Prius (2010-12) :: Fill Up Gas Tank At 3 Bars?
I'm sure it's been asked before but why even show the gas level and claim those miles in the range. Also is there any way to tow this thing and while I'm here is there any way to use a floor jack on these.
View 19 RepliesPrius Plug-in 2012-15 :: Gas Fill Ups - Full / Half Tank Or Less?
Since purchase, I've had one gas fill up at 694 miles. That was four or five weeks ago and it's still full. My EV ratio is 65% (1100 miles) and will continue to increase. I realize I'm carrying a lot of dead weigh for weeks. For those with high EV mode use, what's your recommendation with gas fill ups? I'm thinking no more than fives gallons for daily commute and around town.
View 14 RepliesPrius (Gen 2) :: Fuel Gauge Stuck On 2 Bars - Unable To Pump Gas Into The Tank
I have a 2006 Prius, 149,000 miles. The gas gauge has just become stuck on 2 bars. I discovered this after attempting to fill the gas tank. I was unable to pump the gas into the tank. The pump kept clicking off immediately. I was able to slowly put about 3.5 gals of gas in the tank, but very slowly. I also tried to add gas from a gas can, and the same problem occurred: the gas would go in very slowly. I have never had the fueling problem where the pump repeatedly clicks off. I tried several gas stations that had pumps that worked for me in the past, and didn't have any luck. The fuel gauge failure and the gas pumping problem have appeared simultaneously.
View 1 RepliesPrius (2004-09) :: Unable To Get Fuel In Tank - Reverse Light Keeps Blinking
I am unable to get fuel into the fuel tank. the reserve light keeps blinking even after several gallons of fuel has been poured in. Now the battery has gone off and the car is not moving at all.
View 1 RepliesPrius C :: Pump Shut Off While Filling Gas Tank
Can't figure this one out. I've had the car about 9 months and this is the first time I've ever had an issue filling it up with gas. Basically, if I tried to pump it much faster than a trickle, the pump would shut off. It must have taken me five minutes to pump a little less than nine gallons in. And the frustrating part about that is that you never know which of the click-offs is the one you should stop at.
View 19 RepliesFord Ranger / B-Series :: Hard To Fill Up - Gas Pump / Hose Keeps Shutting Off
The gas pump/hose keeps shutting off when I fill my tank. The problem is progressively getting worse. No Codes. Truck runs fine. I looked at the filler neck and filler hoses. They appear to be original but no obvious signs of an issue...
View 9 RepliesAccent LC (2000-05) :: Can't Fill Up Gas Tank
My wife has a 2002 Accent with 117K miles on it. Fuel pump has never been replaced, but fuel filter and PCV valve changed about 5K miles ago.
The problem started when I added some BG44K fuel injector cleaner to the gas tank by way of a funnel. There was no discernable change in the car until my wife tried to fill up with gas...it kept clicking off. This has been going on for some time and it's pretty annoying.
So I do some research and learned that there could be charcoal pellets in the venting lines coming from the charcoal canister. I removed the charcoal canister from the car, and sure enough, there were a lot of little pellets in the hoses. I disconnected all the hoses and shook out all the pellets (not from the box, from the hoses) and connected everything back up. I went to the gas station and...nope, still clicking off every 2 seconds.
Then I removed the fuel filler neck from the car and inspected it. There were no restrictions in the main tube and no restrictions in the tube that runs up the main tube and loops back down the other side. [b]The blue/black check valve was a little clogged, so I blew it out with compressed air. I reinstalled it with the arrow pointing towards the charcoal box - meaning air and/or fuel can travel towards the canister only. Should the check valve be facing the other way? I assume it should, so gases can vent from the canister to the atmosphere - I don't want air/fuel going into the box, right?
I did find a restriction in one of the smaller hardlines that is connected to the fuel filler neck - it was more charcoal pellets. It was really clogged and I had a hard time removing them. At this point, there are no clogs, restrictions or charcoal pellets in any of the lines (including the charcoal canister), yet I still cannot properly fill the tank. Is the check valve now my only problem?
My wife told me today that the car "felt funny" and didn't "go when she stepped on the gas". Another symptom of the check valve?
I'm not entirely sure why adding fuel injector cleaner would have caused this problem.
Camry :: 05 Solara - Cannot Fill Up Tank Without Stopping
As title says, I cannot fill up tank without pump cutting off every few seconds.
View 2 RepliesHyundai - Elantra :: 2000 - Gas Tank Won't Fill
Like a lot of others, my 2000 Elantra will just barely take gas at the pump. So I've done the research, I think I understand the problem, but when I tried to find the replacement filter, there seem to be 4 different parts ranging from $8 to $180. Which part should I order and order first, or should I just replace them all?
View 4 RepliesToyota - Camry :: 2002 Won't Start After Fill The Tank
Background: My 02 camry (155k) ran great but I noticed grease/oil on the front of the engine so I had a local mechanic take a look. He replaced the front valve cover gasket, timing belt, and while he was in there, the water pump. He made me take it to the dealer to reset/recalibrate the stability control sensor because after disconnecting the battery to perform the work my "VSC", "trac off" and check engine lights were on. I got it back along with a list of work they thought I needed (replace the rear valve cover gasket, dog bone engine mount, and a bunch of bs I don't need).
