Golf IV R32 :: Cranks Fine But Won't Start, Fuel Pump Doesn't Shut Off
The car cranks absolutely 100%, in no way is this the battery, it just will not start. Then I noticed the fuel pump wasn't shutting off, I only had a quarter tank in the car, I figured as hot as it was today I was getting some vapor lock with the fuel. Went and got some gas, still wouldn't start, then the dash started yelling at me telling me I have no oil pressure, shut off the car.........car you are not running calm down. So then there's that along with the car not starting. I took the fuel hose off to make sure I was getting fuel, I was, so I took the key back out, but the car would not give up, the fuel pump kept going and the dash was blinking violently. When I put the hose back on and got compression it finally stopped, that can't be how the cars work can it? The fuel pump doesn't shut off if there's no compression? Checked all fuses and the fuel pump relay, every was fine, the fuel pump even still ran with the relay out. What could be going on, I can't seem to find one damn thing even related to the fuel pump not shutting off.
View 24 RepliesGolf IV / Jetta IV :: 2005 - Cold Start - Chokes / Sputters Like It Isn't Getting Enough Gas
So my new problem is cold engine starts If it's mildly cold out like 30-40 F or 0-10C and has been sitting awhile the car won't start on the first couple of tries. It tries to start but I guess chokes/sputters out like its not getting enough gas. Warm engine it starts instantly.
I put a bottle of gumout regane fuel system cleaner in the tank hoping its a dirty fuel system seeing it feels like it chokes out on gas during the cold start. I'm about half way done that tank and was going to add another bottle on the next tank.
I'm worried about the cold winter approaching and found out issue 8001 today that the oil pan heater is ripped off with broken wires and missing cover.
Golf/GTI VI :: 2012 - Cranks Up And Then Sputters Out - Keep Getting Waning Messages
Well, after owning 4 other VW's, this one has left me "stranded". I bought my 2012 Autobahn GTI back in September and it had been absolutely problem free up until now. I have the APR flash and Carbonio intake as my only modifications for reference.
I drove over to my girlfriend's house yesterday around 5:30pm, had no issues or anything up until this point. I get into my car around 10:30pm, ready to go home and push the starter. The car cranks up, then sputters out. This has actually happened once or twice before when I pushed the starter too quickly, so I chalked it up to that. I push the starter again, I get a click, and then nothing. A ton of warning lights come on, I get a couple warning messages come up, one about an error with the ESC, and one about the adaptive lighting system. The car's fan turns on, as if the car was running.
I try to start the car a few more times without any luck, and keep getting the same warning messages. I then got out of the car, locked the doors and let the car go to sleep. I wait 15 minutes and try starting the car again, still can't start. At this point I'm pretty much ready to throw in the towel, but I decided to disconnect the battery for a few minutes, hoping that when I reconnect I'll be able to start it. It still didn't work. At this point I know I'm going to have to take it to the dealer, so I try to put the car back into stock mode. I couldn't even do that.
I ended up having to call roadside assistance. To add to my frustration, I requested a flat bed and instead a front-wheel lift one came. I had my car towed to the dealer, had my gf follow the tow truck to the dealer and filled out the night drop off form and left my key.
This morning I call the service department, trying to inquire about my car and the service adviser tells me "your car has severe electrical issues and we are not going to be able to diagnose them today." He asked me if I had any performance software on the car, and I tell him that this is my 5th VW that I've owned, and that every one has had the same APR software on it. I had my car flashed back in September or October, and that I've never had an issue with it with any car. The service adviser then tells me that this is going to have to go to his manager to write off on it if they determine this is caused by my flash or not.
Now I'm stuck without a car, at least through Monday. I asked for a service loaner and they told me they had none and that since they are closed on Sunday, the soonest I might be able to get one is Monday. I just started a new job and have no vacation time saved up, so the timing of this is certainly not ideal. I know that I assumed responsibility by getting the flash, but I've got my fingers and toes crossed that they don't point the blame on the flash and make me pay out of pocket for this.
