Ford Super Duty (1999-2016) :: F350 - Truck Is Running With Hesitation In 3rd / 4th And 5th Gear
I have a 1999 Ford F350 5.4L 4x4. I had a check engine code on my truck a couple of months ago. The truck was running fine then. The light went away and I forgot about the issue. In the last week the truck began to run like crap; hesitation during hwy speeds. The truck is running with hesitation in 3rd, 4th, and 5th gear. In low gears the truck seems to run just fine. I have changed the EGR valve as well as the fuel filter. Check engine light is not on but the problem has not gotten any better.
View 3 RepliesFord Super Duty (1999-2016) :: Grinds Bad Shifting Into 3rd Gear
I have a 99 7.3 F350 with 5 speed manual with over 300,000 miles. Grinds bad shifting into 3rd, and nothing happens in 4th. I think it is a S5-47-ZF. Is a 6 speed manual comparable to bolt up to bell housing?
View 2 RepliesFord Super Duty (1999-2016) :: Transmission Shifting From 3 To 4 Gear Seems To Be A Bit Prolonged
I have a 2012 F-250 ccsb lariat and the shift from 3 to 4 seems to be a bit prolonged as if the converter is slipping and wont go ahead and push it into 4 gear. Also it will want to downshift from 3 to 1 and feels like the car behind nailed you. I have read that the early 2011 had some of this problem and the dealer reflashed the tcm and it did not do much good but as mine being a 2012 mine should have been flashed with the lastest tcm flash from the get go?? Egr fell off and am running Kory Willis tunes through ez lynk so the stealership is probably out of the question. I have also read that changing a couple solenoids( dont remember which ones) will fix the problem.
View 11 RepliesFord Super Duty (1999-2016) :: Transmission Shifting Hard Between 2 And 3 Gear
The tranny is shifting really hard between 2 and 3 if I feather the throttle it can be a little less of a jolt but still enough none the less iv never done a filter and fluid change as I just got it it has 235000 miles 99 v10 super duty 4x4....
View 8 RepliesFord Super Duty (1999-2016) :: Transmission Stays In 5th When Shifting Into Any Gear Including Reverse
I have a 2000 F-550 w/7.3 and a 6 speed ZF transmission. My problem is that when you go to shift into any gear inc. reverse the transmission stays in 5th gear. I pulled the shifter and tried to do it from top of transmission it still stays in 5th. Any thoughts that I could possibly check?
View 1 RepliesFord Super Duty (1999-2016) :: Clutch Slipping - Harsh Shifting - Loud Clunk Noise Into Gear 2 Then 1
New truck 11000kms ago thats done medium amount of work but nothing heavy or sustained for long periods of time. I get the feeling of clutches slipping especially when truck is cold but also when normal temps. Doesnt make any weird noises or anything. I can really notice the difference in torque if in manual mode being much better, but still not perfect if i stomp on the gas pedal and go through the gears in manual mode will still slip. Also is really harsh shift if i come to a halt in 3rd manual mode with the brake pedal depressed push minus button the truck makes very loud clunk noise into gear 2 then 1. Took it to ford they couldnt find anything ? Thinking of trying another dealer.
View 2 RepliesFord Super Duty (1999-2016) :: Strange Whine When Cold Outside?
My tuck has been making a whining noise very similar to this and only when it's below freezing out. At 5 degrees it's even louder. Just noticed it the other day. Sounds like power steering whine. I have the 6.2 super duty.
View 14 RepliesFord Super Duty (1999-2016) :: Strange Oil Leak On 6.4 Powerstroke
[URL] .....
Just got this truck a few weeks ago... cannot trace the oil leak. Is this common?
Ford Super Duty (1999-2016) :: 2003 - Strange Noise After New Tires?
I got a 2003 5.4L Auto F-250 Super-duty CC yesterday and noticed it needed newer/new tires. I found some today and got them put on. I looked when the tires were off and all the tie rods, brakes, etc looked good. After leaving the tire shop the check engine light came on, I drove about 10kms on the hwy and it seemed fine then I got into town and made a stop.
When I was leaving there to go home I heard something that sounded like a chain dragging for a second then when I braked at lights the truck started jumping kind of so I pulled over and everything still looked fine. So I drove another 5kms and it was fine except for 1-2 lights it happened again, the brakes would squeal when stopping.
Then when accelerating from a light the truck would shake and make scraping noises until I hit about 30kms per hour, this happened whenever I heard the squealing at the few stops I had to do at lights. Some lights I stopped at and it was normal. The tires that were on the truck originally were mismatched, different sized and smaller than the stock size. The ones I put on are all the same set, and are 265-75-R16. what this could be?
Ford Super Duty (1999-2016) :: 2008 F350 - Strange Noise At Higher RPM
I recently switched back over to the 5.4 from a diesel. It's a 08 F350. I have about 38,000 on it now. I have no complaints so far, a little less power than the diesel, but I don't tow much anyways. The only thing I can't figure out is a strange noise at around 2500-3000 rpms shortly before a shift sometimes. The best way I can think to describe it is that it sounds like a turbo fart in a diesel. Almost like someone is putting their finger over an air hose on and off a couple times. It doesn't do it all the time, and doesn't shake the truck, or effect the shift at all from what I can tell.
I've put it through a lot of different shifts just to see if it might be transmission related. It downshifts and upshifts perfectly without any noise or slipping, and the fluid looks just as clean as brand new. No smell or anything either. It doesn't feel like torque converter shudder to me either as i can't actually feel anything in the truck, just the small noise. To me it almost sounds like it's coming from under the hood. I'm not overly worried about it right now, because it isn't effecting the way the truck drives or shifts at all, I'm just curious what it could be.
