Ford Super Duty (1999-2016) :: 2001 F450 V10 - Hydro Clutch Petal Fails To Return
My 01 450 V-10 dump truck had intermittent clutch petal problem. Petal would not return all the way. Had to pull it up then it worked ok for a while. Now it only works occasionally. Could it be the disk is collapsing or the master or slave? Any good how to video for replacement?
View 4 RepliesGolf IV / Jetta IV :: 2003 - Clutch Pedal Sticks To The Floor
2003 Jetta, 1.8T, 5spd, stock, 129k miles. I am working on a friends car and his complaint is the clutch pedal occasionally sticks to the floor and during this sequence it is hard to shift gears. I removed knee bolsters to inspect under the dash and found all linkage straight, all plastic parts/springs in place and no fluid leaks, I removed slave cylinder from bell housing and found smooth operation and no leaks. I guess I could replace both but I am wondering if there is a common issue. My searches have found broken plastic parts, bent push rods and leaking cylinders.
View 4 RepliesGolf IV / Jetta IV :: Clutch Pedal Stuck To Floor With Fluid Underneath Car
I have a 2003 Jetta GLI. Thus morning driving into work my clutch pedal stuck to the floor. I was able to pull it back it and make it to work, but when i got to work i noticed fluid dripping from underneath my car.
View 4 RepliesGolf IV / Jetta IV :: 2003 - Clutch Pedal Went Straight To The Floor With No Resistance?
So last evening, I went to start my car and the clutch pedal went straight to the floor with no resistance. Car started and was extremely hard to get into every gear. Felt like the only thing pushing the clutch pedal back up was the spring underneath the pedal itself. Clutch pedal was 100% just the day before. Got the clutch line bled (vacuum bleeder) and it worked fine again.
Any clue as to what could caused this overnight?
Its a AWP 1.8t jetta with ASR.. I believe I came across something about a revision in the hydraulic line but I'm not sure.
Golf IV / Jetta IV :: 1998 - Clutch Engages Lower To The Floor / Shifter Stuck In Gear
98 Jetta TDI hydraulic system ... We just received this vehicle from my mother in law, who is not driving any more. It's a cream puff--79,000 miles, beautiful condition. Problem is the clutch engages lower and lower to the floor, and eventually the shifter gets stuck in gear. The brake pedal slowly sinks to the floor when at stops on hills. Our mechanic tells us these two are connected because both the clutch and brake run off the same hydraulic system.
1st time he said the fluid was filthy, and he emptied the system and put in clean fluid. Worked for a little while and then we were back where we started. Second time he replaced a couple parts on the clutch, replaced this fluid, and this time it ran like a dream for a little over a month. Then the problem just returned. Again he says the fluid is filthy, and now we are looking at replacing the master cylinder and again changing the fluid. The theory behind why this is happening is that my mother in law let the car sit for half a year before passing it on to us. She didn't do much driving the 6 months before that either. I've done research, and this doesn't appear to be a common problem by any means on these cars.
Golf IV / Jetta IV :: Stalls Out In Stop And Go Traffic / Bang And Clutch Pedal Drops To The Floor
I have a 2005 VW jetta 2.0 engine 5 speed. Just replaced right control arm spark plugs wires and coil pack. I had a misfire only when it rained and it got rid of it! Driving home in stop and go traffic and My car stalls out a hear a bang and my clutch pedal drops to the floor. I had noticed some fluid loss but nothing was low I checked everything before I left work. I finally get it towed but I can not shift to first I can shift to 2 3 4 5 and reverse. I was in first when it stalled out during stop and go traffic while it was in first gear and i had the clutch pressed in. Everything Ive google says it is more than likely the Slave cylinder that is right below the air box. I found some that said it could be the release bearing in the gearbox for the tranny...
View 4 RepliesGolf IV / Jetta IV :: 2001 - Clutch Is Slipping
My 2001 Golf seems like the clutch is slipping. It bangs into gear at low revs so bad you think you've hit a large pothole. I'm hoping it's not the whole transmission that needs replacing, because we only have 135000 on the clock.
View 2 RepliesGolf IV / Jetta IV :: 2001 Gti VR6 Stuck In Reverse / Clutch Won't Fully Disengage
My 01 GTi (12v VR6) was having some trouble shifting into, and out of, first and reverse so after a bit of research I decided to try adjusting the shift linkage as it seemed like a possible easy fix. After doing that I tried backing it up in the driveway and after a couple of shifts to different gears it ended up getting stuck in reverse. When I pushed in the clutch pedal to let it roll forward I noted that it seemed to be resisting rolling forward despite the steep incline. Once it reached a less steep incline it stopped rolling forward completely, so I'm thinking that it probably won't come out of gear because the clutch won't disengage all the way.
I've done some searching around and from what I've read so far it sounds like it could be a worn or damaged clutch fork, the hydraulic lines, master or slave cylinder, or even a broken clutch plate. What I don't want to do is pull the transmission and clutch, only to find that it was something much easier to fix.
Golf IV / Jetta IV :: 2001 VR6 - Loud Ticking Noise When Clutch Is Not Depressed On Idle
I've searched but can't find what my problem is , ON idle when clutch is not depressed loud ticking noise , but when I push the clutch in it goes away . Also the ticking noise will get louder if I accelerate . ONLY Im first gear will I hear a loud grinding noise which means I have to quickly switch into second . Sound similar to something being dragged along a fence . Again the grinding sound I'm first will only happen if I'm giving it gas. Car has 325,000 km . Something with the transmission ?
