Ford 7.3L Power Stroke (1999-2003) :: 2000 E350 - Overdrive Light Is Flashing - Shifts Hard
Here is my issue. I have a 2000 e350 7.3 the overdrive light is flashing, the speedometer and the odometer isnt working it also shifts hard, i changed the vss, the vss plug, range sensor, and alternator. still acting up. also all the fuses are good.
View 8 RepliesFord - Explorer :: 1991 4X4 - Overdrive Not Working
My 1991 Explorer 4.0 4x4 overdrive not working, so far have checked ohms on sensor at trans and it appears to be ok. Also looking for the pinout of PCM under passenger kick panel to see if voltage is being output to the sensor at trans.
View 1 RepliesFord Super Duty (1999-2016) :: 2012 - Transmission Burns Up At 60k Miles?
This F250 has 60130 miles on it. A week ago the transmission would not engage and we had to have it towed to the dealership, so we called roadside assistance. Finally getting the report from the dealership we are verbally told that the transmission pump failed and the clutches have burnt.
The work is submitted for warranty. Last night we get a phone call that they are denying the warranty because the truck has been neglected/abused. So I asked for the service paperwork. The service paperwork states, SEALS FAILED ALLOWING CLUTCHES TO FAIL, NEEDS CLUTCHES, SEALS, AND PUMP TO REPLACE.
When I call to get clarity on the definition of neglect and the justification, I am told the inspector was shown burnt clutches and a muddy truck. When I ask about the pump and seals, I am told the inspector was never shown 1 failed seal, and the pump was fully assembled and did not appear defective.
So I call the dealership back and ask for an explanation and they tell me they will research it and get back to me. When they call me back their story is not just that the clutches failed, nothing else and that they are just replacing the pump and seals because it is recommended. The notes given by the technician to the warranty folks now state that the clutches burnt and the truck was muddy so he knows we abused it.
It would slip and then knock into gear. Transmission was service 5000 miles ago by dealer, we were told it was good, in good working order, fluid looked great, no issues.
Ford Transmission :: 1989 AOD Transmission Stuck In Overdrive
My '89 Ford Crown Victoria Country Squire is a 5.0L with the AOD transmission. Yesterday, I slowed from 40 mph to 25 mph to turn on my street. As I drove up the street's slight incline I noticed the acceleration was sluggish as if the transmission had not downshifted from 4th to 3rd. When I stopped to back into my driveway, the engine shuddered and stalled as if it was hooked to a manual transmission and I had released the clutch with the shifter in an upper gear. My wife had to push the car into the driveway (she is a Minnesota farm girl ).
Now the engine starts normally with the gear selector in Neutral. It shudders and stalls the moment I try to put it in any gear or Park. The engine will not start in Park, but once again, balks as if I was trying to start a manual transmission equipped car without depressing the clutch or taking it out of gear.
The transmission and engine had been working perfectly before the above sudden problems. My guess is that the transmission is somehow stuck in overdrive.
Is there any way to knock it out of 4th gear? Why would the engine start in Neutral but not Park? It is the original AOD transmission with over 230K miles on it, but this car has at least nine lives and I am hoping this is another serious problem that turns out to be not so serious!
Ford Transmission :: E350 - Auto Gear Shift?
How the auto gear shift works on a ford E350.Does it work by wires or does it have a steel column to change the gears.I have looked for pictures but with no luck. I have spent 2 hours looking.
View 4 RepliesFord Transmission :: 1998 E350 - ATF Leak Near The Mount?
Noticed an ATF leak on my van on crossmember/tailpiece mount awhile ago. Not the driveshaft seal but near mount. Checked tightness of bolts on case and mount and found the one mount bolt that goes into transmission case loose- about one whole turn.
(other bolt is on an "ear" of tranny case) Checked again after a couple of weeks and leak is worse, same bolt is loose again.
Is there a gasket or O-ring on this particular bolt? 1998 Ford E-350 with 6.8L - trans code E on door sticker. I believe it is an E4OD as the tranny pan says "Metric" (?) 324,000 miles on this and runs/shifts fine. Occasional vibe issue at highway speeds... I've added 1 quart of ATF over this time period.
