Ford Super Duty (1999-2016) :: F250 V10 Blowing Oil And Smoke Out Of Exhaust
Got a 99 V10 blowing a lot of oil out of the exhaust pipe, to the point where I could fog the neighborhood, cylinder number 10 had original spark plug dirt down in the hole know one wanted to clean it out so I did put new plug and coil now smokes a lot, also truck has 173559 miles, did a half diesel half used motor oil flush tonight, wanted to go for 15 minutes only made it to 14 to much smoke, will put fresh oil in tomorrow, what could be the problem, piston ring blow by, intake manifold leak, burning what I think is oil could be coolant, head gasket no bubbles in oil or antifreeze and antifreeze and or oil are not mixing. Is it easier to pull the heads off with pulling the motor which looks fairly easy or leave it in the truck.
View 2 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Black Smoke Blowing Under Acceleration
My 2006 F-250 (6.0 Diesel) started blowing black smoke under acceleration yesterday. It has 181k miles on it now. No loss of power, no rough idle, no smoke unless there's a load on the engine like accelerating, but then it doesn't matter if it's 1500 or 3000RPM, just the higher the RPM the more smoke it blows from the exhaust, dark black.
The truck has ARP headstuds, no programmer. Replaced both batteries and the A/C system about 2 weeks ago. About 3000 miles ago it got new glow plugs & harnesses, new alternator, all fluids changed, new aftermarket EGR cooler, new EGR valve, new turbo & actuator, new EBP sensor, new HPOP incl pipes and IPR.
Trucks starts up just fine, runs normal, just yesterday going down the Freeway about 65mph I noticed it started smoking black going up a hill, then smoke went away going downhill... Now every time I accelerate it's smoking black. Taking off from a stop sign it made a little puff of white smoke then went back to black smoke, but that only happened once.
Where I should start looking? No codes so far. But I have an AutoXRay EZ-Scan 6000, what sensors do I need to look at?
Ford Super Duty (1999-2016) :: 2003 F250 - Blowing White Smoke Even Replaced EGR Valve?
I have a 2003 F250 that has recently started blowing white smoke. I replaced the EGR Valve but no luck.
View 3 RepliesFord Super Duty (1999-2016) :: 2004 F250 - Whitish Smoke Coming Out
I have a 2004 F250 with 180K miles on it. About a year ago my truck would smoke pretty bad so I got on here and found I needed to take my FICM off and do some touch up soldering on it in a few places. Did that and everything has been fine until this past weekend when I noticed a little bit of whiteish smoke. Could it be the FICM again or something else. still have power and all gauges are normal. What to check next. Also, I do not have a scangauge, just the stock gauges.
View 11 RepliesFord Super Duty (1999-2016) :: 2004 F250 Keeps Blowing Fuse 23 When Hit Bumps
2004 5.4L F-250 ... it's a one owner truck I bought brand new in 2003 and only has 50,000 miles on it.
I have the 2V 5.4 engine no tuner or chip. 4x4 with 4" lift and 35's and I changed the rear to 4.88's. I love the truck but my problem is when I hit a large bump or drive too fast on a dirt road the fuse#23 that controls the PCM will blow. Consistently. I have to keep a box of 20 amp fuses handy. I have a 2 post lift in my shop and have scoured over every wire that is connected to the fuse. The EVAP solenoid, AC Clutch, Transmission solenoids and the O2 sensors. I only have 2 sensors I could find one on each side of the headers.
I couldn't find any rubbing wires or exposed wires. I am at a loss. It only happens when I hit a large bump. Could it be the Torque Converter Clutch Solenoid?
My brother in law is a mechanic and he brought over the diagnostic computer and when it blew while hooked up he seemed to think it was the TCC solenoid because when it engages the chart shows it angling up but when it disengages it drops off straight like it should. My truck seems to run fine when the fuse isn't blown, but when it blows it goes into a limp mode with the tranny stuck in 3rd or 4th gear and I have to drive it home in 1st.
Ford Super Duty (1999-2016) :: 2004 F250 - Loud Whining Noise / White Smoke From Serpentine Belt
I bought a 2004 6.0L F-250 used a few weeks ago. There have been a few problems here and there that I have been competent enough to fix. I am now facing a problem of A: the truck not starting (I believe it was just a battery problem, charged and started fine). But also B: I have had a slightly frayed serpentine belt that I noticed a few days ago. After I got the truck running from my the no-start and driving it around the block I parked it and went inside. Came back out a few minutes later and I tried to start it. It hesitated a little bit but started with a loud whining noise and white smoke coming from the belt. Turned the engine off and saw on one of the bottom wheels (pulleys?) some residue that looked and smelled like burnt rubber. Is this just simply a need for a new belt?
