Ford Super Duty (1999-2016) :: 2004 F250 Won't Start - Spraying Noise Coming From Underneath The Truck
I have a 2004 f250 with a 5.4l and it won't start. I went to leave the store and went to start it and the truck started when I turned the ignition on not when I engaged the starter so I drove home anyway but there was what sounded like a spraying noise coming from underneath the truck all the way home the truck did die once on the way home but started right back up without me doing anything. Got home shut the truck off now it won't crank or anything all my lights and everything come on like normal just won't crank. What the problem is?
View 7 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Ticking Noise Coming From Underneath
I have a 2003 F250 4wd with a 5.4 and 6 spd and 175,000 miles. Yesterday I came out to start it and noticed it had a ticking noise coming from underneath. According to the stock gauge it had normal oil pressure and the oil looked nice and clean and was full. I checked it while running and was able to verify that it is coming from the bottom oil pan/bell housing area. Before anybody says exhaust leak, I just put on JBA headers a few months ago and verified it wasn't an exhaust leak. I was assuming it was a rod bearing so I figured I would let it get to operating temp and see what happens. Once it started getting warm it started getting quiet and finally it just stopped once it hit full operating temp. Took it for a drive and found that it does it when in gear no matter what but stops when I put it in neutral and let out on the clutch. it makes the noise in neutral with clutch pushed in, but stops as soon as you let it out.
View 5 RepliesFord Super Duty (1999-2016) :: 2000 - Smoke When Truck Gets To Temperature - Oil Coming Out Of Exhaust?
My truck is a 2000 7.3 doesn't smoke on start up but once it gets to temperature it does. I'm not going through any antifreeze, just oil and it's coming out the exhaust. The truck still runs great starts right up every morning without being plugged in. Any opinions?
View 3 RepliesFord Super Duty (1999-2016) :: 2004 F250 - Whitish Smoke Coming Out
I have a 2004 F250 with 180K miles on it. About a year ago my truck would smoke pretty bad so I got on here and found I needed to take my FICM off and do some touch up soldering on it in a few places. Did that and everything has been fine until this past weekend when I noticed a little bit of whiteish smoke. Could it be the FICM again or something else. still have power and all gauges are normal. What to check next. Also, I do not have a scangauge, just the stock gauges.
View 11 RepliesFord Super Duty (1999-2016) :: 2009 F250 - Dome Light Not Coming On When Open The Door
I just bought a 2009 F250 and when I open the door the dome light does not come on?? Is there a setting I am missing? Could it be a fuse?
View 3 RepliesFord Super Duty (1999-2016) :: F250 V10 Blowing Oil And Smoke Out Of Exhaust
Got a 99 V10 blowing a lot of oil out of the exhaust pipe, to the point where I could fog the neighborhood, cylinder number 10 had original spark plug dirt down in the hole know one wanted to clean it out so I did put new plug and coil now smokes a lot, also truck has 173559 miles, did a half diesel half used motor oil flush tonight, wanted to go for 15 minutes only made it to 14 to much smoke, will put fresh oil in tomorrow, what could be the problem, piston ring blow by, intake manifold leak, burning what I think is oil could be coolant, head gasket no bubbles in oil or antifreeze and antifreeze and or oil are not mixing. Is it easier to pull the heads off with pulling the motor which looks fairly easy or leave it in the truck.
View 2 RepliesFord Super Duty (1999-2016) :: 2001 F250 5.4L - Smoke From Exhaust Pipe
2001 F250 5.4L - I recently had my muffler changed and the pipe flange on the tailpipe up by the exhaust manifold welded back on. I haven't driven my truck much this past summer so when I took it in to get the muffler fixed the front caliper got temporarily stuck like it tends to do. It eventually freed up but in the meantime I noticed a hot oil-like smell coming from my truck from time to time. I chalked it up to either the new muffler or maybe it just smelled hot and it was instead the front brake caliper still being stuck. One day I'm driving down the interstate and I start uphill. I noticed smoke behind me and pulled over. The brake was not overheating so I got underneath the truck.
The smoke was rolling off of the exhaust pipe all the way down it all the way up near the manifold but mostly around the muffler. The smoke quickly went away while I was under the truck. I noticed it doing this only while the engine is under a load like going uphill. Just driving around town nothing is noticeable. When it does smoke I lose power. Once I slow down for awhile and then gradually speed back up things seem okay. I checked the oil.
