Ford 6.7L Power Stroke Diesel :: 2016 - Got Low Fuel Pressure Message?
I have a 2016 F350 i purchased about a year ago and now has 7500 miles. last night it tossed up a low fuel pressure message and then de-rated then wouldn't start, i heard a crazy humming sound before it shut off. they pulled the fuel filters "claimed it was gelled" even though it fired right up once it got to the dealership. the fuel i run is good to -9*F and i use ford anti-gel on top of that. So they changed the filters and it wouldn't start again. now they are dropping the tank. So, I am not sure what they are gonna find but I am meticulous when it comes to pulling all the foil off of the anti-gel bottle before even opening the cap. I don't know what could possibly be in the tank to cause the issue.
View 13 RepliesFord 6.7L Power Stroke Diesel :: Whining Sound / Low Fuel Pressure And Reduced Power Warning - Fuel Pump Just Died
So, I just had the fuel pump replaced on my '15 6.7 a month ago and it just died again. (next day edit: it didn't actually die, it showed all the same symptoms)
Same symptoms: whining sound, low fuel pressure warning, reduced power warning.
This time I'm 50 miles from home so I pulled off the road before it shut off. Interesting, I was in a hilly area and my low fuel warning came on too. We are waiting for a tow. I was considering trying to push on but don't want to get stuck in a dangerous spot on the highway. We're in a church parking lot.
So, last time this happened I was on flat road with about a half tank of fuel on a lunch break. I ran a mile after the warnings came on to feel out the issue and to see what would happen. I happened to be only about a mile away from my dealer so I drove that way. I got reduced power warning and then it cut power on me (limp mode). I made it to about 100 yards away before it cut off.
This time, I was in a hilly area at night on a windy two lane road with no shoulders in the woods. I was miles from civilization and was showing below a quarter tank of fuel. ~100 miles to EMPTY. I got the low fuel pressure warning first and then the reduced power mode before the whining noise started. I was climbing a hill on a curve at the time. I drove a quarter mile and then pulled off the road into a parking lot so I wouldn't be stuck on the shoulder. It didn't actually go into limp mode.
I let it sit a few minutes, talked it over with the wife and decided to call for a tow. After talking to the tow truck driver who said he would be an hour because he had to go find a bigger truck, I decided to see what I could do while I wait. I fired it back up and the fuel level dropped to below 1/8 and I was now showing 33 miles to EMPTY. I was parked on a hill with the back end up. I had backed the truck into a space to make it easier for the tow truck driver. I let it run a minute, checked for leaks and it seemed to run fine with no studdering or additional warning lights.
CEL was on but no new warnings. I put in my code reader and pulled the P0087. Just one code. I revved it a bit to see if there were any issues. It seemed fine so I decided to try my luck. I started driving towards home with the intention to stop at the first diesel station to fill up. Truck ran fine. After two minutes of driving gently, heart racing, my fuel level came back up and it now read 88 miles to EMPTY. I drove 11 miles to the nearest station and filled up. No issues. I shut it down. I fired it back up. Still no issues so with a full tank, I drove home the remaining 30 miles without issue.
Planning to take it in to the dealer Monday to get it checked. Could this be from an air pocked due to low fuel level and hilly terrain? Is my new pump dying already? Is there something else going on inside the tank or elsewhere?
Ford 6.7L Power Stroke Diesel :: Water In Fuel / Drain Filter Warning Message Came On
During a heavy rain the "water in fuel, drain filter" warning came on. I drained the filter like suggested and a water bottle full of water drained out. This is less then a week after I had the titan fuel tank installed. After I drained the fluid I restarted the engin and "reduce power an water in fuel" warning came on. I am 250 miles from the nearest ford dealer. How major is this???
View 12 RepliesFord 6.7L Power Stroke Diesel :: Low Pressure Fuel Warning Came On
Low-pressure fuel warning came on two separate times Sunday ... I know what caused it the fuel gel 18 below not enough anti gel in the tank no big deal warm the truck up everything's fine now no more warning lights coming on does the dealer need to reset anything I guess I'm asking did it throw a code that needs to be cleared? Its running fine now I guess I'll just have to put a little extra in when it gets that cold wasn't expecting - 18 checked drain no water just gel up could here the pump under the truck fighting to pump for a few minutes.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel Pressure Warning?
65 miles an hour driving down the interstate (I-5) pulling my 5Th Wheel and I look in the mirror and I see at first what I thought was smoke coming from the trailer and then I glanced at my dash and up pops "warning of Low Fuel Pressure". I pulled over as quickly as I could and when I stopped there was diesel fuel spray coming from under the hood. Turned off the key yelled for wife to get out of the truck now. Popped the hood and there was fuel dripping from the engine the all the way to the rear bumper and the front of the trailer.
Since I just had Ford service the truck and change the fuel filters three weeks ago I knew exactly what happened as I looked at the fuel line and seen the green retainer clip wasn't seated properly to the filter canister. I pushed the line in and seated the green clip. What I don't understand is I have driven the truck 200 miles since it was serviced. I re-attached the line and made sure the clip was seated correctly, poured 5 gal of water on the engine plus after using a roll of paper towels to soak up fuel. I didn't want to panic the dear wife but it could have very easily all went up in smoke!
What a mess it made of the Trucks undercarriage and 5th wheel. Going give a call to Ford tomorrow to hear what they can do to clean up this mess.
Question? This happen on a 6.7 after a filter change?
Ford 6.7L Power Stroke Diesel :: Got Fuel Pressure Warning?
Ok here is a good one. Had a low fuel pressure warning so took it in for service. The warning was intermittent. They replaced fuel filter first, but apparently the low pressure fuel pump needs to be replaced.
