Ford 7.3L Power Stroke (1999-2003) :: Long Cold Crank / Hot No Start
I have a early 99 f250 super duty 7.3l and it's giving me fits. about a month ago the truck started to do a hot no start. drove truck for about a hour. Shut it off and half hour later no start. Let it sit over night and would start with long crank.
Changed CPS no change. Pulled tuner and set back to stock. No change.
Changed fuel filter, no change.
After reading forums changed IPR and truck started and ran great. About a week ago back to the same problem. Battery's are about 2 months old. Oil change and oil filter a month ago.
Checked the hpop reservoir and its 1/2 from the top.
Checked fuel bowl and it has fuel. no sign of oil in it.
Drained bowl and watch bowl fill back up. seems to fill quickly.
Pulled passside valve cover to check for bad orings while cranking.
Every thing seems fine. have not done driver side yet. used FORSCAN and ran buzzed test on injectors and they all buzzed what seems to be about the same. ran test couple of times to make sure. this morning I ran a live scan while cranking and this is what I got right before it started. ICP 660.6psi, IPR 64.84% and RPMs 227. took 8.86 seconds to start. after work scaned again for hot no start and this what I got. ICP 292.9psi, IPR 55.86%. and RPMS 203. unplug ICP and no change. still will not start. one thing I did notice when plugging ICP back in I looked down in side at the pins and can see what seems to be bubbling around one of the pins. the pig tail has just the slights sign of oil.
Passat (B5) :: Engine Would Finally Start After Few Tries
She has a 2000 Passat. This has kind of been a recent problem where we would turn the key, hear a single click, and nothing would happen. After a few tries the engine would finally start. This has been going on for a few weeks. Now, it just won't start. The car only has 55k miles on it. Starter motors don't die after so few miles do they? I was going to check the battery first though.
View 3 RepliesCamry :: 1995 / 2.2 - Won't Start Randomly Until Crank On It For A Minute Or So
I have a 1995 Camry 2.2 that will run perfect for 2 weeks, them randomly it won't start unless you crank on it for a minute or so. Parts I have replaced are fuel pump, fuel filter, ignition coil. This problem has occurred when the engine has been at operating temp and at initial start up.
View 4 RepliesFord Super Duty (1999-2016) :: 7.3L Suddenly Start Taking More Cranks To Finally Fire Up On First Start
I don't drive the truck much anymore but over time my MPG has gone to total crap...about 10mpg around town...and that's baby-ing it.
Now it suddenly takes many cranks to finally start on a first start. (cold or warm days)....
Sonata I45 (LF 2015+) :: Long Crank / No Start?
I have about 3400 miles on my Sonata 2.0T, and I have experienced a long crank with (puttering in between), and does not start, twice occurrence thus far. I have no warning lights, no lamps (SES) that stay on afterward, nothing at all. I have had to press the "start/stop" button again to make it stop, then let it sit for a few seconds press the button again, re-cranks, and starts this time. I know that if take to the dealer they will not find anything wrong since most concerns they have to duplicate in order to diagnose. The SES light is not on, so I know we have no fault codes to go by. Sounds as if the fuel pump is crapping out, or no spark is being generated.
View 8 RepliesCamry :: 2007 XLE - Long Crank Times To Get The Car To Actually Start
My grandma has a '07 XLE 4cyl with around 65K on it.
Every once and awhile, completely intermittent, no consistency whatsoever it takes 4 seconds or so to get the car to actually start. Normally 1-2 seconds.
Was going to change plugs. See that you have to replace the whole pump/strainer assy. in the tank, no stand-alone filter.
No DTC's or any other lights on. Wondering about replacing the whole pump/strainer assy. will fix it or what the deal is. Can't order it online at Advance Auto parts, and called their store and the Denso one they show isn't even listed as available at the factory. Hope you don't need an OEM one, sure that's not cheap.
Chrysler - Lebaron :: Long Crank And Hard To Start Seems Like No Gas
I own a really nice original ' 89 Chrysler Lebaron coupe with the 2.5 N/A, throttle body injection and 3 speed automatic. It has just over 100k miles. The car sits in the garage all the time and is not used during the winter months and is never used in the salt season. I do "try" to start it sometimes just to keep the battery up. The problem is when I want to start it, especially after sitting for a while, often it will crank and crank but won't start. It's acting like it has no gas. When I take the aircleaner lid off and dump a little gas in, it fires up just fine then runs perfect after that. Even after it has been used as a daily car after that, when I shut it off, sometimes it will start just fine, other times it won't, then I have to use the gas can again. It has a mind of it's own. When you think it will restart, sometimes it won't. I've been keeping a little gas can in the trunk in case it does happen at odd times. With the gas can, it will always restart. I've talked to a few shops about this, they have no idea what might do this. Naturally, when I brought it in to show it to them, it would ALWAYS restart for them. Getting rid of this car is not an option for me, I love the car, except for that part of it.
