Ford 6.7L Power Stroke Diesel :: Cleaning Exhaust Filter Message
I got a 2 second "cleaning exhaust filter message" on my drive home tonight in my new truck with about 500km. I completed my drive and pulled off the highway into my yard. I don't know if it had finished cleaning yet but I unloaded the bed and then got back in the truck and drove another mile or two until the fuel economy was normal normal again.
The reason I did this was the underside of the truck was clicking and pinging as it cooled. You could smell the heat. Is it necessary to drive to complete this cycle? Or could I have just pulled in and shut it off. I'm sure it would finish on the highway in the morning. Other then the fuel economy increasing I couldn't tell anything else was going on.
Ford 6.7L Power Stroke Diesel :: Drive To Clean Followed By Cleaning Exhaust Filter Message
I've been having frequent, low speed, short trips lately and have been seeing the 'Cleaning Exhaust Filter' message pop up. Given that I have only been mere minutes from my destination in each case, I thought 'good luck with that'.
Today I see the 'Drive to Clean' message, followed by the 'Cleaning Exhaust Filter' message which stayed on (I have been used to it appearing for only a second or two.)
It should all be fine tomorrow though as I have a longer trip planned.
Ford 6.7L Power Stroke Diesel :: 2012 F250 - Cleaning Exhaust Filter Message Every 100 Miles Or So
New to Diesel trucks, have a 2012 F250 with 4000 miles on it. for the first 3000 miles I would see regular messages about "Cleaning Exhaust Filter" about every 100 miles or so, but this last 1000 miles I have not seen any?? I drive about 100 + miles a day, 55 to 65 mph so I'm sure I'm running it long enough.
The other thing I've noticed is that my MPG has gone from 17 down to 14 which is what I would normally see during a cleaning cycle. It almost seems like I'm in a constant state of cleaning as my MPG has taken a dive... Any things I should check?
Side note, I towed a 30ft RV around the 3000 mile mark, since the tow I haven't seen the message.
Ford 6.7L Power Stroke Diesel :: Cleaning Exhaust Filter Lit Up On Dash When Driving At 55 MPH
New truck does it's first regen at 100 miles!
I Experienced my first REGEN last night. We were on the highway for about 20 minutes at 55 MPH when the dash lit up "Cleaning Exhaust Filter".. The odometer was at 100 miles and it lasted until 115 miles. The fuel economy dropped from 14.6 to 13.9 pretty fast.
There was no notification when it was done with the Regen other than the instant fuel economy gauge climbing pretty quickly.. So 100 miles on it and it was already sooted up??? Is that uncommon?
Ford 6.7L Power Stroke Diesel :: Exhaust Filter Cleaning Notification?
I recently bought a certified used 2012 F-350 a couple of weeks ago. I was reading the diesel insert in the owners manual and came across the exaust filter cleaning notification. I have already put almost 3000 miles on the truck and have yet to see the notification. My brother has a 2013 and said that his comes on every week. I don't know what the previous owner did to the truck, if anything. It is very clean and everything else is stock. I am averaging over 19 mpg combines and it runs great. This is my first diesel truck and I am certain that I will never go back to gas.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Exhaust System Cleaning Message / DEF Level Is Not Being Depleted
In the last year I've had a NOX sensor fault (dealer repaired) and a DEF heater fault (I replaced). I'm now getting an EGT sensor fail. Every fault is with the same system.
I'm also realizing that while I'm getting the exhaust system cleaning message, my DEF level is not being depleted.
All the dealership wants to do is change out fault codes but I think the true issue is elsewhere.
2011 F250 SD FX4 6.7L (stock)
Ford 6.7L Power Stroke Diesel :: Exhaust Filter Over Limit Message And CEL Came On
At the end of hauling ny 5th wheel on a 2 hour drive I received the exhaust filter over limit message and engine light came on. It's a 2015 f250 super duty with 11500 miles. I called the dealer when I got home and he recommended changing the air filter. I did that and then drive 1000 highway miles on a vacation, mostly hauling the 5th wheel. The only light/message I get is the check engine light. The truck will not attempt to regen. P2002 and p24a2 problems.....
View 8 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Filter Clogged Message On Display
My truck started to display exhaust filter clogged and cleaning exhaust filter multiple times today. The cleaning exhaust message stayed on until I hot OK and then it comes back later. Not sure what this means?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Flashed Message - Clean Exhaust Filter?
We have had our Ford 6.7 diesel for a week today and on the way home I am pretty sure it did a regen. It flashed up and said "clean exhaust filter, then the miles per gallon dropped to down around 11 from 15.5 rather quick. The truck smelled really hot and we drove it for about 35 miles to home and MPG started going up and now it's ok. The thing that stumped me was that the truck only has 620 miles on it vs 6.7 miles it had when we bought it last weekend.
View 11 RepliesFord Super Duty (1999-2016) :: Cleaning Exhaust Filter Message
Is this the same thing as the regen? Got it for the first time yesterday at 775 miles. Just curious. On a related note, I've tried to run around town some with 5th and 6th locked out (speeds of around 55-60 on a regular basis, running about 2300-2500 rpms) to try to run this process...am I doing it wrong?
View 10 RepliesFord Super Duty (1999-2016) :: Cleaning Exhaust Filter Message Comes Up On Display For About 10 Seconds
I'm a new Powestroke Diesel owner. I recently (Dec. 2012) picked up a 2008 F-350 Crew Cab, DRW, 4x2 with a 6.4l automatic. Love the truck. Lots of power. Runs great. My question is; while driving, every couple of days the "cleaning exhaust filter" message comes up on the display for about 10 secs. I understand what that message means and what the truck is doing. What I don't understand is, why does the truck seem to run like crap after? It seems to be down a little on power and the idle surges until I shut it off and restart and then everything is fine.
