Ford Super Duty (1999-2016) :: 2000 F250 V10 - 4R100 Making Noises Audible While Driving Especially In Third And OD
Troubleshooting on my wonderful transmission. I have a 2000 F-250 CC Lariat with the V-10. When I start the truck, I hear a high pitch noise. It's like a high pitch whine. It changes frequency as you rev the engine in park. Put the transmission into gear. Either forward or reverse, and the noise is lower pitch. As you accelerate, the noise will change frequency. If the tranny is manually shifted, the noise will go away, and then come back a short time later. The noise is audible while driving especially in third and OD. The truck has 93,000 and is dead reliable except for this. I have been under the truck, and I can tell it's coming from the tranny. Not sure if it's the converter or what.
View 10 RepliesFord Super Duty (1999-2016) :: F250 - Whistling Turbo Under Load
Just bought a 1999 7.3 f250 w/71000 miles and took it to a diesel guy and under load he said that the whistling was normal..is this correct?
View 3 RepliesFord Super Duty (1999-2016) :: Gauge Levels For 2003 SD Twin Turbo F250?
Just bought a watchdog monitor by Bullydog. What are the normal levels for Boost, MAF, Load for a SD Twin Turbo 6.0L?
View 7 RepliesFord Super Duty (1999-2016) :: 2005 F250 6.0 Turbo Diesel With FICM Related Codes
After finding that a battery was low and not getting charge, they found the alternator was bad. Replaced that. Next the battery that was low was able to be charged and did not effect the other battery. Both batteries have been load and charge tested and they both read 84% charged. I am told this is "good."
Next I swapped both fuel filters and did the oil change as well. I finally got a chance to get my friend to run his scanner on it. The results are injectors and FICM. The codes are PO261, 264, 267, 270, 273, 276, 279, 282, and finally 611. I guess this means that the FICM is toast.
I have tried salvage and no one has anything. I guess I still don't understand how this truck is capable of running daily with the computer throwing every code dealing with the injectors and the computer that runs them.
Ford Super Duty (1999-2016) :: F250 V10 Blowing Oil And Smoke Out Of Exhaust
Got a 99 V10 blowing a lot of oil out of the exhaust pipe, to the point where I could fog the neighborhood, cylinder number 10 had original spark plug dirt down in the hole know one wanted to clean it out so I did put new plug and coil now smokes a lot, also truck has 173559 miles, did a half diesel half used motor oil flush tonight, wanted to go for 15 minutes only made it to 14 to much smoke, will put fresh oil in tomorrow, what could be the problem, piston ring blow by, intake manifold leak, burning what I think is oil could be coolant, head gasket no bubbles in oil or antifreeze and antifreeze and or oil are not mixing. Is it easier to pull the heads off with pulling the motor which looks fairly easy or leave it in the truck.
View 2 RepliesFord Super Duty (1999-2016) :: 2001 F250 5.4L - Smoke From Exhaust Pipe
2001 F250 5.4L - I recently had my muffler changed and the pipe flange on the tailpipe up by the exhaust manifold welded back on. I haven't driven my truck much this past summer so when I took it in to get the muffler fixed the front caliper got temporarily stuck like it tends to do. It eventually freed up but in the meantime I noticed a hot oil-like smell coming from my truck from time to time. I chalked it up to either the new muffler or maybe it just smelled hot and it was instead the front brake caliper still being stuck. One day I'm driving down the interstate and I start uphill. I noticed smoke behind me and pulled over. The brake was not overheating so I got underneath the truck.
The smoke was rolling off of the exhaust pipe all the way down it all the way up near the manifold but mostly around the muffler. The smoke quickly went away while I was under the truck. I noticed it doing this only while the engine is under a load like going uphill. Just driving around town nothing is noticeable. When it does smoke I lose power. Once I slow down for awhile and then gradually speed back up things seem okay. I checked the oil.
Normally I don't lose a drop but this time I was a quart low but the oil on the stick was clean. It's been awhile since I had my oil changed but very little mileage on this change (my truck has sat awhile). My truck doesn't leave a drop of oil under it when it sits. From what I read you can remove the radiator cap and start the truck to see if it's a blown head gasket. At least that one of the things I can check easily without actually taking the plugs out even though the oil looks clean. The radiator has not lost any fluid. The transmission fluid is also good. It's been doing this for about 3 weeks.
I still drive it to and from work (about 15 miles round trip) everyday but I take it easy on the acceleration and stay on city streets. I looked into the EGR system online for my truck and instead found an EVAP purge solenoid/valve in its place on the passenger side. I don't have any service lights on the dash. I went to Autozone and had them scan it but nothing came up. I read somewhere that either the purge solenoid assembly or EGR (I can't remember) can burn up the board if it goes bad resulting in no code showing up.