View 10 RepliesFord - Explorer :: 2002 V6 - Long Crank Time Before Start
So my 2002 ford explorer with the 4.0 L V6, has been cranking along time before it starts. I thought i had this figured out already, i put a brand new fuel pump in it from the ford dealer. That seemed to work, but the problem came back.
Especially when it is cold, it cranks a lot longer than normal to start. and when it does start RMPS go way up briefly and come back down. Seems to only act up when its cold out, say 35 degrees and lower.
So the remote start wont work because it only cranks for a few seconds and then stops. it tries this three times and it gives up. i go out there to start it and cranks for 10 seconds it seems like, sometimes i have to feather the fuel pedal.
Volvo :: 1990 - Long Crank Then Eventually Start But Run Real Rough
1990 Volvo 760 4 cyl. Turbo. Drove the car to work, everything fine. Got off work, car wouldn't start. Cranked but wouldn't start. It was getting spark. Changed the fuel filter, it ran perfect for a month. Drove it to town a month later, shut it off, then trying to start it, would crank and crank eventually start but run real rough. We got it home....barely.
Replaced the fuel filter again. Still wouldn't run right.
Replaced the fuel pressure regulator. Same problem.
Replaced the throttle positioning switch. Same problem. Replaced the air control valve. same problem.
Found out that this car has an on board diagnostic doo hickey.
Found out how to check each sensor and component individually.
All sensors and components are working. Checked both fuel pumps and they are working. If I unplug the air flow sensor and the air control valve sensor, I can start the car using starter fluid and it will idle all day with out missing a lick.If I plug in either one of the sensors, it will kill it immediately.I don’t know what else to do to make this machine run.
Civic - Honda :: 1995 - Hard To Start In The Rain / Crank For Long Time
Car does not have to get wet, just be in humid air. Problem going on 2 years now, mechanics tried disconnecting a (?) ground/sensor from computer, major tune up, new fuel pump. Until recently, it just took keeping it in crank position for a long time for it to finally start. Recently, in crank position for 30 seconds does nothing and has me worried I'm doing damage. In dry weather, it starts first time every time.
View 12 RepliesFord 6.0L Power Stroke Diesel :: Long Crank To Start - Setting Code 2285?
Long crank to start hot and cold. Acts like missing when its cold tho and when it warms up it runs ok but it will set code weafher warm or cold and u can turn it out with scan tool and drive and it wont come back till restarted again...
View 1 RepliesFord 6.0L Power Stroke Diesel :: Long Crank Time To Start After Oil Rail Removal
Removed my oil rail to replace standpipes/dummies (04 Wavy rail) and now I have huge crank times to start. This is after the initial Huge crank to get it started. Do I have air in the system, or did I bugger something. I did the whole deal very careful. I lifted the rail up very carefully, pipes removed. I lined up the rail nipples with the injectors and evenly pressed it back in place, and then inserted my dummies/standpipe. Tightened the rail to 120 inch lbs then the dummies/standpipe to 60 ft lb. I did my son's '06 a month ago with no troubles. (didn't remove rails though). Once running it sounds perfect, turn it off and re-start and it's a long crank (30 seconds or more). I have not monitored ICP/IPR while running, will try that today.
View 8 RepliesFord 6.0L Power Stroke Diesel :: Long Crank / Idle For A Couple Minutes / Died And No Start
I need to get my oil cooler replaced but that's besides the fact. I drove it on a little trip the other night ran fine. Then went to start it after i was done with what i was doing turned it over didn't start the first time. Cycled the key and cranked it again. Started up drove it back home on the high way no spitting or sputters got off the high way it started idling like crap and shaking as i accelerated but made it home. Let it sit over night and day (was at work) got home to start it and it fired up no problem but still idled funny.
Revved it a couple times and it seemed to clear up so i took it around the block. Floored it and it ran like it was suppose to then go to the other side of the block floored it again and it had no power and sounded like it was running on 4 cylinders. Pulled it back in the driveway idled weird and cleared up again went down the street and floored it ran like a scaled ape and then just died. tried cranking it over and nothing finally got it to start after holding the ignition on ran and then died again. Got it pushed home and decided to fire again after a VERY long crank and it idled for a couple minutes very horrible and died on its own and hasn't started since.