Problem: Quickly my check engine light is back on. I fill up gas and I can't get it to turn over. The owner of the shop gets it to turn over by gassing it a bunch while turning the key. My mechanic later tells me the check engine light is due to a bum gas cap. He replaces that and the dog bone mount. Next day check engine is back on AND the next time I get gas the same thing happens - it won't turn over until I gas it, then it turns over and stalls a few times until I really gas it and it turns over and takes. Every other time I try to start the car it turns over first try. Both times I filled up I wasn't close to running out of gas or anything. I don't think the gas cap or the fuel injectors went bad coincidentally the same day the dude had his hands in the engine.
Passat (B5) :: Gas Tank Overflow At Fill-up / Venting System?
When filling the gas tank, the pump shuts-off (as it should) unless the tank filled very-very slowly. It has overflowed/spilled before the pump even shut-off in some cases.
CEL is not on. DTC 16826 stored: "EVAP Emission Contrl.Sys (small leak) Leak Detected". I just got a VAG-COM cable but haven't got the software going
yet.
Bentley has some diagrams for the fuel vapor recovery system but that's about it. Seems like there's something with the fuel vapor recovery / venting system going on. How to further diagnose?
'01 Passat 1.8T ....
Sonata I45 (YF - 2011+) :: AC Blow Colder Air When Fill Up The Gas Tank
Is it just me or does the AC blow colder air when I fill up the gas tank... without fail, after every fill up I notice colder air coming out the vents than previously before I fueled up. what's going on???
View 1 RepliesElantra XD (2001-06) :: Gas Tank Will Only Fill About Half Way Before Clicking Off
At seemingly random times when I take my Elantra to the gas station it will only fill the tank about half way before clicking off. After doing some quick google searches I'm leaning towards something being wrong with CCV system. I read that over filling the tank can cause debris to clog the system and a few months back my father-in-law borrowed it he has a tendency to overfill the gas tank. But I've also read that there's an error code that tends to pop up with it and so far there's been none. Either way I'm not familiar with how the CCV and related systems work.
View 3 RepliesSonata I45 (YF - 2011+) :: Gas Tank Won't Fill Up / Pump Stops
After pumping for a few seconds the pump stops because it thinks the tank is full. I have been searching for other 2011 Sonata owners with this problem but can't find any. I see it on older cars, something about charcoal pellets, but not on new cars. Could this be charcoal pellets on this car? The car is still new, why would this happen?
View 26 RepliesMetro :: 2000 - Hole In Gasoline Tank Fill Tube
2K Metro has a hole in the gasoline tank fill tube, between the gas cap and tank. It doesn't leak only when putting gas in. Is this hard to change or patch? I just found a replacement fuel filler neck. Is this hard to change. Can you change it with gas in the tank if you're careful?
View 4 RepliesChevrolet - 1500 :: Can't Fill Tank / Pump Cuts Off After 7 Gallons
Can't fill the tank in my 1981 Chevy 1500 Truck; pump cuts off after 7 gallons. I took the vent tube and the fill hose off and there are no blockages.
View 8 RepliesFord - Edge :: 2010 - Can't Fill Gas Tank Up To Its Full Capacity
I have a 2010 ford edge. The last two times I tried to fill the gas tank, the nozzle on the pump shuts off as if the tank is full. The tank has not reached it's capacity. I have to "dribble" the gas into the tank, and even then it seems to be backing up the pipe. A simple two-minute fill takes ten minutes.
View 3 RepliesElantra XD (2001-06) :: Cannot Fill Fuel Tank / Gas Overflows When Filling
I have an 04 Elantra GT. My gas gauge is showing full but the car is running out of gas. I try to fill the tank and I get the annoying click and after trying for a few, gas comes up the filler and overflow tube and makes a mess. At the same time, I was getting a P0449 code. I got an evap canister from the junkyard and that seems to have gone away.
Tried diagnosis but dropping the fuel tank to access the lines. When I jack the tank back up into position, you can hear gurgling sounds and as if the gas is coming up the fill tube. I also opened the access panel under the seat to see the pump assembly and when I removed the 8mm bolts, gas came pouring out. There was definitively gas in there. Checked the float on the pump assembly and it moved?
There is also something at the fuel neck at the top. Don't know what it is and if that could also be part of the problem.
Elantra XD (2001-06) :: Gas Vapor Lock At Pump Won't Fill Tank
Son was unable to fill his car's gas tank, 2002 Elantra (but happens to all cars sometimes).
The vapor lock on the pump kept shutting the gas flow off.
This was caused by the tanks vapor exhaust being unable to exit while filling, so the only place to go was back up through the gas fill hole.
The charcoal filter had sprung a leak so the zillions of tiny little charcoal pellets pour from the filter into the rubber hose clogging it.
The Filter is $150 at Hyundai. Not available at AutoZone or OReilys.
Very simple to replace a couple bolts a few hose clamps.
Strange problem, thats no one at work had encoutnered before. A few Hyundai mechanics had heard of it and worked it before.
Also could be Purge Valve or Vent Valve solenoids...search EAP system too if your having this issue of not being able to fill your tank with gas, without 500000 vapor locks shutting the pump off!