Ford Transmission :: 2007 E350 - Shudder When Accelerating In OD - Whine In Park / Neutral
Looking for your collective expertise
2007 E350 with 5.4L and 4R70W trans. 107K miles and the fluid has probably never been changed ( my mistake - thought it was 100K interval - finding out from my reading that is def not true ). Anyway, following is recent development (last couple days):
Symptom #1: In Park/Neutral there is a whine. As soon as you put it in P or N, the whine 'spins up', stabilizes, and does increase with engine RPM.
Symptom #2: Hesitation (albeit minor) when starting from stop in D and R, with _very_ minor shudder. Sometimes feels like it's struggling a bit to move its own weight just until it's rolling.
Symptom #3: Shudder when accelerating in OD. No shudder when I turn off OD. It does not stop when applying brakes (a test suggested elsewhere). Also, the shudder does not happen when applying gas while braked in D at standstill. Only at highway speeds (enough to be in OD).
This all started at the end of a trip (90 miles or so in 85-90 degrees) when I was pulling a utility trailer (maybe 2000 lbs loaded). Not sure if related, but traction control warning went off a couple times. I think I have a axle seal leak that may be triggering that.
Otherwise shifts fine (no change in shift behavior or smoothness). Things seem to be worse when it has heated up. Should I start with a fluid change? Wasn't sure because there are comments out there saying don't do it or the tranny will just fail faster (I am skeptical).
Ford Transmission :: 1993 F250 - Sometimes No Shift Until Lift The Throttle
I have a 93 F250 diesel 4X4 with the automatic, the transmission was rebuilt by a reputable shop les than 10000. miles ago, every few months it will act up, it will act like I put it in neutral then it slams back in gear, then it shifts very hard, sometimes it will not shift until i lift the throttle. Sometimes I can shut it off and when i start it again it will be back to normal, other times it will do this for a few days, then work fine for another month or two.
View 5 RepliesFord Transmission :: E4OD Coast Clutch Resistance Check
Last weekend my 95 F350 developed an issue where it feels like something in the transmission is dragging in reverse and it moves forward in neutral. This happened suddenly. One minute it was working fine and the next it was acting up. I found some info that leads me to believe that it might be the coast clutch solenoid causing the problem. Today I tested the resistance of the coast clutch solenoid through the PCM connector. I used pin 55 and pin 37 to test it. The resistance is supposed to be between 20 and 30. I got 0. My meter read the same as putting the leads together.
Am I correct in thinking that I need a new solenoid pack or at least a coast clutch solenoid?
Ford A/C :: 1993 E350 - Blower Motor Vibrates Quite A Bit While Making Whirring / Buzzing Noise
I have a 1993 E350 Econoline-based RV. The blower motor intermittently makes a horrible whirring/buzzing sound, usually if on position 3 or 4 (high). Doesn't stop until I turn the HVAC to Off. The blower motor vibrates quite a bit while making this noise (verified with my hand). The problem occurs even if the engine isn't running. This started a few years ago, and has simply gotten worse.
Since it runs OK at the lower speeds (until the problems start with the higher speeds), I think that means I can rule out something simple like debris? Also, when the engine is under load (climbing hills, etc.), the blower fan cuts out. Could that be a resistor problem, or something else?
Lexus RX 2010-15 :: 2011 RX350 AWD - Transmission Downshift During Coast To Stop
I recently just purchased a 2011 Lexus RX350 AWD... I would like to ask on the downshift while slowdown the car.... Every once in a while I feel the tranny down shift while slowing down... It's not harsh or anything, but just enough to have a slight feel. Like a backlash? Is this normal? I also have 09 GS350 AWD.. It's so smooth that I can't feel the downshift at all...
View 11 RepliesFord Transmission :: C6 Transmission Whine - Truck Gets Much Louder When Under Load At About 1700 - 1900 RPM
The video below IS NOT my truck, though my truck makes the same sound. Mine isn't nearly as loud as the truck in the video at idle, but gets much louder when under load at about 1700-1900 rpm. If you take it easy accelerating it doesn't get any louder than at idle. At cruising speed in third it isn't audible. The trans in my truck is a 1979 C6. Again, not my video. Same noise though.
Transmission whine - YouTube....
