Avalon 2005-12 :: 2008 - Power Steering Pump Leaking Slightly
What is the life expectancy of the PS pump? car and 255K (08 Touring) it is beginning to leak very slightly....
View 4 RepliesAvalon 2005-12 :: Power Steering Fluid Leaking - Hoses Dried Out
I guess one of the hoses dried out and the fluid is leaking.
Called the dealer to buy a new one but guess what.. They don't sell that hose separate. Only the assembly with the metal line and the price for the whole thing is over $90 + tax .
Red arrow shows the hose that I need and the part number for what dealer sells is 44406
I cleaned everything today and put an extra clamp where the hose is connected to the PS reservoir. Will see if it's going to work for now.
My question is where can I get a piece of hose which will be compatible with PS fluid so I can replace this? Also what is the ID of that hose?
Avalon 2005-12 :: 2006 - Windshield Washer Reservoir Leaking
Evidently, this is not an uncommon problem on 2005 - 2007 models. It is (was) also covered by a TSB. I found a related link below but the links to the pictures are broken. Also, the OP states "remove the splash guard panel on the drivers side" which seems odd since the reservoir is on the passenger side.
2006 Avalon Wiper Fluid Leaking....
Avalon 2005-12 :: 2006 - Washer Fluid Pump Motor Stuck On
On our '06 Avalon Limited, my wife had parked the car was parked in the driveway and about 30 min later I walked by and heard that the wiper fluid pump motor was running non-stop. The only way I could get it to shut off was to loosen the fender liner and reach in and un-plug it. I'm thinking relay, but would it be that, the switch, the motor itself, where should I start and how can I tell or diagnose short of replacing them?
View 3 RepliesJeep - Cherokee :: Power Steering Pump Leaking
I have a 1999 Jeep Grand Cherokee which I bought used. Last oil change they told me that the power steering pump was leaking. The leak was not enough to be seen, but it did seem to make some noise every once in a while so I took it in to get a new power steering pump at the dealer. Two days after they put the new pump in, power steering fluid was pouring out on the driveway, it was a really big puddle of fluid. I had to put new fluid in to drive it five miles back to the dealer. They said that it needed a new line, they were not sure why it needed a new line, they guessed because of the high mileage, 164,000 miles.
I told them that my Mercury has 287,000 miles on it and has never had the power steering pump replaced or the line either. I have driven most every car I ever owned 300,000 miles and have never replaced a power steering pump or line. But anyway, when the Jeep was supposed to be ready, they told me that the new line blew up spraying fluid all over the shop as soon as they started the Jeep and they had to get new parts so it would take another day or two. My question is what caused the new line to blow? My thinking is there must have been something wrong with the new pump or with the installation, somehow it was outputting too much pressure, anything that could blow a new line, would blow the old line.
Ford 7.3L Power Stroke (1999-2003) :: Hose Seal Leaking At Power Steering Pump
Looking for a write-up on replacing the seals on the hose that leaks at the power steering pump? I replace them once but may of over tightened them. I pour in atf and see it dripping on drivers side of power steering pump. Can I just use regular o rings?
View 5 RepliesCamry :: 1998 Power Steering Pump Leaking - Groaning Sound
98 Camry, V6. Power steering pump was leaking and level was low enough that it was groaning. I replaced the pump. 2 days later, more power steering fluid on the ground. Took some searching, but found it leaking from the boot on the rack. OK, very uncommon, but I replaced the rack and did a complete flush, refilled with ATF as recommended. every cold morning since, the pump will groan and steering will be very hard until it warms up... car will then drive normal. I thought maybe the pump had gone dry from the rack leaking and had gotten damaged... replaced the pump a second time... same symptoms!? belt is tight.. Im at a complete loss now...
View 3 RepliesFord Aerostar :: Power Steering Fluid Leaking - Pump Replacement?
