Ford F-150 (2004-2008) :: 2006 - Grinding Or Whirring Noise Coming From Front Passenger Side Wheel
I owned a 99 f250 a little while ago. Just bought a 2006 crewcab F150 xlt about 2 months ago, and for the past month there has been this unusual grinding or whirring like noise coming from the front passenger side wheel.
I took it to the mechanic and he found a bad wheel bearing on drivers side and replaced it but that wasn't the issue. He could hear the noise but wasn't able to figure out what the actual issue was.
The noise only happens when my foot is on the throttle. (not when coasting) and i also just discovered that it doesn't make any noise at all when put in 4x4.
Ford F-150 (2004-2008) :: Roaring Noise Coming From Right Front While Turning - Front Wheel Bearings?
I gotta a roaring noise coming from my right front while turning. Planning on replacing just the wheel bearings tomorrow & not the whole hub assembly(2008 2wd). Is there a thread that lays out the steps and other parts I may need? I've seen alot different stories on the net on how to do it. Everthing from I can press new bearings to I have to do 4x4 hub conversion. Seems to be some confusion.
View 2 RepliesFord F-150 (2004-2008) :: Right Front Wheel Is Always Engaged When In 4x4
Have an 08 f150 crew and love it. I have noticed though that when its in 4x4, it seems as thought the right front wheel is always engaged. Why it's not letting the 4x4 float back and forth from right to left??
View 3 RepliesFord F-150 (2004-2008) :: Loose Front Wheel But Not Lug Nuts?
I was driving my truck and I heard a noise around the front drivers side wheel area, like a loose center cap. I got home and jacked up the wheel and grabbed it, it wiggled side to side and u and down. Would that be wheel bearing or tie rod end or something else
View 11 RepliesFord F-150 (2004-2008) :: Grinding From Front Wheel Area At 20 KPH And Above
I am getting a grinding sound from the left front wheel while driving straight.. The sound stays the same when brakes are applied and does not change when selecting 4wd or 2wd.. I pulled the wheel off and had a look, but saw nothing unusual.. What are the steps to diagnose/repair the issue? 2004 F-150 5.4 4x4
View 6 RepliesFord F-150 (2004-2008) :: Left Front Wheel Bearing Keep Going Bad
What is causing the right front wheel bearing to keep going bad on my 06 f-150 2 wheel drive....
View 1 RepliesFord F-150 (2004-2008) :: Repeated Front Hub Failures - Wheel Bearing Grinding
Repeat Front Hub Failures -- 2WD Try this situation -- Purchased 2006 F-150 XL with 57,000 miles. Truck built on 05/24/2006.
Sept 2011 68,621 miles -- Left front hub failure -- Wheel bearing grinding -- Done by Bell Ford in Phoenix.
2013 -- Left front hub failure -- wheel bearing grinding -- done by independent shop.
Sept 2014 -- Left front hub failure -- wheel bearing grinding -- done by independent shop.
Sept 2016 -- Upper & lower control arms, struts, strut mounts, springs replaced -- Quality part used -- Complete front end alignment -- Brake job front and rear.
Nov 2016 -- New performance exhaust system due to exhaust leaks.
Dec 2016 -- Failed automatic transmission -- Remanufactured FORD transmission installed w/ 36 mo warranty. Sanderson Ford gets an A+
March 16, 2017 151,000 miles -- Left front hub failure -- wheel bearing grinding! Verified by jacking up truck and spinning left front wheel -- GRIND! This is coming from down in the hub. This is a 2 wheel drive truck. Yes, you counted correctly, this will be the 4th replacement on the Left side!
NO Towing! NO Overloading! Wheels are 2006 XLT style Aluminum rims with P235/70R17 Michelin XLT M/S (Defender LTX) tires all around.
It only hauls maybe 200 to 300 pounds of electronic equipment at the max, once in a while. This is driving me crazy! I always use FORD PARTS for the HUB ASSEMBLIES. Really loosing faith, the front right hub is OEM original - NEVER CHANGED!
Ford F-150 (2004-2008) :: Rough Sound Coming From Front Right Wheel When Driving
My 2008 F-150 recently started making a funny noise from what seems like the front right wheel.
The weird thing is that it will only make the noise while accelerating. The second i take my foot off the it stops. Also, the sound stops if i put it into 4WD and does not happen at all in 4WD.
