Ford Super Duty (1999-2016) :: 2001 F250 - Wandering In Steering
I have a 01 f250, owned it for about 8 months now. Have done a ton of work to it, replacing all worn out parts. It's a v10, replaced so far is ball joints, all tie rods, steering dampener, front sway bar links and bushings and Monroe gas Magnum shocks all around. My biggest problem is the wandering in steering. I put a 2.5" add leaf spring pack to front when I first bought it. It has stock bullet whole wheels and new Firestone's destination a/ts. Also. Tires have been rebalanced and are smooth until I get to 60+mph, its a swirling ride after 60mph. Could I have bad wheel hubs or do I have an alignment issue? Planning to replace hubs with Napa hubs since I did everything else and I'm sure there bad with 236k miles on truck.
View 8 RepliesFord Super Duty (1999-2016) :: Grind Feeling Through Gas Pedal And Noise From Front Right Suspension
I have a new 2016 F250, few months old, loving life. I noticed a weird noise/feeling when I am making turns while going over a bumps. There is a left hand turn on my way home that I take every day at approx 15 mph. There is a dip in the road and I can feel a weird grind kinda feeling through the gas pedal and a noise from the front right suspension. Being a brand new truck, I'm not sure what the deal is, or if I'm just overly critical.
View 4 RepliesFord Super Duty (1999-2016) :: Strange Whine When Cold Outside?
My tuck has been making a whining noise very similar to this and only when it's below freezing out. At 5 degrees it's even louder. Just noticed it the other day. Sounds like power steering whine. I have the 6.2 super duty.
View 14 RepliesFord Super Duty (1999-2016) :: Strange Oil Leak On 6.4 Powerstroke
[URL] .....
Just got this truck a few weeks ago... cannot trace the oil leak. Is this common?
Ford Super Duty (1999-2016) :: 2003 - Strange Noise After New Tires?
I got a 2003 5.4L Auto F-250 Super-duty CC yesterday and noticed it needed newer/new tires. I found some today and got them put on. I looked when the tires were off and all the tie rods, brakes, etc looked good. After leaving the tire shop the check engine light came on, I drove about 10kms on the hwy and it seemed fine then I got into town and made a stop.
When I was leaving there to go home I heard something that sounded like a chain dragging for a second then when I braked at lights the truck started jumping kind of so I pulled over and everything still looked fine. So I drove another 5kms and it was fine except for 1-2 lights it happened again, the brakes would squeal when stopping.
Then when accelerating from a light the truck would shake and make scraping noises until I hit about 30kms per hour, this happened whenever I heard the squealing at the few stops I had to do at lights. Some lights I stopped at and it was normal. The tires that were on the truck originally were mismatched, different sized and smaller than the stock size. The ones I put on are all the same set, and are 265-75-R16. what this could be?
Ford Super Duty (1999-2016) :: Strange Hesitation When Shifting From 1st To 2nd Gear
I bought my 2011 F250 FX4 about 2 months ago. A little about the truck: 6.2 liter gas. XL FX4. Manual 4x4. 6 speed auto. Supercab. Long bed. 42,000 miles. (1,000 of them mine.)
Until yesterday, the truck has performed absolutely flawlessly under all conditions. Then, randomly, I had what felt like a "missed shift" as I was leaving my dog's veteranarian yesterday. I pulled out onto the highway and as the truck attempted to shift into second gear, it didn't "catch" second. The gas just revved up and I had to take my foot off the gas pedal and put it back down to get second gear to engage. Most of my driving is stop and go around town and this has only happened once in probably well over a thousand stop and go situations. Should I be worried or was it just a fluke?
Also, FWIW, I did plenty of stop and go driving today without a single problem.
Ford Super Duty (1999-2016) :: 2008 F350 - Strange Noise At Higher RPM
I recently switched back over to the 5.4 from a diesel. It's a 08 F350. I have about 38,000 on it now. I have no complaints so far, a little less power than the diesel, but I don't tow much anyways. The only thing I can't figure out is a strange noise at around 2500-3000 rpms shortly before a shift sometimes. The best way I can think to describe it is that it sounds like a turbo fart in a diesel. Almost like someone is putting their finger over an air hose on and off a couple times. It doesn't do it all the time, and doesn't shake the truck, or effect the shift at all from what I can tell.
I've put it through a lot of different shifts just to see if it might be transmission related. It downshifts and upshifts perfectly without any noise or slipping, and the fluid looks just as clean as brand new. No smell or anything either. It doesn't feel like torque converter shudder to me either as i can't actually feel anything in the truck, just the small noise. To me it almost sounds like it's coming from under the hood. I'm not overly worried about it right now, because it isn't effecting the way the truck drives or shifts at all, I'm just curious what it could be.
Ford Super Duty (1999-2016) :: Strange Pop Noise Coming From The Transmission Area
I've got a 2016 250 6.2l and am getting a popping sound coming from the transmission area. the following is what i have figured out so far. the noise is made just before a complete stop, just as the tranny down shifts to 1st and can be felt through the manual floor shifter 100% of the time and heard roughly 90% of the time. sound ranges from not audible to loud and is random in how loud it is. the only way it does not do this is if i come to a stop in neutral or i go slow enough as not to have the tranny shift out of first from my last stop. the only other way is if i do one of those long, slow rolling stops. truck only has 6600 miles on it. i will be taking it in at 7500 for first service and have them look at it ...