View 1 RepliesGolf IV R32 :: Clutch Pedal Went To The Floor When Get It Into Gear
So my clutch has been acting up lately. When it sits for a few hours the clutch engagement point seemed to creep down but over the course of 35 minutes of driving would work its way back up again. Today it was unusually low and wouldn't let me get it into gear. I tried pumping it a few times and realized it wasn't coming back up all the way, I pulled it up and then tried again and it just dropped right to the floor where it now sits. Fortunately I was at work and can hang here until my ride arrives, and will just wait until late tomorrow night to drive it to my shop without stopping...
My guess is I need a new clutch master cylinder. I have plenty of fluid in there although its a bit old so I'll be changing that when I change the cylinder. Could it be the slave cylinder? If so is it a bear to change that? (do I need to drop the trans?)
Brakes - Chevrolet - Blazer - Clutches :: 2001 - Push Clutch Hard Almost Through The Floor To Start The Car
I recently purchased a used 2001 Chevy Blazer with a manual transmission. In order to start it, I have to push very hard on the clutch, almost through the floor. Is there some type of adjustment to make starting a little easier? Also, when I push on the parking brake, it also goes right to the floor and seems like it barely engages.
View 1 RepliesGolf VI R :: Clutch Pedal Stuck To The Floor On Several Occasions
So over the weekend my clutch pedal stuck to the floor 2 times and would not come all the way up on several occasions. It has since then stopped doing it. I am wondering if I should bleed my clutch or not. Flush and change fluid?
Just concerned it may turn worse.
Golf VI R :: Clutch Went To The Floor - Leak At Bell Housing?
Came out of a turn, went to grab third, clutch went to the floor and didn't come back. Stopped, pumped pedal for a bit, managed to get into first and milked it home. There's nothing leaking, but fluid level was low. I topped fluid, pumped pedal and bled the block at the tranny, pressure came up and I was able to engage gears. Pulled into garage and same issue, no pressure and clutch won't disengage. Pedal is soft. I'm thinking I managed to get some air in the system. Question is if the slave failed, wouldn't I have a leak at the bell housing?
Do I have to drop the tranny to bleed the slave? Also, my stock clutch on APR stage 1 was doing ok before this issue. There was chatter and/or other noises in the clutch at take off but no real issue with slipping. I'm thinking I'll go ahead and replace the clutch. I'll be dropping the trans on a rack in my friends shop.
Golf IV / Jetta IV :: CEL Flashing When Floor 2004 1.8T GLI
For a while i've been dealing with this problem but its low priority because I never floor my car. The car drives perfectly fine even if you hold it 5-10 lbs of boost. When it goes into 18-20lbs it wont hold.
Symptoms : Only when I floor it SOMETIMES the car bogs down and the check engine light flashes for a little and eventually goes away. Now this doesn't always happen. Sometimes I floor it and everything works fine. I don't have vag or a laptop to hook it up and see what code is thrown.
The car is a 2004 1.8t GLI
Golf IV / Jetta IV :: 2003 GL With Wet Floor Board After Raining
Returning to the VW fold. Just purchased a 03 Jetta GL (NO SUNROOF) and after the first rain, the passengers floor board is wet. I have searched the forums and have read many threads about the sunroof drain. Where else could this be coming from? I had a BMW that would do this because the vapor barrier in the door came loose. Is this the same situation? I looked at the panel at the bottom of the windshield and it looks tight against the glass and do not see anything stuck in between the panel and the glass.
View 5 RepliesGolf IV / Jetta IV :: Driver Side Floor Soaked
I left my the car sitting for a week out in heavy rain and came back to find that the driver side floor was soaked. After searching around I seem to have found the entry point. It seems like all of the water is pouring in from my hood release lever area which I find strange. I put a towel down last night during two hours of rain and came back to find the towel almost fully soaked through. I read other threads on this but the results were inconclusive. Could it be the lower or upper windshield seals? Door seals? Another problem I'm having is water leaking from my dome light buttons after a heavy rain. I assume this is a problem with the sunroof seal, but whenever I search around it feels dry?
View 8 RepliesGolf IV / Jetta IV :: Spotted Wet Garage Floor / Coolant Leaked
I have a 24v Vr6, a couple days ago i spotted some water on my garage floor. I looked in the engine bay and I saw some coolant on this metal can looking piece, it's on the passenger side of the car to the left of the headlight door and a couple inches down. I also looked all the way at the bottom of the engine bay on on the plastic shield there is quite a bit of coolant that has leaked onto there.
View 2 RepliesGolf IV / Jetta IV :: Oil Coming From Exhaust And Leaves Little Splotches On Floor
I've noticed that when I start my car and its cold oil comes out from the exhaust and leaves little splotches on the floor I was wondering if this is normal or if I should be worried; I have an mk4 jetta with the 1.8t engine and a 3 inch turbo back exhaust if that matters?
View 3 RepliesGolf IV / Jetta IV :: 2003 - Floor Of The Trunk Compartment Is Plastic?
So when i open my trunk and look into the left, after i open that side hatch inside, the floor of the compartment is plastic. And then you can take the floor off.What is this for? It seems too small for a battery!
[URL]