Golf IV / Jetta IV :: Sway Bar Laying On Passenger Side Axle
I recently just lowered my gti and I noticed that the sway bar was laying on my passenger side axle. I put adjustable end links on but that did not got the problem either, this car I daily drive.
View 10 RepliesGolf V R32 :: Driver Side Headlight Points Slightly Higher Than Passenger Side
My Drivers side headlight points slightly higher than my passenger side headlight. Is this normal or do I need to adjust, and if so how do I adjust?
View 6 RepliesGolf IV / Jetta IV :: 2009 Auto Transmission - Should It Be Flushed / Changed
So, I have a 2009 Golf City (Canadian mk4.5) with the 09G 6 speed Tiptronic automatic transmission. It's at 80k kilometers and shifting fine, I can remember maybe one 1-2 slip bump a few weeks ago but that's it. Shifts in Drive, Sport or Tiptronic are smooth and forced downshifts are smooth as well. I do want to follow the US service interval of 40k miles, and of course, my dealership won't do anything with this transmission unless it's broken because "Your fluid lasts the life of the car sir!" That, of course, we all know is BS because every transmission wears, and I don't want millions little metal shards of hardened steel having a party on the inside of my transmission.
This being said, I know that you can do a pan out filter and fluid change, but your only getting about 5L of fluid of the 9L that the 09G has. Or I can pay a local trans shop to do a full flush without dropping the pan by tapping into the in/out fluid ports and flushing everything out. My worry about a flush is that it will take these little anarchist metal shards and put them in a spot where they get stuck and have an all out project X-style party with my solenoids, gears, and torque converter. And the filter still won't have been changed!
Or I do the former where I get the ECS Tuning kit, drop the pan and clean out these little bastards and put in a new filter and not worry about the last 4L of fluid that still might have some of these buggers in it...
Golf IV / Jetta IV :: Changed Battery Now Car Has No Boost And Slams Hard Between Gears
I have a 2004 jetta gls wagon with a 1.8t. the car ran just fine and had a tune running 16psi strong. I changed the battery in it and now the car wont boost, bogs out and SLAMS hard from gear to gear ( auto 5 speed ). I don't have vag com. I just need to get the car to drive with out it. Even if i get back to factory tune im ok with it.
View 8 RepliesGolf IV / Jetta IV :: Overheating Mainly On Freeway While Having Higher RPMs
I have a 2004 Jetta 1.8t. 160k miles. Bought it recently. It's been overheating on me. Mainly on the freeway while having the RPMs higher than the small streets. I don't see any leaks. I'm not losing any coolant. But I do smell burning coolant. I don't see anything smoking though. I changed out the coolant temp sensor. I have a thermostat but haven't gotten to it yet. Just wanted other opinions before moving on. There is some sort of little motor on the radiator with some coolant hose connected to it. When turning off the car, it stays on and buzzes for a good 10-15 minutes before stopping. I'm not sure if that has anything to do with it. I don't even know what that thing is or called.
View 14 RepliesGolf IV / Jetta IV :: Going Higher Profile On 17 Inch Wheel
2003 Jetta. She has worn out front 225/45-17's on right now. From what I can tell, these would still work but I want to make sure on here. Not really worried about a slight speedometer speed change or slightly more sidewall compared to rear, just don't want any rubbing issues.
View 3 RepliesGolf IV / Jetta IV :: 02 - Axle Came Loose From The Tranny
I have an 02 Jetta the the left CV Axle came loose from the tranny/axle flange. I checked the Bentley and it shows that a bolt holds the flange on, I guess a spline. My question when taking one off, is there anything inside that will drop/pop off when I pull it? The reason I need to take it off is that some of the bolts actually broke off, while others screwed their way out. Not sure why they came out or what made the others break but they did. It would be so much easier to get the broken bolts out with the flange out.
View 2 RepliesGolf IV / Jetta IV :: 2000 - Way To Install CV Axle?
I am stuck in the process of replacing a driver side CV axle on a 2000 Jetta VR6 automatic. I followed a Youtube video that may have misguided me. I removed the ball joint connection to take out the axle. (I will need a alignment after all this.) I was able to take out the old cv axle, but unable to put the new one on. While taking out the old one, the strut sank 2 inches. I then disconnected the suspension from the braking system, so it would be lighter and easier to push the strut up. However, it will not budge upwards. Do I need to compress the spring? How to move the strut up?
View 14 RepliesGolf IV / Jetta IV :: Buzzing Noise Gets Louder With Higher Revs
I am experiencing a weird noise coming from my 1.8T AWP engine. Its kind of a buzzing, and it gets louder with higher revs. Unfortunately its hard to hear while driving as I have an exhaust on it, but in a confined space you can hear it clearly.
View 4 RepliesGolf IV / Jetta IV :: Rumbling And Clicking At 30+ MPH - New CV Axle Broken?
I have a 2001 gti that I just changed the cv axle on and it feels like it's failing already but there's no play in the axle or place it mounts to the tranny.. Doesn't feel like the last one I removed but rumbles and clicks at 30+mph.
