Passat (B5) :: Passenger Side Motor Mount Cracked Out
My passenger-side motor mount is cracked out. Is this a common failure? The aluminum part that connects the "frame" to the engine mount is cracked, the hydraulic rubber mount looks almost new, not sure how the previous owner missed the crack in the aluminum. Car has 140K miles on it. I'm thinking about just having it welded up.
View 8 RepliesPassat (B5) :: 1999 - Passenger Side Motor Mount Leaking
The passenger-side motor mount on my '99 1.8t has blown (again). I'm on my second mount already and want to make sure I address all other possible causes before I go through another one. Looking for keeping this new mount intact a bit longer? (BTW the original mount lasted approx. 120k miles and the replacement has "only" lasted 85k miles)...
View 4 RepliesYaris/Scion & Vitz :: Can't Get Front Passenger Side Motor Mount Out
I can't get my front (passenger side) motor mount out because it's under the refrigerant line. How would I do that? There is a black, coiled "jacket" that goes around the line right before it enters the back of the radiator, can I detach it there? The line snakes all over the engine compartment and appears to be bolted onto the radiator on one end and the other end goes through a clamp and into the dash area. [URL]....................
View 5 RepliesGolf IV / Jetta IV :: Broken Bolt From Motor Mount Bracket
The other day when i wanted to start the car, I found out my battery was death so i decided to ask my buddy to push me and crank it on gear. Car shakes as normal and engine started, but then i heard a weird noise like if something was rubbing. I turned it off and popped the hood. I found my engine leaning forward and toward the passenger side.
So the next morning, I checked the bay again and i found out that it wasn't the motor mount. Motor mount is ok, but then i found a broken bolt that holds the bracket to the block; the one that goes right next to the water pump to be more specific. Also in the back of the block there is a bolt that hold bracket to the block again and the thread whole was enough weak to break when the other bolt failed. So I did some research and i found that there is a solution for the bolt in back of the block.
What I am concerned is for the on the goes right next to the water pump. It seems that it broke the whole thing including the part where the bolt threads go. I just had a shop install I.E connecting rods, new piston rings, and rebuilt the heads. They put a new timing belt kit and all its job required. I think they might have a bit of fault on this since it had to be removed when they did the timing belt kit. Anyways I don't want to think my block will be a junk now because engine is running like a champ, and that would be a bummer.
-Bolt that is broken in two pieces.-
-And where it is attached to the block-
-Part of the engine where this all goes.-
Golf IV R32 :: Popping And Clunking Noise From Passenger Side Spring / Mount Area
I had the struts replaced a few months ago along with the strut mounts and bearings. Since then I've developed a popping and clunking noise from the passenger side spring/mount area. I've greased it and it has quieted it down but I noticed that when the car is not moving and I turn the wheel from lock to lock that very top piece of the strut pretty sure it's called the hat moves along with the wheels while the drivers side does not. What's wrong? Is it something as simple as the nut being to lose or to tight?
View 3 RepliesGTI 337/20th Anniversary :: Huge Clunk Sound Seems Like Coming From Under Driver Side Motor Mount
I was sitting at the stoplight in neutral when the light turned green. I pushed in the clutch and put the car in first then all of a sudden a huge CLUNK like when you take out the starter bolt without supporting the trans or motor. Then while letting out the clutch about halfway all hell broke loose. It sounded like a bunch of marbles rattling like crazy in the trans. I pushed the clutch back in then it stops until you let it back out again. The car still moves forward and reverse but with all that noise. The sound seems like it's coming from under the driver side motor mount. When I put my hand on the tranny I can feel the vibrations very well. Does this sound like the throw out bearing?
View 3 RepliesFord :: 2006 - Motor Mount And Front Stabilizer / Rattling Noise From Driver Side Engine Compartment
My 2006 AWD LTD 500 has about 52000 miles on it; a slight rattle/clunking noise is intermittently heard on driver's side in engine compartment. Took it in to dealer who says motor mount is cracked and front stabilizer bar joints are worn and both need replacing. Car has only been driven on highways or for short trips (3-4 miles) and has had no impacts nor been driven over rough roads or run over any potholes or such. Should the motor mount be damaged? At 52K miles?? Never heard of such a thing. Ditto, the stabilizer bar joints: worn out in under 60K miles? What can I do about this? Who seek relief from? Ford warranty is, of course, over, and supplemental warrenty will only cover motor mount replacement but not stab bar. Are these parts routinely wearing out at such an early date that repair shops can reap the rewards???
View 4 RepliesGolf IV / Jetta IV :: Ticking Sound Coming From Belt Side Of Motor?
Recently my GTI has been ticking, but it is only between 1 and 2 thousand rpm. After 2k it runs fine and doesn't make the sound. Local tuner suggested an oil pressure problem (not using the proper oil) but I am using the proper oil. It has been like this for over a month now and nothing has come of it. It is coming from the belt side of the motor and sounds like plastic ticking. Could it be a belt?