Proud owner here of a '96 3.0L RWD Aerostar Utility Van with about 138k miles, and leaking power steering fluid. At this point I'm replacing fluid from zero every time I have to drive it which is about once a week. I've located the leak and it seems to be coming from the pump/reservoir around the pressure hose. The hose is loose as in i can move it around a bit, but from what I've read, this is normal and the hose is supposed to be like that. I figure that at this mileage, with so much air going through the pump, all the crazy squealing and whining it does even when full, at this point it probably makes sense to replace the whole pump while I'm in there, as opposed to just doing the reservoir. Anyway, I'm planning to do this in a couple of weeks, and have some questions...
1) The pump - I've read on this forum that the best way to go on brand of the pump is Motorcraft.
2) Hoses - I'd like to replace the hoses coming out of the pump while I have this thing all taken apart, but I'm not exactly sure what parts to get. I know one is the pressure and one is the return, but there are variations of each based on the research I've done. The parts on the Napa site have different descriptions like "with switch port", "without switch port" "56in hose" "26in hose", and so on. Which ones I need, specifically the ones connecting directly to the pump? I havent been able to find anything in my research online, in Haynes, or Chiltons manuals.
3) Washers - Whether or not I replace the hoses, should I replace the washers at the connection point? Chilton's seems to recommend replacing them. Will they come with the new pump?
My local auto parts shop has the pulley remover/installer for me to rent so I've already got that squared away. I'm pretty sure I've covered all of my bases otherwise.
Avalon 2005-12 :: Power Steering Fluid Looked Dark
I have a 2008 Avalon with 111,000 miles on it. I was messing around under the hood and noticed the power steering fluid looked very dark. I bought a turkey baster and a quart of power steering fluid and did maybe 4 exchanges. During this process I finally paid close attention to what it said on the power steering reservoir "Use Dextron II or III ATF fluid." So, I started exchanging the power steering fluid with the ATF.
View 14 RepliesFord F-150 (2009-2014) :: Oil Slowly Leaking Near The Power Steering Pump Pulley
2010, 5.4L... Noticed a small oil spot under the truck this morning. Took it into the shop after work, we lifted it up, and ran it for 15 min to see where the leak was coming from, and the truck did not leak a drop... until we turned it off. The oil would slowly leak near the power steering pump pulley. But only when the engine was not running ...
View 1 RepliesSubaru - Outback :: 1998 - Leaking From The Power Steering Pump And Valve Cover Gaskets
I have a 98 Subaru Legacy Outback with 133K miles. It was leaking from the power steering pump and valve cover gaskets. My husband replaced the passenger-side valve cover gasket (which involved removing the air box) and the power steering pump (which required removing the alternator). When we put the car back together and reconnected the battery, it no longer starts! It "clicks" once but won't turn-over. The car does not have an alarm system (but it was an option on this model). We've tried jumping it. The battery is about 14 months old. The alternator is about 10 months old and the starter was replaced about 10 months ago too. We've double checked the wires that were disconnected and don't think we've missed anything.
View 3 RepliesLexus SC430 :: Rubber O-ring On Power Steering Pump Solenoid Valve Leaking Fluid
My car is in the shop and has a leak at the Power Steering Pump. The rubber O-ring on the Power Steering Pump Solenoid Valve (p/n 4417030120) is leaking fluid. The Solenoid Valve is ok, just the Rubber O-ring is bad, but it looks like you have to buy a complete new Solenoid Valve to get the O-ring (a lotta bucks).
I did find a Lexus Power Steering Pump rebuild kit online at, but I can't see if it includes the solenoid valve o-ring or not. Have to replace their solenoid valve o-ring?
Santa FE SM (2001-06) :: Power Steering Pump Is Leaking Fluid Onto Serpentine And Timing Belts Causing Them To Swell
So I have multiple issues that all seem to stem from a power steering leak. According to the dealership, the PS pump is leaking fluid onto the serpentine and timing belts causing them to swell. This in turn has something to do with the AC compressor not working but they wouldn't give me details. When I looked at the clutch wheels on the AC compressor, there seems to be a good amount of rust in between the two wheels. I can't say that I trust the dealership because the original owner was bought out by a larger group that is known to just say "replace everything". I usually do most of my own work on my 95 Tacoma, so I'm no stranger to import v6 motors.