Service dept is indicating that the fuel pump is not covered as part of my CPO (certified pre owned) 100K drive train warranty or the extended warranty that this dealership sold me. (wasn't a ford plan but was the one they recommended that would cover everything). Lodged my complaint with the Service manager and waiting on a call back.
Does this make sense to any of you service writers out there
Ford 6.7L Power Stroke Diesel :: Getting Low Fuel Pressure Warning Every Morning?
I have been getting a low fuel pressure warning every morning now for a couple of weeks. It normally goes away after the truck warms up, but yesterday it came back on later in the day after a brief cool down.
I am already running ford antigel. I have run cetane boost in the summer and antigel in the winter since new.
Is this considered part of the 100,000 engine warranty or bumper to bumper only?
Truck has 30,000 miles on it, but outside of 36 months.
I'm disappointed in the reliability of this truck to be honest.
Ford 6.7L Power Stroke Diesel :: CEL / Low Fuel Pressure Along With Reduced Engine Power Warning
I just had my first fuel filter change (about 9,000 miles). After the shop changed both fuel filters with factory Ford ones, a check engine light came on and a "low fuel pressure" warning, along with a "reduced engine power" warning. It also stalls a lot and takes a long time to restart.
Obviously, they didn't do it right. I suppose there is air in the lines or something didn't go back together correctly.
My '06 seemed to purge itself, but this truck obviously won't. It is not even driveable to get it back to the station, to see if they can correct the problem.
The thing is, I watched them do it, so if someone can ask me the right questions as far as what I saw, maybe I can lick the issue in the driveway myself.
Ford 6.7L Power Stroke Diesel :: Changed Fuel Filters - Reduced Power And Low Pressure Warning
Changed the fuel filters. No issues in replacing.
Primed them by the book - key on 30 seconds 6 times
Now I have low pressure warning and reduced power.
All parts were FOMOCO...
Ford 6.7L Power Stroke Diesel :: Reduced Engine Power Warning Message Pop Up
I have seen this pop up on the truck I think 3 times now over the first 4000 miles on the truck.
Usually it's when I'm on the highway around 70mph or so.
It comes on for a few seconds, then goes away. I do have an exhaust / tune on the car.
Ford 6.7L Power Stroke Diesel :: Low Fuel Pressure And Reduced Pressure Limp Mode
My truck gave me low fuel pressure and reduced pressure limp mode at 21,000 miles. The fuel and air filters were changed at 16,000. The dealer said all they found was the fuel filters (at 21,000) were what needed to be changed. Also, why does my truck hum??
View 14 RepliesFord 6.7L Power Stroke Diesel :: Truck Won't Start And Low Oil Pressure Indicator Beeps In Message Center
I am towing my 5th wheel RV trailer and just started out on my journey. I've driven 350 miles. I stopped for a breather for about two hours. Now my truck won't start and a low oil pressure indicator beeps in the message center. My truck is a 2011 F250 super duty 6.7ltre diesel. Recently had oil change and fuel filter change.....
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F450 - Exhaust Fluid Warning Message
I have a 2011 f-450 6.7 - truck has 70K miles. The other day I was driving and the message said "Cleaning exhaust filter ". I usually keep it running a little to finish. Then shorty after a warning message came on which said "800 Miles to Exhaust fluid empty". So I went to fill tank and it was FULL. Now the warning keeps showing up each time I start the engine. It now says 300 miles to empty. I'm afraid it's going to go into limp mode even though the exhaust fluid tank is full.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Low Fuel Message After Filling Up At Pump
After filling up today at the pump, the low fuel message is still coming on. My gauge is correct though. How to clear the message. I keep on trying to reset it with the reset button but it doesn't go away.
View 8 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel / Power Message Then Check Engine Light On
My low fuel light came on tonight. I drove about 2 miles, stopped and shut the truck off. When I restarted it and began to drive off to the fuel station a notice came on that isaid power reduced then a check engine light came on. I was about a mile or less from the fuel station so I filled up. I cycled the key but the engine light is still on. No low power message tho. The power is fine.
I came home and drained the water drain on the filter, didn't see any water but hoped it would solve the problem. I cycled the key a few times and started the truck but the light is still on. My truck is a 2013 f350 6.7 and has 211500 ish miles on it. I bought it a month ago with 18500 miles and haven't had any issue until tonight. My only thought is maybe the fuel filters need changed. I don't know if or when the previous owner changed them.
Ford 6.0L Power Stroke Diesel :: Died - Low Fuel Pressure - Blew White Smoke - Diesel Smell?
no change, changed stand pipe and dummy plug on driver side, no change and guess what? Now I am stuck on the side of the road waiting to give my last $100 to a tow truck! Engine is hydrolocked, fuel pressure is low, starts off at around 20 and works up to 54 with key on engine off, and that is as much as I know from the side of the road with out my AE. Blew white smoke also. Smelled of unburnt diesel. I think it's linked to my rough running issue. Maybe a bad injector? But every time I did the click test they all passed. Idk, I'm gonna remove the glow plugs and see which hole is loaded and with what. . .
View 14 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel Pressure Came On?
Driving to work out of town and low fuel pressure came on screen.... fuel filters??
View 14 RepliesFord 6.0L Power Stroke Diesel :: Low Fuel Pressure At WOT
I just installed my fuel pressure gauge, only to find out that I'm running with low fuel pressure at wot. My filters have a little over 2000 miles on them and I've had the blue spring installed for a while now. It drops to about 36psi from 61 or 62psi. What could be the culprit? Also I'm running the out of the box street tune that comes with the sct x4 because I get about 15mpg with it.
View 11 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel Pressure - Sensor?
truck runs fine changed fuel filters could it be bad sensor .no cold weather
View 2 Replies