View 7 RepliesPassat (B5) :: How To Get Passenger Side Engine Mount Bolt To Stop Spinning
So I just replaced my oil pump and i am reassembling my front end and I just cant get my passenger side engine mount bolt to stop spinning so i can get the nut on (the mount underneath the car) , I have no clue how to stop the spinning
View 1 RepliesGolf IV / Jetta IV :: Only Passenger Side Fan Works
I just recently got a 2001 1.8t jetta. It was leaking coolant and only one fan would come on. Ive fixed the coolant leak. Only the passenger side fan comes on, and the AC blows hot as well. Ive checked the fuses on the battery and they are good.
View 3 RepliesGolf IV / Jetta IV :: Passenger Side Radiator Fan Wobbling?
I could hear a rattling noise under the hood. The passenger side fan would appear to be off balance or the bearing most likely is going out in it. I am having trouble finding a replacement fan for it. Can I replace just that fan, or am I looking at a new cowl complete replacement? What is the part numbers or a link about these fans. It is the passenger side fan that is malfunctioning.
View 5 RepliesGolf IV / Jetta IV :: Smells Like Sulfur From The Passenger Side
After a 70km trip stop in the road and outside the car smell like sulfur and its from the passenger side not in the engine bay not in the exhaust behind not a/c. why is this?
View 2 RepliesGolf IV / Jetta IV :: Rusty Passenger Side Rocker Panel
Recently I made a corrosion claim about some rust forming on my jetta. Long story short VWOA accepted to replace my passenger side fender and trunk, but refused to replace my passenger side rocker panel. Once all the warranty work is taken care of I would like to treat the rocker panel rust the best way possible. I'm not looking to spend hundreds of dollars on this procedure, but I don't want there to be a hole in my car by next winter.
Personally I'm thinking of sanding it all down, treating the rust, applying some paint to it, and then trying to protect the area a little more by investing in OEM side skirts.
Golf IV / Jetta IV :: Loud Whine On Passenger Side Of Engine
I have an 05 jetta 2.0 and I had a loud whine on passenger side of engine. I removed serpentine belt and ran engine briefly and noise was still there. Figured it was water pump or tensioner. and when I was changing timing belt, tension, and water pump I found it was the timing belt itself that was whining. It was OEM original belt with 140,000 miles on it. The belt was in very good shape no tears just used looking. Now engine is very quiet.
View 1 RepliesGolf IV / Jetta IV :: Sway Bar Laying On Passenger Side Axle
I recently just lowered my gti and I noticed that the sway bar was laying on my passenger side axle. I put adjustable end links on but that did not got the problem either, this car I daily drive.
View 10 RepliesGolf IV / Jetta IV :: Rattling Noise When Passenger Side Goes Over Bumps
I did my pads and rotors this weekend. On the fronts I had some difficulty with the passengers side retaining clip. It was stuck in on the bottom. I wound up bending it out of place trying to get it off, and eventually just removed the caliper without it.
I took it out for it's first regular drive today and there is a rattling noise when the passenger's side goes over bumps (could be front or back, hard to say). I have theorized that the clip is deformed enough that when it gets jostled, it bumps out onto the rim which makes it go twang (which would be consistent, it's a relatively high pitched rattle. I'm going to look at it tomorrow, but I'm not sure what I should actually do. Can I just clip it off? What purpose does it serve? I might be able to get it out with WD40 and bend it in to shape.
Golf IV / Jetta IV :: Clunk In Passenger Side Front Suspension?
I've got a "clunk" in my front passenger side suspension. I'm running stock struts with H&R sport springs that I put in about 10,000-15,000kms ago. The clunk is inconsistent and seems to only happen in the parking lot when I'm backing out of a stall. When I pull forward, I get a couple clunks coming from that side? Could this be tie-rod?
View 17 RepliesGolf IV / Jetta IV :: 2004 - Coolant Leak On Passenger Side
I've got an '04 1.8t jetta with 158k on the clock. Recently noticed I have a coolant leak on the passenger side of the car. Started the car in my driveway and looked for drips and found coolant collecting in the front valence right underneath the intercooler. Took a look from the top and noticed the hose going into the bottom of the part shown in the picture is leaking like a sieve. It's the metal canister-type thing on the passenger side right next to the radiator. What part this is? And where I can get a new hose that connects to the bottom of it?
View 11 RepliesGolf IV / Jetta IV :: Front Passenger Side Wheel Tilting
So I just jacked up my car to check out how bad the bushings are on the control arms and the tire rod. They're bad. So I'm going to get the suspension stage 1 refresh kit from ECS.
Well I went to spin the passenger side wheel and I noticed that I can tilt it back and forth slightly, I checked the other side and couldn't do the same thing. I just got both wheel bearings replaced by a shop and I'm hoping its not the hub. This is just a CV joint or bushings or if it's actually the hub???