I recently changed a vacuum valve out that went bad that controlled the vacuum chamber used to operate the hubs on the 4WD. The 4WD is now operational again. Assuming the head gasket is not blown, what to check for next?
Ford Super Duty (1999-2016) :: 2004 F250 - Whitish Smoke Coming Out
I have a 2004 F250 with 180K miles on it. About a year ago my truck would smoke pretty bad so I got on here and found I needed to take my FICM off and do some touch up soldering on it in a few places. Did that and everything has been fine until this past weekend when I noticed a little bit of whiteish smoke. Could it be the FICM again or something else. still have power and all gauges are normal. What to check next. Also, I do not have a scangauge, just the stock gauges.
View 11 RepliesFord Super Duty (1999-2016) :: 2004 F250 Blowing Out Tons Of Smoke
04 F-250, blowing tons of smoke. I've replaced the ICP sensor, crankcase breather hose (it was broken at the clip), cleaned the turbo, and EGR valve. Any other ways before I take it to a shop to get bent?
View 1 RepliesFord Super Duty (1999-2016) :: 2008 F250 - White Smoke Pouring Out
I have a 2008 Ford 250 diesel that is pouring out white smoke from the exhaust when it goes into "cleaning filter" mode. I really don't understand this because I have a dpf delete with a sct tuner. I thought with the tuner and delete the truck wouldn't go into filter cleaning mode. I contacted Ford and they said it was normal for white smoke to come from the exhaust during this process. What's going on maybe tuner is bad?
View 5 RepliesFord Super Duty (1999-2016) :: 2005 F250 Will Not Start And No Smoke - Bad FICM
I have a 05 f250 6.0 that currently will not start and no smoke. Replaced batteries and tested ficm. At initial injector buzz voltage drops to 18.8 then jumps back to 48.8 and drops again to 18.8 while cranking. My question is if the voltage is this low does the pcb still just need a resolder or are there components that will need to be replaced?
View 1 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Black Smoke Blowing Under Acceleration
My 2006 F-250 (6.0 Diesel) started blowing black smoke under acceleration yesterday. It has 181k miles on it now. No loss of power, no rough idle, no smoke unless there's a load on the engine like accelerating, but then it doesn't matter if it's 1500 or 3000RPM, just the higher the RPM the more smoke it blows from the exhaust, dark black.
The truck has ARP headstuds, no programmer. Replaced both batteries and the A/C system about 2 weeks ago. About 3000 miles ago it got new glow plugs & harnesses, new alternator, all fluids changed, new aftermarket EGR cooler, new EGR valve, new turbo & actuator, new EBP sensor, new HPOP incl pipes and IPR.
Trucks starts up just fine, runs normal, just yesterday going down the Freeway about 65mph I noticed it started smoking black going up a hill, then smoke went away going downhill... Now every time I accelerate it's smoking black. Taking off from a stop sign it made a little puff of white smoke then went back to black smoke, but that only happened once.
Where I should start looking? No codes so far. But I have an AutoXRay EZ-Scan 6000, what sensors do I need to look at?
Ford Super Duty (1999-2016) :: 2009 F250 - Smoke Coming From Underneath The Truck
Our 2009 F-250 in our signature with 53,000 miles on it recently had a transmission episode that has me concerned. We were towing our fifth-wheel camper which weighs around 9000 lbs. We were nearly home on a 275 mile trip. All interstate at speeds of no more than 67 MPH. As I was in the process of exiting the interstate on the last 12 miles of our journey I noticed some smoke coming from underneath the truck. I immediately stopped and got under the truck and noticed transmission fluid running down from the top of the transmission and dripping onto the crossover exhaust pipe.
I let the truck idle for several minutes and it seemed to stop dripping fluid, or at least it had slowed considerably. I took off again being very careful not to gas it up at all, if fact I was very light footed with it from there on home. The ScanGauge II showed the transmission temp. had never got above 186 all the way home and it was at about 185 at the time I saw the smoke. The ambient temperature was around 90 and the truck had not labored at all on the way home. It would do the usual down shifting at overpasses but since I installed the 4.30 gears it doesn't do all that much shifting with the cruise control set on around 65-66 MPH.
I couldn't see where the oil was coming from but it was toward the top of the transmission. The transmission acted perfectly normal in every way even at the time of the dripping.