Ford Transmission :: 1993 E350 - Whine At 50 Mph Under Throttle Not Coast
I just came across a deal on a 93 E350 motorhome for dirt cheap. It has a whine at 50 mph and believe its the rear end. The whine is under throttle not coast.
There is a tag on the axle housing that reads :
4:10 a diamond shape 2US AC
760553
Is this a Dana 60? Looks like a Dana.
Ford Transmission :: 1987 E350 Does Not Drop To First Gear To Accelerate
I have a 1987 e350 conversion. Recently the vehicle has been acting up. Once warmed up, the transmission does not drop back into low/1st gear when stopped at a light, when we go to accelerate the vehicle has no power as it tries to accelerate in drive. I have to manually shift into first which the transmission immediately kicks down. When it comes to transmissions I like to have some knowledge before bringing to a shop.
View 2 RepliesFord Transmission :: 1989 E350 - Trans Appears To Be Slipping When Get Around 50 MPH
I have a 1989 tioga 460ford and the trans appears to be slipping when i get around 50mph. The engine revs up but it won't go more than 50. The engine again revs up but there does not feel like the power of the engine is being transferred to the trans. the coach runs fine up until i try to go beyond 50. I have 34000 miles on the rig. Some one suggested that I check the catalytic converter. what else should i look for?
View 2 RepliesFord Transmission :: 1987 E350 - Clank Noise When Shifting In To Drive
Our Rv makes a strange "clank" noise whenever we shift into drive. It is a 87 Ford Econoline 350 with the 460 7.5l. The noise is from the back of the Rv kind of near or in the rear differential. It just started over this past weekend.
We live in Alaska and the mechanics are 3 hours away - do you think we would be able to make it to the mechanics and not have to get a tow? How long we could go without fixing the problem?
Ford Transmission :: 1992 E350 - Trans Slipped And Lost Drive
Quick question. I have a 1992 Ford E-350 Box Truck and during a recent highway trip the transmission slipped and I lost Drive (3rd). The van drives fine in 1st, 2nd, reverse, and overdrive. When it's in D, it wont move at all from a stop. I'm able to get it in to overdrive by starting in 2nd, accelerating to about 35mph, then shifting it in to D. If I accelerate enough after shifting to D, I can usually get it to shift in to OD. The fluid is full and clean.
View 1 RepliesFord Transmission :: 1997 E350 - Hard To Move Gear Selector
I am just about committed to purchasing a 1997 Ford E350 extended cargo van with the 5.4. The transmission shifts through all the gears nice and firm (reverse also works). The only issue with the van is the column selector lever is very hard to move between the entire range of PRND21. It also does not "click" into the selected positions, you have to just line up the pointer to the desired gear selection.
Is this a complete deal breaker (internal transmission issue/replacement necessary) or, is it something relatively simple (such as a worn selector cable). The owner did admit the van has been sitting for sometime. It has 134,000 miles on it.
Ford Transmission :: 1992 E350 - Pinging Almost Tapping Noise As The Truck Was Stumbling
Started having an issue with my '92 E-350 box truck. I noticed a slight hesitation while driving which I thought was a miss from perhaps a plug wire jumping or something. It didn't do it all the time, just occasionally for a few seconds then would clear up. I looked for a bad wire at night but couldn't find anything so I said hell with it and changed plugs and wires, cap and all.
That didn't fix the problem. Progressively the problem has gotten worse. Then I started hearing a pinging, almost tapping noise as the truck was stumbling. Now I've noticed that the motor seems to be running fine as it does it which has led me to think it may be in the trans.
A little background on the trans. About 6 months ago the van started randomly conking itself out coming to a stop after a few minutes of driving. It seemed the trans was bogging the motor down as if it were locked together. If I put the truck in neutral coming to a stop it wouldn't do it. I went ahead and had my uncles shop flush the trans and he put some sort of synthetic fluid in it.
Since then the van has never done the cutting off thing again. All seemed well. Then this started. It does it from take off through all the gears even in OD. It almost feels as if someone is rapidly hitting the brakes. I thought maybe malfunctioning brakes however soon as I'm not pressing the accelerator it doesn't do it.
