Golf IV / Jetta IV :: 2003 - Coolant Leak Quickly From Passenger Side Of Engine Compartment
My 2003 GTI 24V VR6 is leaking coolant pretty quickly from the passenger side of the engine compartment. I have a new water pump in hand. If I'm replacing the water pump, would it be smart to go ahead and order a thermostat and metal crack-pipe to replace at the same time that I'm having the water pump installed? I'd hate to get the water pump installed, and find out that the leak is at the crack pipe.
View 3 RepliesGolf IV / Jetta IV :: 2003 GL With Wet Floor Board After Raining
Returning to the VW fold. Just purchased a 03 Jetta GL (NO SUNROOF) and after the first rain, the passengers floor board is wet. I have searched the forums and have read many threads about the sunroof drain. Where else could this be coming from? I had a BMW that would do this because the vapor barrier in the door came loose. Is this the same situation? I looked at the panel at the bottom of the windshield and it looks tight against the glass and do not see anything stuck in between the panel and the glass.
View 5 RepliesGolf IV / Jetta IV :: 2003 - Clutch Pedal Sticks To The Floor
2003 Jetta, 1.8T, 5spd, stock, 129k miles. I am working on a friends car and his complaint is the clutch pedal occasionally sticks to the floor and during this sequence it is hard to shift gears. I removed knee bolsters to inspect under the dash and found all linkage straight, all plastic parts/springs in place and no fluid leaks, I removed slave cylinder from bell housing and found smooth operation and no leaks. I guess I could replace both but I am wondering if there is a common issue. My searches have found broken plastic parts, bent push rods and leaking cylinders.
View 4 RepliesGolf IV / Jetta IV :: 2003 - Clutch Pedal Went Straight To The Floor With No Resistance?
So last evening, I went to start my car and the clutch pedal went straight to the floor with no resistance. Car started and was extremely hard to get into every gear. Felt like the only thing pushing the clutch pedal back up was the spring underneath the pedal itself. Clutch pedal was 100% just the day before. Got the clutch line bled (vacuum bleeder) and it worked fine again.
Any clue as to what could caused this overnight?
Its a AWP 1.8t jetta with ASR.. I believe I came across something about a revision in the hydraulic line but I'm not sure.
Prius (Gen 3) :: Plastic That Covers Bottom Of Motor Compartment Seems Missing
Yesterday I want under my 2011 for the first time . Successfully installed an engine block heater ! when I was under there I noticed an opening in the plastic that covers bottom of the motor compartment It was under what looks like the transmission on the driver side of the car . I was working through the access door to the oil filter of course. Is there supposed to be two doors under the car and one just is not been replaced ?
View 4 RepliesElantra XD (2001-06) :: Smell Of Burned Plastic From Engine Compartment
I just bought 2004 Elantra GLS with 64 000 miles on it. Great small car. Suddenly when I parked the car I felt smell of burned plastic from engine compartment. I checked,no smoke just smell. Also,when I drive and press the breaks the car slows down fine after I release the brake pedal and just before to stop I can feel small pushes. What is happening.
View 2 RepliesLexus GS 2006-11 :: 2 Plastic Pins Missing From Engine Compartment Covers?
I had the fuel pressure sensor recall done recently, and I got the car back with 2 plastic pins missing from the engine compartment covers.
Car went in with all of the pins in place. No big deal, I have a bag of pins and I can replace them.
But then I wonder, if they're careless about small things like pins, are they putting my engine back together with all the bolts and screws???
My dad once told me a story about a coworker who used to work the Ford assembly line. They would sometimes put in 3 bolts where 4 were required.
One day, if my engine fails, it may be hard to prove the dealership was the cause.
Golf IV / Jetta IV :: 2001 - Hot Plastic Or Wire Smell From Vents
I have an 01 GTI GLX with climatronic, and I've noticed this hot plastic or hot wire smell in the vents. Yes the fan wire gets hot when the car is hot and AC is on. But I don't think that's it. I've torn the passenger side apart, took the blower motor out, not it. The vent / recirculate motor is external to the vents, the only other place is behind the radio for the other one. What else is internal, if anything, that could be causing this smell? I'm concerned that something will melt or burn up.
I've been wondering if the ecm in the cowl would be getting hot but I can't smell anything with the plastics on. I would say it does seem to occur after driving for about ten minutes in town. But it also seems like it's there when I first start it up also.
Golf IV / Jetta IV :: No Crank Just Single Loud Relay Click From Engine Compartment
So I drove my car about a mile to a friend's house and when I went to start it back up 10 minutes later, I got no start and no crank. Just a single loud relay click from the engine compartment. Tow truck tried jumping it and then thwacking the starter solenoid to try and get it going. No dice. Battery seems all good.
Had some interesting things go wrong the day before which may be related to it. First, I was tracking my MPG and fuel trim on a highway trip and the trim and fuel consumption data just stopped coming in. Speedo and RPM data was still coming down the OBDII but I just assumed that my reader took a ****. Later that night I noticed that the lights on my climate control (the manual kind) went out. Tapped on it and it came back on, but only briefly. The bulb looks shot.
No engine strangeness on the drive over or earlier in the day. I drive it most every day. Has 215,000 miles on it.