Normally I don't lose a drop but this time I was a quart low but the oil on the stick was clean. It's been awhile since I had my oil changed but very little mileage on this change (my truck has sat awhile). My truck doesn't leave a drop of oil under it when it sits. From what I read you can remove the radiator cap and start the truck to see if it's a blown head gasket. At least that one of the things I can check easily without actually taking the plugs out even though the oil looks clean. The radiator has not lost any fluid. The transmission fluid is also good. It's been doing this for about 3 weeks.
I still drive it to and from work (about 15 miles round trip) everyday but I take it easy on the acceleration and stay on city streets. I looked into the EGR system online for my truck and instead found an EVAP purge solenoid/valve in its place on the passenger side. I don't have any service lights on the dash. I went to Autozone and had them scan it but nothing came up. I read somewhere that either the purge solenoid assembly or EGR (I can't remember) can burn up the board if it goes bad resulting in no code showing up.
I recently changed a vacuum valve out that went bad that controlled the vacuum chamber used to operate the hubs on the 4WD. The 4WD is now operational again. Assuming the head gasket is not blown, what to check for next?
Ford Super Duty (1999-2016) :: 2004 F250 Blowing Out Tons Of Smoke
04 F-250, blowing tons of smoke. I've replaced the ICP sensor, crankcase breather hose (it was broken at the clip), cleaned the turbo, and EGR valve. Any other ways before I take it to a shop to get bent?
View 1 RepliesFord Super Duty (1999-2016) :: 2000 F250 - Smoke Will Come From The Turbo After Driving For A While
I have a 2000 f250 7.3 powerstroke. I bought the truck with 218000 miles on it, I have only put 1000 on it. I have had some issues with. The cps went out of it, and it wouldn't start until u replaced it. I have a Ts chip on it and cold air intake. It will not start after a cold night, it starts fine if I plug it in. It also lopes, or misses no matter the temperature outside. Also, it will blow a steady flame when you get on it. Finally, it also gets hot, smoke will come from the turbo after driving it for a while, no matter how you drive it.
View 2 RepliesFord Super Duty (1999-2016) :: 2008 F250 - White Smoke Pouring Out
I have a 2008 Ford 250 diesel that is pouring out white smoke from the exhaust when it goes into "cleaning filter" mode. I really don't understand this because I have a dpf delete with a sct tuner. I thought with the tuner and delete the truck wouldn't go into filter cleaning mode. I contacted Ford and they said it was normal for white smoke to come from the exhaust during this process. What's going on maybe tuner is bad?
View 5 RepliesFord Super Duty (1999-2016) :: 2005 F250 Will Not Start And No Smoke - Bad FICM
I have a 05 f250 6.0 that currently will not start and no smoke. Replaced batteries and tested ficm. At initial injector buzz voltage drops to 18.8 then jumps back to 48.8 and drops again to 18.8 while cranking. My question is if the voltage is this low does the pcb still just need a resolder or are there components that will need to be replaced?
View 1 RepliesFord Super Duty (1999-2016) :: 2008 - 17 X 9 Will Fit On F250 Truck?
I have a 2008 f-250 4x4 extended cab, I picked up a set of black rock steel wheels 17x9. I now have 265 70 17s on my truck. will these wheels work and with what size tires.
View 4 RepliesFord Super Duty (1999-2016) :: White Smoke Coming Out Of The Tailpipe
2001 F250 5.4 with 160K miles. My wife "borrowed" my truck as she drove away, I saw white smoke coming out of the tailpipe. The kind you see in cold weather. Its was 75 degree in Texas this morning, so what could that be? There is antifreeze in the reservoir and I recently changed the oil and there was no water in it.
View 5 RepliesFord Super Duty (1999-2016) :: 2005 - Blue Smoke Pouring Out Of Back Of Truck At 70 MPH On Uphill Section
I was towing a 16' Carmate Box trailer (empty), in tow/Haul mode, through the mountains on the PA turnpike. On an uphill section, 70 mph, suddenly blue smoke was pouring out of the back of the truck. I immediately slowed to about 50mph and pulled over at the next opportunity, about a mile. The bottom of the trans pan was coated with fluid, mostly on left side and the exhaust crossover pipe was smoking. Gauges were all normal. Ambient temp was 90F.