Today I had about 4000 lbs of wood in truck and it was a horrible trip. The truck would barely get up to speed. I unloaded the wood and on the way home it only seemed to do it going up hills so it seems any load on the truck makes it happen.
Does it seem I'm in the right area thinking transmission?? Being it happens in every gear would a torque converter seem to be a possibility. When I was having the cutting off problem I was told it sounded like the converter wasn't unlocking but the flush seemed to fix that issue.
I haven't pulled the pan to see if there's any surprises in it and I did the diagnostic check and there wasn't any problems found. Any other manual diagnostic checks?????
Ford Transmission :: 1994 E350 - OD Light Flashing And Trans Shifting Hard
I have a 94 E350 with a 7.3 diesel. I took it to the Ford dealership to have a new fuel filter and oil change when I got it back the OD light was flashing and transmission shifting hard. They tell me they cannot find a problem could they have possibly knock a wire off of something to make this happen...
View 3 RepliesFord Transmission :: 2007 E350 - Shudder When Accelerating In OD - Whine In Park / Neutral
Looking for your collective expertise
2007 E350 with 5.4L and 4R70W trans. 107K miles and the fluid has probably never been changed ( my mistake - thought it was 100K interval - finding out from my reading that is def not true ). Anyway, following is recent development (last couple days):
Symptom #1: In Park/Neutral there is a whine. As soon as you put it in P or N, the whine 'spins up', stabilizes, and does increase with engine RPM.
Symptom #2: Hesitation (albeit minor) when starting from stop in D and R, with _very_ minor shudder. Sometimes feels like it's struggling a bit to move its own weight just until it's rolling.
Symptom #3: Shudder when accelerating in OD. No shudder when I turn off OD. It does not stop when applying brakes (a test suggested elsewhere). Also, the shudder does not happen when applying gas while braked in D at standstill. Only at highway speeds (enough to be in OD).
This all started at the end of a trip (90 miles or so in 85-90 degrees) when I was pulling a utility trailer (maybe 2000 lbs loaded). Not sure if related, but traction control warning went off a couple times. I think I have a axle seal leak that may be triggering that.
Otherwise shifts fine (no change in shift behavior or smoothness). Things seem to be worse when it has heated up. Should I start with a fluid change? Wasn't sure because there are comments out there saying don't do it or the tranny will just fail faster (I am skeptical).
Ford Transmission :: 1999 E350 V10 - Speedometer Bouncing - O/D Flashing And Harsh Shifting
Vehicle: '99 E350, V10
Symptoms: speedometer bouncing, O/D flashing, harsh shifts. Symptoms do not present until the van has been driven at highway speeds for about 20 miles. Then, the speedometer starts to bounce a little. Then, after another 5 - 10 miles, the O/D light starts to flash. Then, with a few more miles, the harsh shifting begins.
Parts replaced: neutral safety switch, rear ABS/speed sensor (twice), instrument cluster.
Each time after I replaced a part, when I drove the van, all was fine until it had been driven at highway speeds for about 20 - 25 miles, regardless of whether the engine was warm or cold. Where to go next with it?
Ford 7.3L Power Stroke (1999-2003) :: 2001 E350 Transmission Not Shifting Properly
I recently purchased a used 2001 E350 with a 7.3L and the transmission is not shifting properly. It will go into Reverse no problem, put it in "D" and it starts in high gear and will not shift out. If I manually shift from 1 to 2 to "D" it works fine and will even go into OD. It will not down shift on its own either. What should I do to fix this issue?
View 2 RepliesFord - F250 :: 1997 - Transmission Goes Out Of Overdrive?
I and a friend both have 1997 ford F250 Diesel pickups and both at about 140,000 miles have had problems with the transmission going out of overdrive and changing gears at higher than usual rpms. The overdrive light blinks and if the pickup has a day or two it will reset the computer and function normally. Any fix easier than a new transmission???
View 5 RepliesFord Transmission :: 1995 - No Overdrive Trans Shifts
I have a 95 f150 5.0 with a 4r70w Trans. What to check now no overdrive Trans shifts and drives great but no od the od off light on shifter is lit up and just never goes into overdrive solenoids have been replaced and new shift lever and button where do I go from here is not throwing any codes...
View 7 Replies