Passat (B5) :: 1999 V6 Doesn't Crank / Start - No Window Will Go Up Or Down
I have a 1999 4DR V6 Passat and today was not my day. I got to work around 8am this morning, and parked. Forgot my window was down, so I turned the ignition on to roll up the driver's side window like normal, and the window does not go up. In fact, no window will go up or down. I have full power, from what I can tell. All lights work, radio works, AC works, etc... Door locks and my alarm doesn't work either.
This also boggled my mind; the car wont start?!? The car won't even crank. It doesn't even want to try to start. This all happened at the same time. What could have happened? The battery has 12.8 volts and the car drove fine on the 1 hour commute. I disconnected the battery and reconnected hoping to reset anything that may have happened. But that didn't work.
Ford 6.0L Power Stroke Diesel :: Long Crank Start And No Oil Pressure When Warm - Codes P2290 And P2291
As the title says I am suddenly having a long crank when starting and low oil pressure when when warm (above approximately 100 degrees). IPR goes to 85% when cranking. Stored codes were P2290 and P2291. Other symptoms are low power and what sounds like a power steering pump with low oil whine and low power. (It is not power steering related however, I checked.) I pulled the oil filter and cranked engine and filter bowl filled in less than 10 seconds.
Oil did have a fair bit of air bubbles. Oil has 5000 miles and is Motorcraft 10w30 diesel. I have not added any since the last change. I do not have the new style pump so it's not the STC fitting. What my issue is? I do have AE if any other info is required. Particulars are in sig. The searches I have done combined with the mileage I have lead me to either the low pressure pump is failing, or the high pressure pump has lost the ball bearing out of the side.
Ford 7.3L Power Stroke (1999-2003) :: 2002 - Long Crank Even Plugged In
Little background- this is my first winter in a diesel truck. When I purchased it- it had 4 glow plug codes. Everyone around me just told me to plug it in and fix it later, that if I plugged it in, glow plugs don't matter much.
Had hard starts all last week with temps down to -20, turns out my block heater wasn't turning on due to a bad cord. Replaced cord end today. Let the oil temp get up to around 60F according to torque pro.
Still had a long crank despite warmer oil (15ish outside). Batteries dip to around 10V when plugs are on, then cranks at around 11V. Lots of white smoke which I know is normal.
I still had to fight with it a little bit to get it to start, as soon as she was actually going- runs flawlessly, no lope, no smoke. Runs and drives flawlessly. If I turn it off, she fires right back up instantly every time without hesitation, until she cools off again.
From what I'm seeing I'm thinking my batteries are fine, and my starter is probably fine. Are glow plugs making this big of a difference even though the truck is plugged in?
Truck has 0 codes when warm, 0 blow by, drives fantastic, Just under 300k miles. The only thing I'm thinking of is the glow plugs need swapped. I have a set of ZD11s sitting in the truck waiting for a warm day.
Ford 7.3L Power Stroke (1999-2003) :: Repair Of High Oil Use And Long Crank?
Parts came from Riffraft Diesel Performance. A set of "o" rings for the injectors. High flow CVD fittings for the fuel lines. Turbo rebuild kit. (its got 210,000+ miles) Anti Surge compressor wheel.(ok its not part of the oil problem)
Photos to come. I will take during the rebuild.
Ford 7.3L Power Stroke (1999-2003) :: 2001 E350 - Long Crank Before Starting
I have a 2001 E-350 w/7.3. When I start the truck first thing or when engine is cooled down it starts fine. I checked the high pressure pump pressure and it is 500 - 600 psi start up great. But when engine warms and try to start it it has long crank before starting. I checked pressure and it is between 425 to0 450 and takes awhile for it to get to 500 or better. Is this a cause of the high pressure oil pump ? I changed the oil and still does same thing. Also I noticed that after engine is hot and I try to start it, while cranking the engine the oil gauge does not move. I don't know if it supposed to when you crank it or not. I thought on other 7.3's I've worked on that the gauge builds up pressure....
View 14 RepliesFord Super Duty (1999-2016) :: Long Crank When Parked Facing Downhill Intermittently?
I am having some intermittent long cranks when parked facing down hill (even very slight downhill). It seems like it only happens cold and is worse when parked for longer. Truck has all updated parts under the hood and is under warranty for another month. I would like to know where to start diagnosing (what would cause this symptom) since I'm sure it won't do it when I take it to the shop right before warranty is up for one last go over.
View 2 Replies