Golf IV / Jetta IV :: 2002 - Car Will Crank Fine But Never Start
2002 Jetta GLS 1.8T (engine stock except diverter valve) 171k miles
It's done this a couple times now. Both while raining out/high humidity. Prior to this, I could hear the pump "growling". Sounded like maybe starting to go. You could hear it prime when opening the door or turning the key forward but would stay sounding like that even when the car was started. Without the radio, you can hear the pump running.
1st time- The car will crank without issue but never start. I let it sit a few minutes, turned key, heard it prime,tried again, started right up like there wasn't an issue and I couldn't hear the pump this time while the car was running.
2nd time-The car will crank without issue but never start. I let it sit for an hour, opened door (couldn't hear prime), checked fuse 28 (good). Figured wth, let's try anyways. Turned key, couldn't hear prime, started right up. WTF. cold idle normal (1000-1200rpm), light revs to 3000 ish normal. Turned off car, let sit for a minute. Turned key, heard prime, car started without issue and I couldn't hear the pump again while the car was running.
My dad is thinking to replace the pump right away. Is there anything else to try? The relay is working... at least sorta. With the somewhat intermittent issue, where to start? Either way, relay or pump, I will be replacing fuel filter.
Golf IV / Jetta IV :: 01 - Car Only Cranks, Won't Start
About a month ago I went to start my car and it started up and died and now it won't start at all. All it does is crank and crank and crank. My vagcom say j271 relay open circuit . so I replaced the 428 relay and it still doesn't start. I'm also not getting any epc or cel light with the key in the on position which is strange to me. But if I swap the 428 relay with the 100 relay right next to it I get all the dash lights like I'm suppose to but as soon as I try to start it the two lights go out and won't come back on until I pull the relay out and put it back in. I hate obd2 so much sometimes.
View 2 RepliesGolf IV / Jetta IV :: MK4 Cranked Fine But Would Not Start - VCDS Code
I just bought a 2002 Jetta 2.0L with automatic trans and about 98000 miles on the odometer.It drove fine on a short test drive. It drove fine on a 45 min drive home after which I parked it for a short while (about an 60-90 mins.) Then I tried to restart it . It cranked fine but would not start. After 3 or 4 attempts I let it rest for a min and then it started. And the CEL came on.
This was a few days ago. Today I finally got a chance to scan it with these results:
VCDS Version: Release 15.7.3 Running on Windows 7 x86
[URL] .....
Address 01: Engine Labels: 06A-906-032-AVH.lbl
Control Module Part Number: 06A 906 032 FR
Component and/or Version: 2.0l R4/2V G 4070
Software Coding: 00003
[Code] ....
I'm new to MK4's and I'm at a bit of a loss as to where to start. It looks to me like there's a problem with both the fuel pump relay and the crank sensor. But what to make of all the short to ground codes. Could they be caused by a bad fuel pump relay?
Golf IV / Jetta IV :: 2.0L Cranks But Doesn't Start
I've got a Mk4 Golf 2.0L with 136k on the clock. Hasn't really given me any problems in the past year of ownership till now. I recently picked her up from the shop for a rear axle beam replacement. When I picked her up she drove fine. I headed to class for the day and she sat in a parking lot for 6 hours or so. I hop in and try to fire her up and nothing. Had to have her towed back to my apartments. I've checked fuses, spark plugs were recently replaced but I am getting no spark. When I crank it I do hear the fuel pump and I can smell gas when I crank it. The rpms go up just a bit, 100-200 range. Going to check out the crankshaft sensor later on. maybe it could be the coil pack as well? I don't know a huge amount about these cars, only some info. And I sadly have no access to a scanner to check for codes.
View 2 RepliesGolf IV / Jetta IV :: Engine Cranks Over But Does Not Start
So I bought a project golf vr6, but the head and some of the components were off, I have all the parts but I just cannot figure out why it is not wanting to start, it cranks over but does not start...
View 1 RepliesGolf IV / Jetta IV :: 2003 - Cranks But Won't Start
I am having a problem starting my VW Golf 2.0 since yesterday. When i turn on the ignition the car cranks up but does not start. I did a computer odb check and it gave me out some error codes.
here are a few things that i noticed sometime back:
While driving once or twice suddenly the car wasn't accelerating when i pressed the accelerator. This happened to me twice but then it was OK. Didn't have an issue again.