It doesn't matter how long it runs after the DPF cleaning message displays. Also, three times now since I purchased it it has shown a different message, "drive to clean exhaust filter" followed by "cleaning exhaust filter". This message will stay on for many minutes. What is the difference between messages? Is the truck doing anything different? Is it ok to shut the truck off while either of those messages are displayed? The first time it happened I drove around for 15 minutes or so afraid to shut it off! Unfortunately the truck is obviously used and the owners manual was missing.
Ford 6.7L Power Stroke Diesel :: Water In Fuel / Drain Filter Warning Message Came On
During a heavy rain the "water in fuel, drain filter" warning came on. I drained the filter like suggested and a water bottle full of water drained out. This is less then a week after I had the titan fuel tank installed. After I drained the fluid I restarted the engin and "reduce power an water in fuel" warning came on. I am 250 miles from the nearest ford dealer. How major is this???
View 12 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Filter Goes Form 0% To 50% After 130 Miles - Normal?
I'm new to the 6.7 so I'm still learning as much as I can. I recently added the exhaust filter screen to the display using forscan. I had a regen yesterday. I drove the truck until the exhaust filter displayed 0% full. I've driven about 130 miles today and noticed the exhaust filter is now 50% full. That seems really quick to fill halfway up in so few miles. Is this normal? If not what would cause it? I'm really entertaining the idea of deleting the rocket ship under the truck.
View 13 RepliesFord 6.7L Power Stroke Diesel :: 2011 F450 - Exhaust Fluid Warning Message
I have a 2011 f-450 6.7 - truck has 70K miles. The other day I was driving and the message said "Cleaning exhaust filter ". I usually keep it running a little to finish. Then shorty after a warning message came on which said "800 Miles to Exhaust fluid empty". So I went to fill tank and it was FULL. Now the warning keeps showing up each time I start the engine. It now says 300 miles to empty. I'm afraid it's going to go into limp mode even though the exhaust fluid tank is full.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Drive To Clean Exhaust Filter And Check Engine Light
I am at 34,600 miles and had the oil changed yesterday afternoon. My son picked the truck up for me and on his way home the "drive to clean exhaust message" came on with the "check engine light" at the same time. I get home from work, re-check owners manual and no mention of the check engine light coming on with the drive to clean message.
I called my service rep and he says drive it as per owners manual, so I head out drive about 45 miles, averaging 60 mph nothing changes, both lights/messages are still on. Truck seems to be running fine and the last cleaning exhaust message was Sunday and I believe I was out long enough for it to do its job. It will go into the shop tomorrow, but was looking for thoughts from the the rest of you pros before I go.
I mention the oil change only because after the last oil change at around 30,000 miles I drive to work 2 days after and my water pump starts leaking.. coincidence I know.. but getting freaked out as I approach 36000 miles..Truck is a 2011 and I bought it new in Jan of 11.
Ford 6.7L Power Stroke Diesel :: 2012 F350 - Exhaust Fluid System Fault Message
My 2012 F350 Lariat has 6100 miles on it now and on the way home tonight I got a "speed limited to 50 mph in 50 miles" message on the display. It states that there is a "diesel exhaust fluid system fault". The def was topped off about 2000 miles ago and the message center says that the fluid level is "ok". I am going to be on the phone with the dealer first thing in the morning. This is my personal/work truck and if I can't tow a trailer then I can't work. My guess would be a faulty sensor. I have no doubts that the dealer will get this resolved quickly as they have been great about everything else. I also want to say that other than this, I am sure minor issue, this truck is awesome!
View 14 RepliesFord 6.7L Power Stroke Diesel :: Diesel Fumes In Cab During Regen
On the way in to work this morning, I get the "Cleaning Exhaust Filter" message. This was great because I still had about 15 minutes of driving left and it usually comes on right when I am pulling into my driveway. As soon as the regen starts, I can smell diesel exhaust/fumes in the cab (this is going 70 mph on the freeway). When the regen was done, the smell went away. Is this normal? I could understand if I was sitting still getting some exhaust in the cab, but moving at full speed everything should be blowing away. This is my 4th or 5th regen and the first time I have noticed it.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Check Coolant Additive Message While Driving
Driving to work this morning and I get a notification "Check Coolant Additive". Sure, I've got 12,100 miles on it but come on. Dealer dip a test strip in the coolant to check it out. He says it only takes a few minutes to check provided the engine isn't too hot. I guess the "coolant additive" is something that the computer monitors to make sure the coolant is still good.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Regen While Towing Heavy With Low Soot Already?
Over the holiday weekend I towed my 13k# 5th wheel 180 miles to the campgrounds.
According to my Torque Pro app, soot was around mid 30% when I left home. Upon arrival it had passively dropped to single digits.
After driving unloaded a few times over the weekend, the soot level had gone back up to mid 30s.
While towing home it again had passively dropped back to 1.1% .......... then boom! A regen starts.
After 22 miles it completed and soot had dropped to -13.2%.
So towing heavy, passively burning soot off, exhaust temps in the 700-800 weren't good enough for the system.
It had to start a regen and boost tempts to the 1100-1200 range WHILE TOWING to basically burn off NOTHING.
Not to mention drop my already poor MPG to single digits.
Just venting about what appears to be unnecessary exposure to high temps and wasted fuel.