As I said, I took it plenty easy all the remaining 12 miles home and the tranny temp. dropped down to around 181. I parked the truck and camper on our asphalt driveway and saw no sign of drippage after it was parked. I fired the truck up the morning after this incident and drove it pulling the camper until the transmission temp. got to 185 and came home and parked it on the asphalt again and saw no signs of any leakage.
I checked the transmission fluid level per the instructions in the owners manual and it appeared to be right up to full. I don't believe it was over full. It smelled like it was new without a hint of any burnt odor. I bought the truck with 31,000 miles on it and had the dealer at which I purchased it change the transmission fluid at that time so it should be in very good condition.
I am going into a very busy time with this truck and can't chance any down time if it can be avoided. According to the research I did at the time I purchased this truck the automatic transmissions Ford used in the 2009 F-250 are pretty much bullet proof if maintained properly and not overly abused. This one has been well maintained and I've NEVER abused it. I wanted a manual trans. at the time I bought this unit but could not find one anywhere. I'm not a big slush-a-matic fan and I sincerely hope this one doesn't make me realize my long standing fear of slush-a-matic transmissions.
Ford Super Duty (1999-2016) :: 2005 F250 Idles Then Revs By Itself And Throws Black Smoke
2005 F250
123'xxx miles
EGR delete kit
This is my problem, the truck Idles then revs by itself and throws black smoke.If i leave it on it eventually seems like it floods and shuts off,when i first noticed this it had a loss of power and was having a hard time shifting gears, it would idle fine but when i would try and drive the truck it had no power. I changed the diesel filters and the air filter and the problem persists.
Could this be a bad turbo? Injector?
Here is the video of the problem.. F250 problem. - YouTube..
Ford Super Duty (1999-2016) :: 2003 F250 Flooding Out - Black Smoke Pours Out When Get It Started
My mechanic cannot figure it out nor can a Ford mechanic. About every one to two weeks, only in the morning, after I drive about a half mile it starts running rough and stalls at idle. It behaves like it is flooding out. When I can get it started black smoke pours out until it clears. I can hold it above 2000 rpm but, as I lower the revs, it starts stalling again until it stops. I've tried blowing it out on a long stretch but at normal speed it does it again. After repeating this several times it suddenly runs right and won't happen again for a couple weeks, the longest being four weeks. I thought it might be the remote start but that theory was busted. I've searched here and in other sites and replaced the IAC but it still did it. Replacing the O2 sensors did not work. I don't want to keep throwing parts at it.
'03 F250 FX4, 5.4 gas....
Ford Super Duty (1999-2016) :: 2006 F250 6.0L - Starts Hard With White Smoke During Summer?
During the winter, the truck would always start very hard. When it was trying to start it would pump out some white smoke. Now during the summer the truck will still start hard. At one point during the winter we were getting glow plug codes, now these have gone away that its warm. We did replace the glow plug control module, but that did not solve the hard start during the winter. We figured that there was a bad glow plug which is sorting out the rest. So we then figured the hard start issue would go away with the warmer weather but it has not.
View 3 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Lots Of White Smoke On Cold Start
Just bought a 02 f-250 7.3 with 115k miles. A couple days after I bought it I noticed a lot of white smoke on cold starts for about 20-30 sec at 50 degree temperature. So I tested the GPR which ended up being bad a replaced with the one that is double in size(name escapes me atm) and also did the 50 cent mod to keep the through-valve cover harness from losing connection since both sides were lose.
After that the temp warmed back up and it would only blow a "puff" of white smoke. The past two days it has gotten down to 30-32 and the truck has a rough time starting. Cranks fine but it's almost like it's getting choked or flooded then it will blow smoke for 3-4 minutes after it starts. The truck does have a FASS fuel system on it with stock injectors. Should I try to Ohm out the glow plugs again or where should I start trouble shooting?
Ford Super Duty (1999-2016) :: 2008 F250 - Light Smoke And Heavy Exhaust Smell
I have a 2008 6.4L F-250 and occasionally when I come to a stop I can see a faint white smoke coming out from under the truck and the hood. The smoke has a heavy diesel exhaust smell. When I step on the pedal nothing comes from the exhaust and it does not happen all the time. What is going on?
View 2 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Crank And Blows White Smoke For 1 - 2 Minutes?
I just recently purchased my 06 Ford F-250 it's got the 6.0 in it once I made a 6hr trip I've noticed once you warm it up and ride a little bit kill it let set for 30min or better and crank it up it blows white smoke for a min or two than on the way to work this morning my heater.
View 2 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Blowing White Smoke Even Replaced EGR Valve?
I have a 2003 F250 that has recently started blowing white smoke. I replaced the EGR Valve but no luck.
View 3 Replies