View 1 RepliesGolf IV / Jetta IV :: Shake In Steering Wheel In Acceleration Mainly But More Often At Higher Speeds
So I just got my first alignment done on my gli since I lowered it. Before I got the alignment it had a shake in the steering wheel in acceleration mainly but more often at higher speeds. I was hoping that it would ride like butter but it's still shaking. The alignment was pretty bad before I took it to the shop today but what could the shake be coming from now? BTW I installed Ecs tuning rear wheel centering plates last night and I'm about to install their adjustable sway bar end links because I noticed last week that the sway bar had been rubbing the axle some.
View 14 RepliesGolf IV / Jetta IV :: 1999 - Higher Frequency / Pitch Noise After Trying To Drift
I let my friend drive my 1999.5 2.0L Jetta (Automatic). He attempted a drift around a cultist, when he started the drift the car made it's usual noise. But after the sharp turn and acceleration, the car made a higher pitch noise. It was definitely noticeable. When driving back home the car performed all the same, accelerated and turned as per usual. But the noise still remains. I don't know what is causing it to make the noise, maybe the Transmission? I'm not too knowledgeable when it comes to cars so that's why I came here.
View 23 RepliesGolf IV / Jetta IV :: Axle Popped Loose, Spilling All The Tranny Oil
So I just had my transmission replaced because my cv axle popped loose and tore a hole right into my old one spilling all the tranny oil all over the road. I was able to find another used one and then bolt it up and now I have a small issue. Its been leaking a little bit of tranny oil through the one piece on the bottom that has two bolts on it and a VW logo on it.
View 5 RepliesGolf IV / Jetta IV :: Axle Makes Humming Noise When Stopping
So I just but my golf about a month ago and have hit many problems but the most annoying is the hum I get at 3500 rpms. In my searching I feel somewhat confident this is caused by a cheap right axle replacement. I also went under and found on the left axle markings that indicate its is oem VW and I was unable to find these on the right side. anyway I have found this: [URL]....
It says it is a hollow axle right there and it is 170 less than the cheapest oem one I have found. would this workout?
Golf IV / Jetta IV :: 2003 VW GTI - Leak On Left Side Of Engine
Recently purchased 2003 golf gti 1.8t that had a leak on left side of engine i think it was engine coolant hose flange it Didn't leak much and coolant stayed at 190. I took the car to a mechanic and he replaced the leaking hose but now the car rises past 190 at idle.
View 2 RepliesGolf IV / Jetta IV :: 2003 - Only Starts When Driver Side Is Closed
So after the long saga of trying to get my 03gti VR6 running, I have come across the STRANGEST behavior I have ever seen in a car. Here's a little background. Two weeks ago driving in a snowstorm my car started sputtering and then died. Left me stranded on the side of the road. Towed it to my buddies house (he's a master tech for Lexus) and tried to figure out what was going on. It wasn't throwing any codes. I replaced the fuel pump relay and that didn't fix anything. Then I noticed the fuel pump wasn't priming when I opened the door. So I replaced the fuel pump. Now it primes when you open the door. Got it started, but it wouldn't stay running for more than 10 seconds, it was acting like it was running out of gas. Even tried disconnectig the battery and touched the pos and neg together. Still to no avail.
After a week of trying to figure it out, I tried starting it with the door closed. Now the damn thing runs. BUT. Here's the strange thing. It will only run if the drivers door is closed. If you open the door, it kills the power to the fuel pump. If you leave the door open, it'll eventually die after roughly 10'secs. If you get out and close the door, it'll stay running. I'm guessing when you close the door it starts sending power to the fuel pump again. Everything else works. Power windows, door locks, mirrors, ect. The local vw shop in town said it might be a bad door switch or the CCM. But the lights come on when you open the door and go off when you shut it. Fuel pump primes when you open the door.
Golf IV / Jetta IV :: Lowering Rear Axle To Install OEM Suitcase Muffler
I am replacing the mid and rear (suitcase) mufflers on my daughter's 2001 2.0L Jetta wagon. She is not interested in anything that would be louder than stock. What I am seeing is that the rear axle needs to be dropped to remove / install the rear muffler. Can this be correct? I know I can continue to cut off parts of the old muffler but that does me no good when it comes to install the new unit.
View 2 RepliesGolf IV / Jetta IV :: 2004 - Front Sway Bar Rubbing On Axle (Not Lowered)
I have a 2004 GLI that I just completed the slave cylinder on, after i got everything back together my driver side axle is now rubbing really bad on the sway bar where it connects to the endlinks. What could be wrong?
View 2 RepliesGolf IV / Jetta IV :: 2003 GLS 1.8T - All Doors Locking Except Driver Side Door
My key when I press the button will lock all of the doors except the drivers door, I can still lock the drivers door, but only if i put my key in the lock and do it manually. I know on my brothers 02 golf gls it would lock all of the doors with the button on the key.
View 1 Replies