I drove another 40 miles, mostly about 60 mph. No problems. When I started climbing in elevation, and hit 70mph again, the smoke started again. I pulled over again and crawled under to fine the crossover pipe in flames. I grabbed a rag and beat out the flames. Fluid was red. Gauges were normal again. Once I disconnected the trailer, I can find no leaks. Snugged pan bolts. I cannot duplicated the problem without the load and speed.
Background: 2005 Crewcab, 5.4, 5R110 trans, 3.73. 416,000 miles, I have towed about 50K miles of that. Trans always ran great. Never replaced.
Ford Super Duty (1999-2016) :: 2006 F250 - Black Smoke Blowing Under Acceleration
My 2006 F-250 (6.0 Diesel) started blowing black smoke under acceleration yesterday. It has 181k miles on it now. No loss of power, no rough idle, no smoke unless there's a load on the engine like accelerating, but then it doesn't matter if it's 1500 or 3000RPM, just the higher the RPM the more smoke it blows from the exhaust, dark black.
The truck has ARP headstuds, no programmer. Replaced both batteries and the A/C system about 2 weeks ago. About 3000 miles ago it got new glow plugs & harnesses, new alternator, all fluids changed, new aftermarket EGR cooler, new EGR valve, new turbo & actuator, new EBP sensor, new HPOP incl pipes and IPR.
Trucks starts up just fine, runs normal, just yesterday going down the Freeway about 65mph I noticed it started smoking black going up a hill, then smoke went away going downhill... Now every time I accelerate it's smoking black. Taking off from a stop sign it made a little puff of white smoke then went back to black smoke, but that only happened once.
Where I should start looking? No codes so far. But I have an AutoXRay EZ-Scan 6000, what sensors do I need to look at?
Ford Super Duty (1999-2016) :: 2002 F250 V10 - Squeak From Under The Truck
I have a 2002 f250 super duty v10 with the manual transmission... It has aloud squeak from under the truck when Im slowing down or maintaining a certain speed. The squeak goes away when I accelerate or if I push the clutch in. It does have a vibration to it when im speeding up. And shakes bad sometimes when I let off the clutch from a stop..
View 1 RepliesFord Super Duty (1999-2016) :: Smoke Coming Out Of Engine Bay / Alternator Is On Fire
So I was going to get the truck washed, but 2 blocks down the road smoke out of the engine bay.
Pulled over popped the hood and the alternator is on fire. Extinguished it self out but the burnt electrical smell.....sheesh..
Anyways, could I potentially drive the truck to the dealer, or will it catch on fire again????
Ford Super Duty (1999-2016) :: Smoke Coming From Under The Hood - Cylinder 10 Does Not Fire
I have a 2000 Ford F-350 V10 Triton that is currently not running. It all started when I was going to work at 7:00am it just shut off in the middle of the road. I had someone to take out of the road and found out one of the fuses had blown. It was replaced and not even a mile down the road it died again, luckily next to Orielly's. They came out and did a test and found out it was coil 10. I purchased and installed a new one and went down the road only to have it die again. I replaced the fuse again, and went back to Oriellys and just as I was backing into the parking spot it died, this time smoke coming from under the hood. The brand new coil had caught on fire but I extinguished the flame and got the coil unplugged before any damage happened. Replaced the same coil and it ran fine until I got home, let it idle and it was fine. Then, two days later I started it and it died, again smoke coming from under the hood but no flames or fire. Now cylinder 10 does not fire any more. What the cause is?
View 5 RepliesFord Super Duty (1999-2016) :: 2005 F250 Idles Then Revs By Itself And Throws Black Smoke
2005 F250
123'xxx miles
EGR delete kit
This is my problem, the truck Idles then revs by itself and throws black smoke.If i leave it on it eventually seems like it floods and shuts off,when i first noticed this it had a loss of power and was having a hard time shifting gears, it would idle fine but when i would try and drive the truck it had no power. I changed the diesel filters and the air filter and the problem persists.
Could this be a bad turbo? Injector?
Here is the video of the problem.. F250 problem. - YouTube..