View 5 RepliesFord Super Duty (1999-2016) :: Lost Control And Blowing Black Smoke?
I have just replaced the EGR cooler, Oil Cooler, professional turbo reconditioning, both dummy plug's and stand-pipe's, blue spring, fuel filters, oil changed, cleaned the EGR valve and intake manifold. I am in the process of doing a coolant flush when my issue occurred. I was on the road for about 10 minutes when I lost power and started blowing black smoke. I have normal power till about 45 mph then nothing. I can baby the truck up to 55-60 and then nothing and the whole time blowing black smoke.
I stomp on the pedal with no power. I hear the whine of the turbo. The truck idles and sounds fine. My SCT showed my oil and coolant temps within 15 degrees. I opened the hood and saw soot all over the top of the engine from the compressor to the EGR valve and all in the valley from valve cover to valve cover; but more so on the driver side to FICM. I obviously didn't connect something properly. I am just about to remove the intake manifold and reinstall, but before I do just wanted some input.
Ford Super Duty (1999-2016) :: 2006 - Black Smoke Blowing Out The Exhaust - No Power?
I have a 06 6.0 Powerstroke 6 Speed every time I get on it or even try to get going I have no power and I have pure black smoke blowing out the exhaust somebody told me to change the fuel filters which I did which they were pretty nasty then after I did that I seem to still have the same problem so then they told me to check the EGR valve put injector cleaner in it to clean the injectors which I have not done a gr or injector cleaner yet just wanted to know, what it could be or what I can do to prevent the black smoke I have no power either...
View 1 RepliesFord Super Duty (1999-2016) :: 2005 - Blowing White Smoke And Leaking Coolant
My truck is a 2005 6.0 with no after mods and has 73000 miles on it. It began to blow white smoke out exhaust. I changed out the egr valve and cooler. After putting back together it then blew white smoke ran it to clear out. This worked however once it warmed up it began to blow thick white smoke at 20 mph and clears up by the time it reached 30mph and white smoke shoots out at rapid acceleration. As well there is coolant leaking out under the truck from somewhere in the motor about in the center. I am looking to work on this myself as I have heard of owners taking it to shops and paying a lot of money for the prob to not get fixed.
View 7 RepliesFord Super Duty (1999-2016) :: 2002 - Pure White Smoke Blowing When Driving
I have a 2002 f250 powerstroke 7.3, while driving it smokes pure white smoke and feels like its loading up and will start shaking if I floor it, it will rev slowly popping like its loaded up then cleans out runs good for a 1/4 mile than same thing. My temp gauge stopped working and it just seemed to get worse. Stuck it on a scanner and it didn't have any codes but was saying the engine temp was -211f. I got a new sending unit didin't fix any of the problems.
View 14 RepliesFord Super Duty (1999-2016) :: White Smoke Blowing - Codes P2452 And P1335
Recently have had a sct live wire extreme on my truck and ever since put it back to stock put the dpf back on its been blowing white smoke got a p2452 and p1335 code but when you turn the tuner back on and turn the dpf off no more white smoke and no codes ? What could be causing this? beyond confused ?? (the reason I took the tuner off is cuz I am sell the truck and the dealership wants it stock),
View 3 RepliesFord Super Duty (1999-2016) :: F250 - AC Blowing Through Defrost
1999 F250 7.3 4x4 switch on dash with manual hubs. No visual vacuum hoses cracked.
Not sure what this component is but when I wiggle the wire at the orange cap a small motor kicks on.
Ford Super Duty (1999-2016) :: 2001 F250 - Fuse 19 Keeps Blowing
I have an 01 f250 5.4l standard. #19 fuse keeps blowing. I hAve taken the gauge cluster out and do not see any wires melted or burned. It blows the fuse as soon as I turn the key over. I have read things saying the overdrive but that doesn't work with mine.
View 4 RepliesFord Super Duty (1999-2016) :: 2005 F250 - A/C Blowing Out Of Defrost
The A/C on my 05 F250 6.0 recently would not blow out through the vents. So, I replaced the vacuum pump and the reservoir tank. Once I replaced them the A/C still starts through the defrost vents but, after a minute or so starts to blow through the vents. I also noticed that the vacuum pump never stops running. Is this normal or is there something else I need to look for?