View 4 RepliesAvalon 2005-12 :: 2006 - No Power / No Cranking And No Clicking Either
My parents have a 2006 Avalon. I put a new battery in it in November of 2014. It gets driving 1-2 times per week. I went to drive it today and I pushed the start button and nothing. No clicking - no nothing. I jump started the battery thinking that was it. There was spark between the cables and the battery and the dash lights came on but it wouldn't start - no clicking either. I disconnected the jump starter and the dash lights went out and nothing. no headlights, no cranking, no clicking no dashboard lights.
View 3 RepliesFord Escape / Hybrid :: 2005 - Power Steering Pump Replacement
We are a 2 Escape family. We have an '03 and an '05 - both 4WD and 3.0 V6. My college freshman son purchased the '05 this summer to get to and from his summer job. It has a little over 173K on the clock and it has a power steering leak, so I decided to try to tackle this one.
There is a fairly good video on YouTube on replacement of the power steering pump on an '03 - but apparently on the '05 Ford decided to relocate the pump from under the upper right engine mount to a lower location closer to the front bumper so the video is not of much use in this case.
I have searched the web and this site but cannot find any tips or instructions to replace the power steering pump on the '05. The Chilton Manual I have does not acknowledge the difference in the power steering pump location on the '05 and only provides the procedure for those Escapes where the pump is located under the upper engine mount.
I think I may be able to get better access by removing the inner fender plastic and perhaps the front bumper cover, but would really like to know the accepted procedure before I start tearing into this one.
One interesting bit of info regarding power steering fluid on these vehicles. Ford designed them to use automatic transmission fluid (Mercon) instead of power steering fluid. Initially, when I saw the leak, I thought it was a tranny line leak. Then I traced it to the front of the engine which is totally on the opposite side of the vehicle from the tranny lines.
Honda - Accord :: 2005 - Power Steering Pump Growls When Cold / Cool
2005 Honda Accord Growls When Cold/CoolLast winter on real cold days (okay, real cold in Houston, TX, means around freezing to about 40 degrees), a loud growl came from under the hood. The growl stayed until things under the hood warmed up a little. While it was warming, the growling would slowly diminish; however, if the steering wheel was deflected, it would aggravate the growling noise. I checked the fluid in the power steering pump, and it was fine. I did some on-line research, and it appears that the Honda's power steering pump's bearings might be going bad. Is there anything that can be done preemptively to avoid the expense of replacing the power steering pump? (I hear they are expensive to replace.) Last month I was in Kansas City and the growl was barely audible on a 64 degree morning. I fear it is getting worse and will not last long.
View 2 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Power Steering Pump Replacement
When replacing the power steering pump on my 2006 should I go OEM on the pump or save some money and get a Napa or aftermarket remaned unit with the pulley installed? Also, whar is the fluid capacity of the power steering system?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 - Power Steering Leaking Bad
So this '06 F350 is blowing fluid from the steering pump fitting when you move steering wheel to either side all the way(lock). Is the internal o-ring blown in the fitting? Do these have the teflon seal at the pump? Pretty new to the 6.0 scene. Got a new line ordered.
View 6 RepliesSonata NF (2006-10) :: 06 Power Steering Pump Whining
I recently replaced the harmonic balancer on my 06 sonata v6.... the rubber was separating from the pulley. About 2 days later, i notice the power steering pump whining, so i checked the fluid and it was at the correct level. I have 98k miles, is it safe to assume i just need to change the power steering pump, is it possible anything else could be causing this problem? I doubt it is related to the crank pulley change, probably more a coincidence but wanted some opinions. Also, if it is the power steering pump.
View 29 Replies