Elantra MD (2010-15) :: Manual Transmission Loose - Gears Make Noise As Shift From Coast To Drive
Ok so my transmission feels loose, too much play between the coast and drive side of the gears. Makes enough noise now that my wife complained about it so I'm looking into taking it to the dealer. I pretty much expect them to pass this off and do nothing, but its getting worse especially in the last couple of months.
Noticed a lot of play in there gearbox? Can you hear the gears make noise as they shift from coast to drive side?
Ford - E350 :: 1991 - Goes In And Out Of Overdrive - Burns Up The Transmission
We recently purchased a 1991 Minnie Winnie (Winnebago) which rests on a 1990 Ford E350 chassis. It only has 58k miles. While driving on the freeway or highway, the Overdrive starts to go in and out; downshifting and upshifting willy nilly. It has a manual button for turning off the Overdrive and when I do this, it stops jerking and drives smooth. But, of course, this effects the gas mileage significantly. I took the Minnie to a garage recommended by the company I purchased the Minnie from. They replaced the manual Overdrive switch and replaced the transmission with a rebuilt Ford transmission.
We got it back and it was okay for one trip but by the second trip, it was doing the same thing again. I took it back to the garage and since it was under warranty, they put in a new rebuilt transmission, another new Overdrive switch, a new fuel sensor and checked the wiring but it still had the same problem. So they sent the onboard computer board to Ford who rebuilt it. The guys at the garage thought for sure this would resolve the problem. It didn't. They have exhausted their ideas as to what is causing this problem. We love the Minnie Winnie and other than this problem it is in beautiful condition.
Ford Transmission :: E350 - Auto Gear Shift?
How the auto gear shift works on a ford E350.Does it work by wires or does it have a steel column to change the gears.I have looked for pictures but with no luck. I have spent 2 hours looking.
View 4 RepliesFord Transmission :: 1998 E350 - ATF Leak Near The Mount?
Noticed an ATF leak on my van on crossmember/tailpiece mount awhile ago. Not the driveshaft seal but near mount. Checked tightness of bolts on case and mount and found the one mount bolt that goes into transmission case loose- about one whole turn.
(other bolt is on an "ear" of tranny case) Checked again after a couple of weeks and leak is worse, same bolt is loose again.
Is there a gasket or O-ring on this particular bolt? 1998 Ford E-350 with 6.8L - trans code E on door sticker. I believe it is an E4OD as the tranny pan says "Metric" (?) 324,000 miles on this and runs/shifts fine. Occasional vibe issue at highway speeds... I've added 1 quart of ATF over this time period.
Ford Transmission :: 1987 E350 Does Not Drop To First Gear To Accelerate
I have a 1987 e350 conversion. Recently the vehicle has been acting up. Once warmed up, the transmission does not drop back into low/1st gear when stopped at a light, when we go to accelerate the vehicle has no power as it tries to accelerate in drive. I have to manually shift into first which the transmission immediately kicks down. When it comes to transmissions I like to have some knowledge before bringing to a shop.
View 2 RepliesFord Transmission :: 1989 E350 - Trans Appears To Be Slipping When Get Around 50 MPH
I have a 1989 tioga 460ford and the trans appears to be slipping when i get around 50mph. The engine revs up but it won't go more than 50. The engine again revs up but there does not feel like the power of the engine is being transferred to the trans. the coach runs fine up until i try to go beyond 50. I have 34000 miles on the rig. Some one suggested that I check the catalytic converter. what else should i look for?
View 2 RepliesFord Transmission :: 1987 E350 - Clank Noise When Shifting In To Drive
Our Rv makes a strange "clank" noise whenever we shift into drive. It is a 87 Ford Econoline 350 with the 460 7.5l. The noise is from the back of the Rv kind of near or in the rear differential. It just started over this past weekend.
We live in Alaska and the mechanics are 3 hours away - do you think we would be able to make it to the mechanics and not have to get a tow? How long we could go without fixing the problem?