View 5 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Heater Not Blowing Hot
2001 F250 5.4. The heater will blow warm air at idle and on the second highest setting, once you start moving or turn the fan up to full blast it instantly cools off. The coolant level is fine. The engine runs at a normal temp.The blend door does work. I just replaced the thermostat, and both hoses for the heater core are hot.
View 4 RepliesFord Super Duty (1999-2016) :: 2005 F250 XLT Keeps Blowing Fuse 17
I have 2005 F250 6.0 XLT. I was driving the other night and all of a sudden my dash lights went out. I noticed I was being flashed from other drivers and discovered that my parking lights are not working. A preliminary check of fuses I discovered fuse #17 (15a mini) was blown. I installed and new one and upon turning my lights on, the fuse popped again. My headlights and turn signals work properly. It appears I have a wire shorted to ground somewhere on this circuit.
The truck is completely stock with the exception of an aftermarket radio which I installed two years ago.
I checked all the fuses with my test light and they are all correct (both sides of each fuse). I disconnected the gray connector and black connector in the driver side rear of the truck to isolate the issue. New fuse pops as soon as I turn lights on. I completely removed the tail lights, trailer 7 pin connector , completely removed both headlights. I did not disconnect the roof running lights or the mirror lights. I am completely stumped.
Ford Super Duty (1999-2016) :: 2001 F250 5.4L - Smoke From Exhaust Pipe
2001 F250 5.4L - I recently had my muffler changed and the pipe flange on the tailpipe up by the exhaust manifold welded back on. I haven't driven my truck much this past summer so when I took it in to get the muffler fixed the front caliper got temporarily stuck like it tends to do. It eventually freed up but in the meantime I noticed a hot oil-like smell coming from my truck from time to time. I chalked it up to either the new muffler or maybe it just smelled hot and it was instead the front brake caliper still being stuck. One day I'm driving down the interstate and I start uphill. I noticed smoke behind me and pulled over. The brake was not overheating so I got underneath the truck.
The smoke was rolling off of the exhaust pipe all the way down it all the way up near the manifold but mostly around the muffler. The smoke quickly went away while I was under the truck. I noticed it doing this only while the engine is under a load like going uphill. Just driving around town nothing is noticeable. When it does smoke I lose power. Once I slow down for awhile and then gradually speed back up things seem okay. I checked the oil.
Normally I don't lose a drop but this time I was a quart low but the oil on the stick was clean. It's been awhile since I had my oil changed but very little mileage on this change (my truck has sat awhile). My truck doesn't leave a drop of oil under it when it sits. From what I read you can remove the radiator cap and start the truck to see if it's a blown head gasket. At least that one of the things I can check easily without actually taking the plugs out even though the oil looks clean. The radiator has not lost any fluid. The transmission fluid is also good. It's been doing this for about 3 weeks.
I still drive it to and from work (about 15 miles round trip) everyday but I take it easy on the acceleration and stay on city streets. I looked into the EGR system online for my truck and instead found an EVAP purge solenoid/valve in its place on the passenger side. I don't have any service lights on the dash. I went to Autozone and had them scan it but nothing came up. I read somewhere that either the purge solenoid assembly or EGR (I can't remember) can burn up the board if it goes bad resulting in no code showing up.
I recently changed a vacuum valve out that went bad that controlled the vacuum chamber used to operate the hubs on the 4WD. The 4WD is now operational again. Assuming the head gasket is not blown, what to check for next?
Ford Super Duty (1999-2016) :: 2000 F250 - Smoke Will Come From The Turbo After Driving For A While
I have a 2000 f250 7.3 powerstroke. I bought the truck with 218000 miles on it, I have only put 1000 on it. I have had some issues with. The cps went out of it, and it wouldn't start until u replaced it. I have a Ts chip on it and cold air intake. It will not start after a cold night, it starts fine if I plug it in. It also lopes, or misses no matter the temperature outside. Also, it will blow a steady flame when you get on it. Finally, it also gets hot, smoke will come from the turbo after driving it for a while, no matter how you drive it.
View 2 RepliesFord Super Duty (1999-2016) :: 2008 F250 - White Smoke Pouring Out
I have a 2008 Ford 250 diesel that is pouring out white smoke from the exhaust when it goes into "cleaning filter" mode. I really don't understand this because I have a dpf delete with a sct tuner. I thought with the tuner and delete the truck wouldn't go into filter cleaning mode. I contacted Ford and they said it was normal for white smoke to come from the exhaust during this process. What's going on maybe tuner is bad?
View 5 Replies