Ford Super Duty (1999-2016) :: Strange Pop Noise Coming From The Transmission Area
I've got a 2016 250 6.2l and am getting a popping sound coming from the transmission area. the following is what i have figured out so far. the noise is made just before a complete stop, just as the tranny down shifts to 1st and can be felt through the manual floor shifter 100% of the time and heard roughly 90% of the time. sound ranges from not audible to loud and is random in how loud it is. the only way it does not do this is if i come to a stop in neutral or i go slow enough as not to have the tranny shift out of first from my last stop. the only other way is if i do one of those long, slow rolling stops. truck only has 6600 miles on it. i will be taking it in at 7500 for first service and have them look at it ...
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F250 4x4 - Strange Noise From Front End
In the last few hundred miles of driving, I notice there is a strange noise coming from what appears to be the front end of my truck. It sounds similar to a buzzsaw or a power sanding tool whenever it comes in contact with an object. The noise starts at around 30 mph, stops from 55-60mph, and starts again around 65 mph. The truck rides and drives normally and there doesn't seem to be any metal to metal contact noises or clunking and the hubs dont seem to be hot to the touch. I was thinking improperly balanced tires, wheel bearing, or front carrier assembly. What it could be? The noise just suddenly started and I was wondering if I should keep driving it?
View 7 RepliesFord Super Duty (1999-2016) :: Strange Wandering Feeling When Heading Down Road
Okay, so this is a very intermittent problem but it has been happening more and more lately. When this scenario happens, it is like the rough spot when driving in manually locked 4WD when turning the wheel, but it is where the steering wheel would be to go completely straight and when I try and correct it, it is like the wheel just over corrects when I try and the truck heads the direction the wheel is facing. I'm not sure what this problem is but it is really confusing me. The hubs are both in auto and the ESOF switch is to 2WD if that makes a difference. And it happened today after I made a left turn into the parking lot on campus.
View 14 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Tracking Down Strange Noise?
My dad just bought a 2001 F-250 Crewcab 4x4 w/V-10. 72,000 miles. Anyways i noticed a small almost exhaust leaking sound on the test drive. I had the dealership put it up on the rack so I could see the underside. I noticed that it has the famous broken manifold bolt. So I kinda wrote it off on that we would have to get that fixed soon. Anyways the noise hasn't gotten worse just now noticing it that it has set times when it happens.
It happens around 25 mph then goes away then back at 45 mph, then goes away. I am having a hard time describing it. Almost like the exhaust is building up pressure then releasing it when it gets too high. But then I starting thinking transmission something since it kinda has a delayed shift when the noise happens.To clarify I am not saying it anything to do with the torque converter. I am just rolling to find out what is going on.
Ford Super Duty (1999-2016) :: F250 - Strange Sound While Turning At Speed?
I have a '16 F250 4wd with the 6.7 and approx 3k miles. There has been a strange sound coming from the front end when turning left from a stoplight. It sounds like something slides or shifts and it only happens once in a while. The noise isn't loud but you can feel it.
View 2 RepliesFord Super Duty (1999-2016) :: Strange Vibration Coming From Driver Side Wheel Intermittently
So I had a strange vibration coming from the drivers side wheel intermittently. Only when the hubs were in Auto , by locking them it would not happen. With hubs in Auto when it occurs switching into 4H made it stop immediately.
It would occur after small bumps and sound like driving over a rumble strip. I figured it sounds like a needle bearing in the hub going wonky and just replaced the entire sealed unit. So that should be it right? Nope.....
The vibration has changed tone and sound but still occurred after a slight bump to the right Driver Side tower. It now is a much deeper tone then before.
I made sure everything was reassembled correctly and tight. I notice however that if I remove the ESOF lockouts to rule them out it still occurs (no lockout in at all ) .
I can move the outer DS stub shaft quite a bit with one finger when the lockouts are not installed. Which would explain that why when the lockouts are installed and I lock the hubs it doesn't occur as the end of the stub shaft rides in the lockout.
I haven't changed the outer axle seals , but they really didn't look shot. It appears as if the play in the axle is coming from the pumpkin.
Side note: I took apart everything and cleaned it , there was mud, crud, dirt and water throughout the hum to and into the lockouts. see pix below for the mess and carnage. I cleaned and lubed everything up.
Ford Super Duty (1999-2016) :: 2011 F250 - Strange Noise Coming From Engine When Accelerate
So after this weekend's hurricane my 2011 f-250 started to making a noise when I accelerate. I don't know if water got in some where. But there's no MIL light coming on.
View 11 RepliesFord Super Duty (1999-2016) :: Hesitation When Accelerating Or At A Stop
F250 5.4L have had a new fuel pump installed and new spark plugs (one blew out). When accelerating, or at a stop i get a kinda hesitation. It did it when I first bought the truck but put correct size tires on it and it went away. What it may be? I don't have a check engine light or anything and at cruise speed no problem--it's just when a slight load is put on the engine?
View 1 RepliesFord Super Duty (1999-2016) :: Hesitation Or Miss When Using The Cruise Control
2010 f250 cc 5.4 145000 miles. I bought it last fall have not drove it a lot. When using the cruise control and a load is added grade or hill in the roadway. It jerks hesitates or miss then cleans up and runs fine. When using the accelerator it does not do this. No codes.... Thinking about changing the plugs.
View 5 Replies