filter" about every 100 miles or so, but this last 1000 miles I have not seen any?? I drive about 100 + miles a day, 55 to 65 mph so I'm sure I'm running it long enough.
The other thing I've noticed is that my MPG has gone from 17 down to 14 which is what I would normally see during a cleaning cycle. It almost seems like I'm in a constant state of cleaning as my MPG has taken a dive... Any things I should check?
Side note, I towed a 30ft RV around the 3000 mile mark, since the tow I haven't seen the message.
Ford 6.0L Power Stroke Diesel :: Slow Fuel Drip Off The Housing For Fuel Filter On The Engine
I have a very slow fuel drip off the housing for the fuel filter on the engine. Can't see where it's coming from. It started sometime after I changed the filter a couple of months ago.
View 5 RepliesFord 6.7L Power Stroke Diesel :: Active Regen Feel While Driving / Cleaning Exhaust Filter Message On Screen
Last week I picked up a 2016 F-350 with the 6.7 diesel. Since then I have put about 4500 miles on it and gone through 2 or 3 regenerations. About half the miles were empty, half were with about 1500lbs of cargo in the bed. Mostly interstate driving at about 70mph.
However, every time the "cleaning exhaust filter" message comes on in the screen it feels like the truck looses all power for a second. The first time I was going up hill with cruise control set at 70 and it felt like stomping the brakes then hitting the gas all within a second maybe.
Ford 6.7L Power Stroke Diesel :: Fuel Drain Valve Leak At Knob?
Just wondering if your fuel drain valve leaks at the knob when you are draining for water? I opened mine yesterday to drain it for the first time and fuel went EVERYWHERE!! Unlike the 6.4 that I was able to use a bottle to capture the fuel in, my 6.7 leaks around the knob and comes out the drain port. After some very colorful words, I got it drained and then closed. I mean, why put a drain port on it if it is going to come out around the know and soak you.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Reduced Engine Power Warning Message Pop Up
I have seen this pop up on the truck I think 3 times now over the first 4000 miles on the truck.
Usually it's when I'm on the highway around 70mph or so.
It comes on for a few seconds, then goes away. I do have an exhaust / tune on the car.