Ford Transmission :: 1992 E350 - Trans Slipped And Lost Drive
Quick question. I have a 1992 Ford E-350 Box Truck and during a recent highway trip the transmission slipped and I lost Drive (3rd). The van drives fine in 1st, 2nd, reverse, and overdrive. When it's in D, it wont move at all from a stop. I'm able to get it in to overdrive by starting in 2nd, accelerating to about 35mph, then shifting it in to D. If I accelerate enough after shifting to D, I can usually get it to shift in to OD. The fluid is full and clean.
View 1 RepliesFord Transmission :: 1997 E350 - Hard To Move Gear Selector
I am just about committed to purchasing a 1997 Ford E350 extended cargo van with the 5.4. The transmission shifts through all the gears nice and firm (reverse also works). The only issue with the van is the column selector lever is very hard to move between the entire range of PRND21. It also does not "click" into the selected positions, you have to just line up the pointer to the desired gear selection.
Is this a complete deal breaker (internal transmission issue/replacement necessary) or, is it something relatively simple (such as a worn selector cable). The owner did admit the van has been sitting for sometime. It has 134,000 miles on it.
Ford Transmission :: 1992 E350 - Pinging Almost Tapping Noise As The Truck Was Stumbling
Started having an issue with my '92 E-350 box truck. I noticed a slight hesitation while driving which I thought was a miss from perhaps a plug wire jumping or something. It didn't do it all the time, just occasionally for a few seconds then would clear up. I looked for a bad wire at night but couldn't find anything so I said hell with it and changed plugs and wires, cap and all.
That didn't fix the problem. Progressively the problem has gotten worse. Then I started hearing a pinging, almost tapping noise as the truck was stumbling. Now I've noticed that the motor seems to be running fine as it does it which has led me to think it may be in the trans.
A little background on the trans. About 6 months ago the van started randomly conking itself out coming to a stop after a few minutes of driving. It seemed the trans was bogging the motor down as if it were locked together. If I put the truck in neutral coming to a stop it wouldn't do it. I went ahead and had my uncles shop flush the trans and he put some sort of synthetic fluid in it.
Since then the van has never done the cutting off thing again. All seemed well. Then this started. It does it from take off through all the gears even in OD. It almost feels as if someone is rapidly hitting the brakes. I thought maybe malfunctioning brakes however soon as I'm not pressing the accelerator it doesn't do it.
Today I had about 4000 lbs of wood in truck and it was a horrible trip. The truck would barely get up to speed. I unloaded the wood and on the way home it only seemed to do it going up hills so it seems any load on the truck makes it happen.
Does it seem I'm in the right area thinking transmission?? Being it happens in every gear would a torque converter seem to be a possibility. When I was having the cutting off problem I was told it sounded like the converter wasn't unlocking but the flush seemed to fix that issue.
I haven't pulled the pan to see if there's any surprises in it and I did the diagnostic check and there wasn't any problems found. Any other manual diagnostic checks?????
Ford Transmission :: 1994 E350 - OD Light Flashing And Trans Shifting Hard
I have a 94 E350 with a 7.3 diesel. I took it to the Ford dealership to have a new fuel filter and oil change when I got it back the OD light was flashing and transmission shifting hard. They tell me they cannot find a problem could they have possibly knock a wire off of something to make this happen...
View 3 RepliesFord Transmission :: 1999 E350 V10 - Speedometer Bouncing - O/D Flashing And Harsh Shifting
Vehicle: '99 E350, V10
Symptoms: speedometer bouncing, O/D flashing, harsh shifts. Symptoms do not present until the van has been driven at highway speeds for about 20 miles. Then, the speedometer starts to bounce a little. Then, after another 5 - 10 miles, the O/D light starts to flash. Then, with a few more miles, the harsh shifting begins.
Parts replaced: neutral safety switch, rear ABS/speed sensor (twice), instrument cluster.
Each time after I replaced a part, when I drove the van, all was fine until it had been driven at highway speeds for about 20 - 25 miles, regardless of whether the engine was warm or cold. Where to go next with it?
Ford A/C :: 1993 F350 - Vacuum Leak / Air Conditioning Shutting Down Upon Giving Throttle
Trying to track down an air conditioning problem. Seems like a vacuum leak somewhere is screwing with my AC and shutting it down upon giving it any throttle (hills etc). Where should I look first or is there a certain area that is prone to leaks?...truck is a stock 1993 F-350 460/auto.
View 1 Replies