Sonata I45 (YF - 2011+) :: Gas Tank Won't Fill Up / Pump Stops
After pumping for a few seconds the pump stops because it thinks the tank is full. I have been searching for other 2011 Sonata owners with this problem but can't find any. I see it on older cars, something about charcoal pellets, but not on new cars. Could this be charcoal pellets on this car? The car is still new, why would this happen?
View 26 RepliesFord Fuel System :: Fuel Tank Blow Back When Try To Fill It Up
I just changed my fuel tank and now when I try to fill it up it keeps blowing back it never did this before.
View 2 RepliesGolf IV / Jetta IV :: 2003 - Some Vents Blow Colder Than Others When AC Turned On
I have a 2003 Jetta GLI. When i turn my a/c on some of the vents blow harder and colder than the others. Why that would be?
View 10 RepliesSonata I45 (YF - 2011+) :: Remove / Install Gas Fill Door
My wife cracked in half the gas fill door on our 2012 SE. I ordered a new one online and painted it to match our car. I cannot figure out how to get the old one out and install the new one. I removed the 4 screws around the gas filler tube but how do I access the back to get out the old hinge?
View 5 RepliesSonata I45 (YF - 2011+) :: AC Does Not Blow Cold Air When Stopped At Red Light
When I'm stopped at a red light for a while I notice that my car doesn't blow cold air anymore, there's tons of blowing but feels like its just normal outside air being blown into the cabin even with re circulation on and AC on.
I've tried turning the AC on and off again at the light, and nothing changes...
I also notice sometimes the AC would decide to blow a little stronger, then let off again. Not sure if the problem is RPM related , i.e. IDLE issue or what.
Just wanted to see what fellow i45+ owners had in mind to what could be causing this issue... I've read something about condenser being clogged, and what not, but I have to be sure.
It works again and starts blowing cold air as long as I'm moving, so I guess it's not that big of an issue, but the hot temperatures here in South Florida can surely give you heat strokes in matter of minutes.
Sonata I45 (YF - 2011+) :: Gas Gauge Showing Empty When Having Half Tank
Its been happening often where it shows empty (when i really have half a tank) and my avg mpg resets itself. As I am driving it will go back to normal.
View 11 RepliesSonata I45 (YF - 2011+) :: Miles To Empty Reading Not Consistent After Filling Tank
This just gets stranger by the month. I could have sworn when I first got this 2011 Sonata that the console read 341 after filling it up for the first time. I thought it had said that after I filled it the second time (just after Hurricane Sandy - yes, before the long lines - I was lucky) and it read 329. On those occasions the console had read approx 67 & 69 miles to empty. I know I filled it with 87 the second time around. The first time may have been with 89. And when it stopped at 14.x I thought to myself, hmm, didn't it fill to 15.x the first time? Weird. So I went on with my life.
This past weekend it read 50 miles to empty and so I filled it again with 87 (same gas station I should point out). And just like the last time, before this time, it filled with 14.1xx and read 288 miles to empty. It just seems to me that "Miles to Empty" has slowly gone down. On the third filling I believe it may have read 303 to empty.
Is it me? I am imagining things here. Could have that much sludge/dirt/whatever it my tank because of the gas station I visited or the 87 and not 89 that I have been putting in? Oil and filter were changed in mid October and then again in mid March. Thats about to happen again on the 28th but also to have the required NYS Inspection done. What should I say to them if anything? Could I have picked that crappy of a local area gas station?
Accent LC (2000-05) :: Can't Fill Up Gas Tank
My wife has a 2002 Accent with 117K miles on it. Fuel pump has never been replaced, but fuel filter and PCV valve changed about 5K miles ago.
The problem started when I added some BG44K fuel injector cleaner to the gas tank by way of a funnel. There was no discernable change in the car until my wife tried to fill up with gas...it kept clicking off. This has been going on for some time and it's pretty annoying.
So I do some research and learned that there could be charcoal pellets in the venting lines coming from the charcoal canister. I removed the charcoal canister from the car, and sure enough, there were a lot of little pellets in the hoses. I disconnected all the hoses and shook out all the pellets (not from the box, from the hoses) and connected everything back up. I went to the gas station and...nope, still clicking off every 2 seconds.
Then I removed the fuel filler neck from the car and inspected it. There were no restrictions in the main tube and no restrictions in the tube that runs up the main tube and loops back down the other side. [b]The blue/black check valve was a little clogged, so I blew it out with compressed air. I reinstalled it with the arrow pointing towards the charcoal box - meaning air and/or fuel can travel towards the canister only. Should the check valve be facing the other way? I assume it should, so gases can vent from the canister to the atmosphere - I don't want air/fuel going into the box, right?
I did find a restriction in one of the smaller hardlines that is connected to the fuel filler neck - it was more charcoal pellets. It was really clogged and I had a hard time removing them. At this point, there are no clogs, restrictions or charcoal pellets in any of the lines (including the charcoal canister), yet I still cannot properly fill the tank. Is the check valve now my only problem?
My wife told me today that the car "felt funny" and didn't "go when she stepped on the gas". Another symptom of the check valve?
I'm not entirely sure why adding fuel injector cleaner would have caused this problem.
Camry :: 05 Solara - Cannot Fill Up Tank Without Stopping
As title says, I cannot fill up tank without pump cutting off every few seconds.