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F250 4x4 - Strange Noise From Front End
In the last few hundred miles of driving, I notice there is a strange noise coming from what appears to be the front end of my truck. It sounds similar to a buzzsaw or a power sanding tool whenever it comes in contact with an object. The noise starts at around 30 mph, stops from 55-60mph, and starts again around 65 mph. The truck rides and drives normally and there doesn't seem to be any metal to metal contact noises or clunking and the hubs dont seem to be hot to the touch. I was thinking improperly balanced tires, wheel bearing, or front carrier assembly. What it could be? The noise just suddenly started and I was wondering if I should keep driving it?
View 7 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Tracking Down Strange Noise?
My dad just bought a 2001 F-250 Crewcab 4x4 w/V-10. 72,000 miles. Anyways i noticed a small almost exhaust leaking sound on the test drive. I had the dealership put it up on the rack so I could see the underside. I noticed that it has the famous broken manifold bolt. So I kinda wrote it off on that we would have to get that fixed soon. Anyways the noise hasn't gotten worse just now noticing it that it has set times when it happens.
It happens around 25 mph then goes away then back at 45 mph, then goes away. I am having a hard time describing it. Almost like the exhaust is building up pressure then releasing it when it gets too high. But then I starting thinking transmission something since it kinda has a delayed shift when the noise happens.To clarify I am not saying it anything to do with the torque converter. I am just rolling to find out what is going on.
Ford Super Duty (1999-2016) :: F250 - Strange Sound While Turning At Speed?
I have a '16 F250 4wd with the 6.7 and approx 3k miles. There has been a strange sound coming from the front end when turning left from a stoplight. It sounds like something slides or shifts and it only happens once in a while. The noise isn't loud but you can feel it.
View 2 RepliesFord Super Duty (1999-2016) :: Getting Vibration Driving Down The Road
01 F350...4R100/V-10/4wd. Sometimes get a vibration driving down the road. First thought of tire out of balance but then the vibration goes away and may not come back for a few days or more. It starts sometimes around 30-40 mph and stays all the way up to around 65 mph. Even slowing down it vibrates or shakes. I can stop and take off again with nothing happening. Would think tires out of balance would do it all the time. And a few times....pulling my 5th wheel...making a right turn out of a parking lot.....it feels like a rumble from the rear.
View 2 RepliesFord Super Duty (1999-2016) :: Strange Vibration Coming From Driver Side Wheel Intermittently
So I had a strange vibration coming from the drivers side wheel intermittently. Only when the hubs were in Auto , by locking them it would not happen. With hubs in Auto when it occurs switching into 4H made it stop immediately.
It would occur after small bumps and sound like driving over a rumble strip. I figured it sounds like a needle bearing in the hub going wonky and just replaced the entire sealed unit. So that should be it right? Nope.....
The vibration has changed tone and sound but still occurred after a slight bump to the right Driver Side tower. It now is a much deeper tone then before.
I made sure everything was reassembled correctly and tight. I notice however that if I remove the ESOF lockouts to rule them out it still occurs (no lockout in at all ) .
I can move the outer DS stub shaft quite a bit with one finger when the lockouts are not installed. Which would explain that why when the lockouts are installed and I lock the hubs it doesn't occur as the end of the stub shaft rides in the lockout.
I haven't changed the outer axle seals , but they really didn't look shot. It appears as if the play in the axle is coming from the pumpkin.
Side note: I took apart everything and cleaned it , there was mud, crud, dirt and water throughout the hum to and into the lockouts. see pix below for the mess and carnage. I cleaned and lubed everything up.
Ford Super Duty (1999-2016) :: 2011 F250 - Strange Noise Coming From Engine When Accelerate
So after this weekend's hurricane my 2011 f-250 started to making a noise when I accelerate. I don't know if water got in some where. But there's no MIL light coming on.
View 11 RepliesFord Super Duty (1999-2016) :: F250 Cutting Off When Driving Down The Road?
While driving down the road the truck will just cut off. We wait a few mins and start it again can drive a few miles and it cuts off again. we have replaced the ignition coils and it is still doing this. No codes are coming up to get any idea what it can be?
View 14 RepliesFord Super Duty (1999-2016) :: Little Clunking In The Wheel On A Rough Road
Not sure if it's a bearing or some kind of U joint. I am just starting to feel a little clunking in the wheel on a rough road. It is not bad but I feel it, is it hard to fix this issue, and what is the correct part I am looking for. Steering Wheel Bearings? This is for a 08 F350 SRW 4X4 KR V10
View 7 RepliesFord Super Duty (1999-2016) :: Loud Spinning Sound When Driving Down The Road
I have a 2004 Ford f250 6.0. When driving it down the road i will hear a loud spinning sound, sorta like putting a playing card in your bicycle spokes. The sound can be heard until I make a complete stop where at that time the sound stops and a clunk can be felt. After that the truck sounds normal. This also only happens once between starting the truck and turning it off. I took it into the shop and they could not hear the sound, all they said is i need new ball joints.
View 6 RepliesFord Super Duty (1999-2016) :: Steering Went Out Completely When Driving On A Straight Road
A few weeks ago, my employees were driving home one of my work trucks, a 2001 F350 7.3 4x4 Crew w. 130K miles. They were on a straight road in a small town when the steering went completely out. The truck veered into a telephone pole. No one was injured. The truck has major damage to the front passenger's side.
I finally got the truck back to my shop today. It is quite evident what caused the problem. The gear/splined shaft that protrudes from the steering box and is connected to the pitman arm sheared completely off.
Ford Super Duty (1999-2016) :: Engine Died Suddenly When Driving Down The Road
2004 F-250. 6.0 I was driving down the road when the engine dies. It was like I had turned off the key. When I tried to restart it, it was no click, no starter sound, nothing. The glow plug light remained on, even while turning the key over. What could cause this?
View 10 Replies