Sometimes the car gear doesn't shift gear i have to shutdown the car and start it again, then it shifts gear properly. I feel like the car is consuming a bit extra fuel. How I can fix this and what the issue is?
Passat (B5) :: Car Cranks Fine But Won't Start
First time ever, my Passat has stranded me. Won't start. 120K. Cranks fine. Fuel pump fuse is OK. Almost new plugs. New fuel filter. No codes. Almost a full tank of gas. No smell of fuel in engine compartment. Disconnect MAF, no difference. This started over a week ago. The car would not start on the first try. Always on the second try. Once started the car ran fine, did not stall or hesitate. Then, just once, it almost did not start; I think it was the fourth try it finally started. After that I replaced the fuel filter, just in case. It's been fine for several days. Now this morning, no go
View 6 RepliesFord Excursion :: Cranks Fine But Does Not Start
Had the Excursion out today. Made a stop coming back and used the remote start. I entered the truck and by mistake pressed the brake pedal which shuts off the engine. When I tried to start the truck with the key...it cranks fine but does not start. It'll try to run, sputter...but will not run.
I cannot hear the pump running when the key is turned. It was towed home and it in the driveway. I assume it's the fuel pump....but wondered if the remote start/alarm could be killing the power to the pump? The cut-off switch in the passenger footwell is pressed in. Where do I start:?
Golf IV / Jetta IV :: On Every 4th Or 5th Start It Cranks And Then Finally Starts / Sometimes Stalls
Recently my 01 Jetta 1.8T has started to not start like it should. Say every 4th or 5th start it cranks and cranks, I see the tach eventually flick a couple of times and then it finally fires up. It's also stalled while I'm driving, say when I stop at a light but will usually start up again ok.
After the not so good start I get the impression the car is kind of surging while driving - like a fuel supply issue although maybe the fuel pump has nothing to do with supply after starting?
So anyway my thought is perhaps fuel pump issue? I decided to try and search for my issue or fuel pump issues but it talks about things that happen when you open the drivers door which in my case isn't working properly (i.e., I believe it is a DLM as my windows sometimes all go down and I don't get any chime or door light when the door opens).
So just wondering if based on what I'm experiencing if fuel pump sounds likely and perhaps what further tests I should run. My battery is new and the engine does crank pretty good if that eliminate it. I guess I should be thinking fuel filter perhaps also.
Passat (B5) :: 2005 V6 Won't Start - Have Spark And Cranks Over Fine
I got a 05 Passat I am working on. The car was being drove and my customer when to eat lunch. Came out side and didn't start. Got it to my house threw it on the scanner and it brought up 2 cam sensor codes. Replaced them and still nothing. What to try next. The car cranks over fine and it does have fuel pressure and also has spark.
View 2 RepliesChevrolet - Tahoe :: 2002 Cranks Over Fine But Won't Start
My 2002 Tahoe cranks over fine (new battery), but, will not start. I have checked the fuel pump relay and have control power to energize the relay, but. no switched power from ECM to change relay state. Jumped rely 30/87 and pump runs. No DTC's. Gauge on instrument panel reads no fuel. Scanner shows 56% level. Tried to use my Snapon MT2500 to switch relay state and received error message "generic device control limit exceeded" ECM?
View 3 RepliesSonata NF (2006-10) :: Cranks Fine When Turned The Key But Won't Start
My 2008 Sonata finally let me down after 4-1/2 years of flawless service. Turned the key, it cranks fine, but won't start. I think it's the fuel pump. It has 63,000 miles now so the bumper-to-bimper warranty is over. Is the fuel pump (if that's it) covered by the 100,000 mile drive train warranty? I checked fuses and they are all fine. I don't know if there is a fuel cutoff switch. It might just be the pump relay...but I want to have it towed, and the choice is dealer or my regular mechanic.
View 7 RepliesPickup - Chevrolet :: 1993 - Cranks Fine But Won't Start?