View 2 RepliesHyundai - Elantra :: 2000 - Gas Tank Won't Fill
Like a lot of others, my 2000 Elantra will just barely take gas at the pump. So I've done the research, I think I understand the problem, but when I tried to find the replacement filter, there seem to be 4 different parts ranging from $8 to $180. Which part should I order and order first, or should I just replace them all?
View 4 RepliesPrius (2010-12) :: Fill Up Gas Tank At 3 Bars?
I'm sure it's been asked before but why even show the gas level and claim those miles in the range. Also is there any way to tow this thing and while I'm here is there any way to use a floor jack on these.
View 19 RepliesPrius (Gen 2) :: Hose Shut Off - Unable To Fill Gas Tank All The Way
This has happened to me a couple of times...last night most recently. My gas gauge was flashing so I stopped for gas.
I was only able to pump 3-4 gallons, before the hose shut off and every attempt to continue filling after that would only go a second or two before the hose shut off again.
I was careful I though to allow fumes not to build up since I imagined that might be why the hose was shutting off.
I drove for a few miles and later that night stopped again at the same station and was able to fill up as expected.
Toyota - Camry :: 2002 Won't Start After Fill The Tank
Background: My 02 camry (155k) ran great but I noticed grease/oil on the front of the engine so I had a local mechanic take a look. He replaced the front valve cover gasket, timing belt, and while he was in there, the water pump. He made me take it to the dealer to reset/recalibrate the stability control sensor because after disconnecting the battery to perform the work my "VSC", "trac off" and check engine lights were on. I got it back along with a list of work they thought I needed (replace the rear valve cover gasket, dog bone engine mount, and a bunch of bs I don't need).
Problem: Quickly my check engine light is back on. I fill up gas and I can't get it to turn over. The owner of the shop gets it to turn over by gassing it a bunch while turning the key. My mechanic later tells me the check engine light is due to a bum gas cap. He replaces that and the dog bone mount. Next day check engine is back on AND the next time I get gas the same thing happens - it won't turn over until I gas it, then it turns over and stalls a few times until I really gas it and it turns over and takes. Every other time I try to start the car it turns over first try. Both times I filled up I wasn't close to running out of gas or anything. I don't think the gas cap or the fuel injectors went bad coincidentally the same day the dude had his hands in the engine.
Passat (B5) :: Gas Tank Overflow At Fill-up / Venting System?
When filling the gas tank, the pump shuts-off (as it should) unless the tank filled very-very slowly. It has overflowed/spilled before the pump even shut-off in some cases.
CEL is not on. DTC 16826 stored: "EVAP Emission Contrl.Sys (small leak) Leak Detected". I just got a VAG-COM cable but haven't got the software going
yet.
Bentley has some diagrams for the fuel vapor recovery system but that's about it. Seems like there's something with the fuel vapor recovery / venting system going on. How to further diagnose?
'01 Passat 1.8T ....
Elantra XD (2001-06) :: Gas Tank Will Only Fill About Half Way Before Clicking Off
At seemingly random times when I take my Elantra to the gas station it will only fill the tank about half way before clicking off. After doing some quick google searches I'm leaning towards something being wrong with CCV system. I read that over filling the tank can cause debris to clog the system and a few months back my father-in-law borrowed it he has a tendency to overfill the gas tank. But I've also read that there's an error code that tends to pop up with it and so far there's been none. Either way I'm not familiar with how the CCV and related systems work.
View 3 RepliesMetro :: 2000 - Hole In Gasoline Tank Fill Tube
2K Metro has a hole in the gasoline tank fill tube, between the gas cap and tank. It doesn't leak only when putting gas in. Is this hard to change or patch? I just found a replacement fuel filler neck. Is this hard to change. Can you change it with gas in the tank if you're careful?
View 4 RepliesChevrolet - 1500 :: Can't Fill Tank / Pump Cuts Off After 7 Gallons
Can't fill the tank in my 1981 Chevy 1500 Truck; pump cuts off after 7 gallons. I took the vent tube and the fill hose off and there are no blockages.
View 8 RepliesFord - Edge :: 2010 - Can't Fill Gas Tank Up To Its Full Capacity
I have a 2010 ford edge. The last two times I tried to fill the gas tank, the nozzle on the pump shuts off as if the tank is full. The tank has not reached it's capacity. I have to "dribble" the gas into the tank, and even then it seems to be backing up the pipe. A simple two-minute fill takes ten minutes.
View 3 RepliesElantra XD (2001-06) :: Cannot Fill Fuel Tank / Gas Overflows When Filling
I have an 04 Elantra GT. My gas gauge is showing full but the car is running out of gas. I try to fill the tank and I get the annoying click and after trying for a few, gas comes up the filler and overflow tube and makes a mess. At the same time, I was getting a P0449 code. I got an evap canister from the junkyard and that seems to have gone away.
Tried diagnosis but dropping the fuel tank to access the lines. When I jack the tank back up into position, you can hear gurgling sounds and as if the gas is coming up the fill tube. I also opened the access panel under the seat to see the pump assembly and when I removed the 8mm bolts, gas came pouring out. There was definitively gas in there. Checked the float on the pump assembly and it moved?
There is also something at the fuel neck at the top. Don't know what it is and if that could also be part of the problem.