Golf IV / Jetta IV :: 2004 - Front Sway Bar Rubbing On Axle (Not Lowered)
I have a 2004 GLI that I just completed the slave cylinder on, after i got everything back together my driver side axle is now rubbing really bad on the sway bar where it connects to the endlinks. What could be wrong?
View 2 RepliesGolf V R32 :: Noise In Front On Passenger Side - Sway Bar Link?
Chasing a noise in the front, seems to be more on the passenger side, and I think I have it narrowed down to the link ends or subframe. I have ST coil overs, came on the car, and already did the 034 mounts and bearings to solve another noise but this one is different. The links are original and I saw some performance ones that are a bit shorter for a slightly lowered car. Should it have shorter ones due to the coil overs?
View 5 RepliesGolf V R32 :: Rear Sway Installed And Now Knocking Noise Coming From Passenger Side
I installed my sway on saturday and it went smoothly. The bushings were greased up, bolts were torqued to spec, nothing was rubbing or touching in anyway. Now I am getting a knocked noise coming from the rear passenger side. after driving it for a day or so i check under the car to make sure nothing loosened up and everything was just how it was when i installed it. What the issue could be, but the noise is really annoying.
View 4 RepliesGolf VI R :: Sway Bar Rubbing The Axle Under Heavy Compression After Lowering?
I lowered the car on H&R sport Springs with Koni Yellows. On the front right, the sway bar is rubbing the axle under heavy compression (pot hole, sharp dip, bridge joints, etc) and is rubbing the lower control arm (opposite direction) on the driver's side... I got an alignment when I lowered it and it was "within specs"...
I put on adjustable sway bar end links and lengthened the passenger side 1/4" and shortened the drivers side 3/8". left side is slightly better but right side seems almost worse... all rubbing was minimal (barely through the paint on the cast iron parts and nearly no marks on the axle... both strut bearings are new. is it possible that it could be the alignment? Just seems odd to me that the sway bar end links need to be varied lengths to clear....
Golf IV / Jetta IV :: 2003 - Changed Axle Now Side Seems Higher
I changed the driver side axle on my 03 GLI 24v VR6 today and the driver side of the car now seems higher than it was. I was given the wrong axle twice so the car sat on a jack stand for hours could this be why? If so how long will it take to revert? Only things that was undone was the ball joint and tie rod so I'm not too sure why it seems higher.
View 4 RepliesGolf IV / Jetta IV :: Sway Bar Rubbing On Driveshaft
I recently lowered my mk4 golf with coilovers, now the sway bar is rubbing on the right driveshaft axle... could I just get a small diameter driveshaft instead of getting sway bars? My driveshift is about 2 inches wide...
View 24 RepliesGolf IV / Jetta IV :: Only Passenger Side Fan Works
I just recently got a 2001 1.8t jetta. It was leaking coolant and only one fan would come on. Ive fixed the coolant leak. Only the passenger side fan comes on, and the AC blows hot as well. Ive checked the fuses on the battery and they are good.
View 3 RepliesGolf IV / Jetta IV :: Passenger Side Radiator Fan Wobbling?
I could hear a rattling noise under the hood. The passenger side fan would appear to be off balance or the bearing most likely is going out in it. I am having trouble finding a replacement fan for it. Can I replace just that fan, or am I looking at a new cowl complete replacement? What is the part numbers or a link about these fans. It is the passenger side fan that is malfunctioning.
View 5 RepliesGolf IV / Jetta IV :: Smells Like Sulfur From The Passenger Side
After a 70km trip stop in the road and outside the car smell like sulfur and its from the passenger side not in the engine bay not in the exhaust behind not a/c. why is this?
View 2 RepliesGolf IV / Jetta IV :: Rusty Passenger Side Rocker Panel
Recently I made a corrosion claim about some rust forming on my jetta. Long story short VWOA accepted to replace my passenger side fender and trunk, but refused to replace my passenger side rocker panel. Once all the warranty work is taken care of I would like to treat the rocker panel rust the best way possible. I'm not looking to spend hundreds of dollars on this procedure, but I don't want there to be a hole in my car by next winter.