I'm guessing either a short or bad starter. FWIW, I've also been experiencing the typical starter whine after starting. Was meaning to take it off and grease it. Not sure that has anything to do with it. I also tried rotating the crankshaft to make sure the engine wasn't locked up and it does turn, albeit not incredibly easily. It does have oil on the dipstick.
Passat (B7) :: Clunking Around The Plastic Inside Of Trunk Lid
I noticed something clunking around in the plastic piece that is on the trunk lid itself - the piece that covers the brake lights. When the trunk goes up or down, there is a distinct noise that is something rolling around in there.
I pulled off the access panel to get to the lights, but is does the rest of it just snap off if I pull at it or use a pry tool?
Ford Super Duty (1999-2016) :: Slight Burning Plastic Smell / Engine Compartment Heat Shield Falling Down?
Recently purchased a CPO 2009 F250SD 6.4L. Happy with the truck overall but this AM I noticed a slight burning plastic smell so I opened the hood and looked around closely. Didn't really find the culprit(I don't think) but noticed that the engine compartment heat shield/barrier appears to be falling down above and behind the turbos (pictures linked below). How big a deal is this? Would it be covered under the CPO warranty? It almost seems like a safety issue. I also wonder if the insulation material, now exposed without the metal reflector material, is what is causing the smell....
View 14 RepliesGolf IV / Jetta IV :: Key FOB Will Not Unlock Trunk
My key FOB only electronically unlocks/locks the doors it wont unlock the trunk and i can't actually use the key part to unlock the car or start the car. Is there a way to fix this besides getting a new key from a dealer since that is very expensive.
View 5 RepliesEngines - Lights - Jetta - Volkswagen :: 2003 - Flashing Check Engine Light / Burning Plastic Smell
Last night I was driving in my 2003 jetta on the intersate at 65mph with the cruise control on. As I came into a turn I had to tap the brakes. As soon as I did the check engine light came on. The car was doing fine so I drove home from school. Today I drove the car to work which is a five minute drive, and back with no problem. I later went to grab lunch and bring it home and then I noticed the check engine light started flashing. I then felt the engine start to stutter, as if it was misfiring. We had the windshield defrost when we started to smell a rotten egg smell. Luckily we were pulling into our drive when we smelled the odor. I immediately turned off the car and got out. I couldn't smell the rotten egg smell, but I did smell burning plastic. I didn't see any smoke and could not pinpoint the cause of the smell.
View 4 RepliesGolf IV / Jetta IV :: CEL Flashing When Floor 2004 1.8T GLI
For a while i've been dealing with this problem but its low priority because I never floor my car. The car drives perfectly fine even if you hold it 5-10 lbs of boost. When it goes into 18-20lbs it wont hold.
Symptoms : Only when I floor it SOMETIMES the car bogs down and the check engine light flashes for a little and eventually goes away. Now this doesn't always happen. Sometimes I floor it and everything works fine. I don't have vag or a laptop to hook it up and see what code is thrown.
The car is a 2004 1.8t GLI
Golf IV / Jetta IV :: Opening Trunk Of 2004 GLS With Key
Can I use my key to open my trunk in the case of a dead battery? I disconnected my battery last night to try it out, but it wouldn't open. Some people say turn the key 50 degrees, but I don't think my key will turn that far. I was also scared of snapping the key off in the lock.
View 3 RepliesGolf IV / Jetta IV :: 2004 - How To Remove Trunk Lid
I have a Bora trunk lid off a 2004 with the euro plate and lip my question is this how do I take my old trunk lid off because its wired in there I'm assuming its maybe a clip but all and all I just want to take the trunk lid off...
View 8 RepliesGolf IV / Jetta IV :: 2004 GLS - Trunk Only Opens With Key
So my 04 GLS Jetta has had this issue for a while and I would like to find out why. If I pull the button for the trunk in the drivers door or press the button my key to open the trunk, nothing happens. The lights will flash when I press the button on the key but no sound comes from the trunk. Same goes for the trunk release button in the door. No sound. The only way I can open the trunk is to use the actual key and while I turn the key, I have to press down on the trunk. Turning the key alone will not open the trunk. It only opens when I press down on the trunk and turn the key.
Is this normal if the trunk release motor on the trunk goes out? I also have had the trunk open and did the button in the door and the key with nothing happening. How to troubleshoot this?
Golf IV / Jetta IV :: 2001 VR6 Clutch Petal Just Goes To The Floor
I have a 2001 jetta with a Vr6 the clutch petal just goes to the floor. No return. What's could be wrong?
View 2 RepliesGolf IV / Jetta IV :: Driver Side Floor Soaked
I left my the car sitting for a week out in heavy rain and came back to find that the driver side floor was soaked. After searching around I seem to have found the entry point. It seems like all of the water is pouring in from my hood release lever area which I find strange. I put a towel down last night during two hours of rain and came back to find the towel almost fully soaked through. I read other threads on this but the results were inconclusive. Could it be the lower or upper windshield seals? Door seals? Another problem I'm having is water leaking from my dome light buttons after a heavy rain. I assume this is a problem with the sunroof seal, but whenever I search around it feels dry?
View 8 Replies