A friend is stumped by a problem with his truck, so I thought I might get some insight here. I haven't actually seen the truck, all that follows is from what he described, I'm just the messenger here.
The truck had been running fine on a used engine installed about six months ago. Then he ran it out of gas, it hasn't run properly since. It cranks fine, but won't start. He says it WILL start when spraying starter fluid into the throttle body, but only while the starting fluid is supplied. He also says he disconnected the fuel line somewhere near the engine, cranked the engine, and got good fuel supply (but no fuel pressure gauge reading). He's done some logical things: new fuel pump, fuel filter, spark plugs and wires. No luck. Figuring that he'd sucked something ugly into the injectors, he decided to replace those with no change (yes, I cautioned him about throwing expensive parts at it with no clear reason).
He reasons that he must be getting spark based on the engine running with starter fluid, and there must be fuel based on his test with the open fuel line, so he thinks it's an electronic problem, presumably the signal to the injectors. This is out of my league...and my friend is a carpenter, not a mechanic. If he could get a scanner would this kind of problem register a code?
Ford Excursion :: 2004 6.0 Cranks Fine But Will Not Start
My 2004 6.0 will not start. It cranks fine. History This happened once before about a year ago towed it into the shop and it stated fine.
The batteries were low yesterday and the truck would not start because the voltage was too low to run the starter. I charged them. Went to try again and I cranked it for close to 30 seconds with no results.
Only cods so far are #6 glow plug and EGR valve open. Whats next, check the FICA?
Ford F-150 (2004-2008) :: Occasional Hard Start / Engine Cranks Strong But Fails To Catch And Then Sputters
My truck's been having an occasional hard start, meaning the engine cranks strong but it fails to catch and then sputters. The 2nd start attempt usually fires up with no issues and then runs perfectly otherwise.
MPG's haven't changed, fuel filter was changed 15K ago. Air filter is clean. Plugs were changed about 10K ago. I always use Shell/Chevron gas. MAF sensor looked clean when I took it out so I didn't do anything to it.
This is starting to happen more frequently, maybe once every few weeks and I get a feeling it's the start of something. I've found myself waiting a few seconds for the fuel pressure gauge to come up before turning the key to start reliably. In the past, I could simply flick the key and it fires up the first time.
I see posts talking about the fuel pump module above the spare tire. What are symptoms of that going bad? Any pending codes that might be stored?
I'm about to get myself a scanner since I need one sooner or later. Which specific PID's to check while debugging this?
Ford 7.3L Power Stroke (1999-2003) :: 2001 F350 Hard To Start / Cranks For A While / Sputters And Dies
2001 F350 7.3 ... Below 35 degrees, truck is hard to start. Cranks for a while, sputters, dies. Repeat a couple times, finally starts running rough, surging and loping for 10-15 seconds before it settles down and runs smoothly. Recently had all glow plugs replaced. Next cold start didn't show much improvement (not as bad as sometimes, but wasn't very cold either).
Surfing here and other forums, I see suggestions about letting glow plugs heat longer after WTS light goes out. Some suggest as long as 60 seconds. In the past, I have tried waiting a little while longer after light goes out, or turning key off/on and letting it cycle again. But I've never really timed how long I was waiting.
We're having a warm spell right now, so I can't do much testing. But yesterday morning was about 30. I timed the WTS light and it went out after 10 seconds. I waited another 20 seconds.. about 30 seconds total. Starting seemed a little better than usual, and there was about 1 second of roughness before it settled down.
I need to do more cold weather testing to be sure, but it does seem like it might be better to wait longer than I have been.
On the other end of the scale, I saw a comment that glow plug cycle is dependent on oil temp, and they don't come on at all if oil temp is above 40. Is this correct? If so, is there any good reason to wait to start in warm weather? I'm usually pretty diligent about waiting for the light regardless of weather, but the truck doesn't seem to object if I get impatient and start it sooner in warm weather. If the glow plugs aren't even on, why wait?
Should I just totally ignore the light, and wait for some interval (or not at all) based on a semi-educated guess about how much glow plug time might be necessary for the current temp?