Personally I'm thinking of sanding it all down, treating the rust, applying some paint to it, and then trying to protect the area a little more by investing in OEM side skirts.
Golf IV / Jetta IV :: Passenger Side Motor Mount Spacer
What hardware I need to install the passenger side motor mount spacer from Euro Image Tuning. Been sitting on it for a while and cant find the hardware that it came with. Would like to install it, but dont remember what it came with..
View 2 RepliesGolf IV / Jetta IV :: Loud Whine On Passenger Side Of Engine
I have an 05 jetta 2.0 and I had a loud whine on passenger side of engine. I removed serpentine belt and ran engine briefly and noise was still there. Figured it was water pump or tensioner. and when I was changing timing belt, tension, and water pump I found it was the timing belt itself that was whining. It was OEM original belt with 140,000 miles on it. The belt was in very good shape no tears just used looking. Now engine is very quiet.
View 1 RepliesGolf IV / Jetta IV :: Rattling Noise When Passenger Side Goes Over Bumps
I did my pads and rotors this weekend. On the fronts I had some difficulty with the passengers side retaining clip. It was stuck in on the bottom. I wound up bending it out of place trying to get it off, and eventually just removed the caliper without it.
I took it out for it's first regular drive today and there is a rattling noise when the passenger's side goes over bumps (could be front or back, hard to say). I have theorized that the clip is deformed enough that when it gets jostled, it bumps out onto the rim which makes it go twang (which would be consistent, it's a relatively high pitched rattle. I'm going to look at it tomorrow, but I'm not sure what I should actually do. Can I just clip it off? What purpose does it serve? I might be able to get it out with WD40 and bend it in to shape.
Golf IV / Jetta IV :: Clunk In Passenger Side Front Suspension?
I've got a "clunk" in my front passenger side suspension. I'm running stock struts with H&R sport springs that I put in about 10,000-15,000kms ago. The clunk is inconsistent and seems to only happen in the parking lot when I'm backing out of a stall. When I pull forward, I get a couple clunks coming from that side? Could this be tie-rod?
View 17 RepliesGolf IV / Jetta IV :: 2004 - Coolant Leak On Passenger Side
I've got an '04 1.8t jetta with 158k on the clock. Recently noticed I have a coolant leak on the passenger side of the car. Started the car in my driveway and looked for drips and found coolant collecting in the front valence right underneath the intercooler. Took a look from the top and noticed the hose going into the bottom of the part shown in the picture is leaking like a sieve. It's the metal canister-type thing on the passenger side right next to the radiator. What part this is? And where I can get a new hose that connects to the bottom of it?
View 11 RepliesGolf IV / Jetta IV :: Front Passenger Side Wheel Tilting
So I just jacked up my car to check out how bad the bushings are on the control arms and the tire rod. They're bad. So I'm going to get the suspension stage 1 refresh kit from ECS.
Well I went to spin the passenger side wheel and I noticed that I can tilt it back and forth slightly, I checked the other side and couldn't do the same thing. I just got both wheel bearings replaced by a shop and I'm hoping its not the hub. This is just a CV joint or bushings or if it's actually the hub???
Passat (B5) :: Leakage From Around CV Axle Near Transmission On Passenger Side
I am getting what seems to be a leak from around the cv axle near the transmission on the passenger side. It only does it after driving and stops shortly after the car stops. How do I check the fluid on the automatic transmission.
View 3 RepliesGolf IV / Jetta IV :: Rear Passenger Side Wheel Wasn't Spinning
Upon putting on my winter wheel i was checking if the bolts were too long and my rear passenger side wheel wasn't spinning. I took the wheel off and checked the rotor and it took a lot of force to spin because the caliper didn't go back. I took the brake fluid line out hoping it would decompress the caliper and it did not, and brake fluid leaked out a tiny bit. This leads me to believe that my caliper is bad. Just want to make sure before I order another one
View 4 RepliesGolf IV / Jetta IV :: Knocking Sound In Rear Passenger Side Area
There is a knocking sound in the rear passenger side area. Cannot diagnose the cause, what it could be. I checked the bushings for the anti sway Bar but that was not it.
View 1 Replies