It has nothing to do with turning or breaking. It only makes the sound in 2WD while my foot is on the gas.
The sound is kind of weird. It sounds like something is loose, and it sounds similar to tin vibrating on metal.
At first i thought it may have been heat shielding rubbing on something, I checked under the truck and found nothing loose.
It's weird that it only happen in 2wd yet in the front end.
Someone had mentioned that it may have something to do with the fact that there is no torque on the front wheels in 2wd and when i put it into 4wd it put torque on it, whatever might be loose then becomes tight.
Ford F-150 (2004-2008) :: Mild Roaring Noise Coming From Right Front Wheel
I got an 08 F150 2wd. I noticed lately a mild roaring noise coming from right front wheel, but it only does it when I'm turning left. There is nothing while driving straight or during right hand turns. Only happens during left hand turning.
View 1 RepliesFord F-150 (2004-2008) :: Squeak Coming From Front Left Wheel Area
My wife just bought her first truck, a 2008 F150 about a month ago. We have been driving it around since then and love the truck. The only real problem that I have seemed to encounter on the truck is a squeak coming from the front left wheel area. I can hear it when I cut the steering wheel and when I hit a big bump/pothole in the road. My dad and I have looked into it and he thinks that it is probably the axle joint where it goes into the steering knuckle/spindle. If it is this axle joint, is there a way to service/grease it and go on, or will it just simply need a new axle shaft?
View 1 RepliesFord F-150 (2004-2008) :: 4 Wheel Drive Is Not Working / Front Hubs Won't Lock In
(2004 f150 S.Crew 4x4) I noticed that my 4 wheel drive is not working. The front hubs won't lock in. The transfer case will go into 4 low but the hubs still won't lock in.
Anyway, I have pulled vacuum on both actuators and one of them won't hold. It's obviously bad, but is that why I don't have 4x4? It seems to me like it is not...
When I pull a vacuum on the actuator that does hold, it disengages the hub from the driveshaft allowing free-wheeling. Correct me if I'm wrong, but when the truck is running in 2wd, vacuum must flow to the actuators preventing the hubs from engaging? The actuator on the bad side is locked 'in' so the driveshaft always turns.
According to my train of thought, since the actuator has failed in the 'locked in' position, I should still have 4x4- What am I missing?
Ford F-150 (2004-2008) :: 2006 - Four Wheel Drive Is Not Working
I have a 2006 F150 4x4 5.4L 43000mi. My four wheel drive is not working. I have the dash mounted switch to switch it into 4x4 Hi 4x4 Low. When I put the switch into 4x4 Hi nothing happens. 4x4 does not engage, and the 4x4 Hi light on the dash does not illuminate. I get the same symptom when the switch is placed into 4x4 Low. I have checked all of the 4x4 fuses and they are ok. I checked all of the vacuum lines to the hubs and they appear to be intact. What I should check next? What would cause this?
View 14 RepliesFord F-150 (2004-2008) :: 2006 XLT - Replacing Wheel Hub Assembly?
I've got an 06 XLT 4x4 with the 4.6L. I'm replacing the wheel Hub bearing assembly this evening and got the old one removed. Opened the new on to find no grease! I was shocked considering I just replaced the IWE and they come pre-greased. I plan on adding some grease around the hub gear but wondered if i should some how get grease in on that inner needle bearing? I have to have this put back together in a couple of hours so I can drive to work tomorrow.
View 6 RepliesFord F-150 (2004-2008) :: Humming With Rhythmic Vibration Coming From Driver Side Front Wheel
2008 2wd 4.6L 98K miles F150 for the past few weeks has been humming with a rhythmic vibration which feels like it is coming from driver's side front wheel. It doesn't do it constantly, nor at all speeds. Once I hit about 25mph, you can start to hear a humming. At 35, slight vibration. Between 50-60, heavier vibration. Sometimes at 65+, it subsides quite a bit. Both front rotor assemblies are newer, and I put in a brand new left because I thought it was a bad bearing.
View 5 RepliesFord F-150 (2004-2008) :: 2007 - Creaking Sound Coming From Driver Side Front Wheel Area?
MY '07 SuperCab just started making a strange rhythmic sound as I drive. It is coming from the drivers side front wheel area. It is like a short creaking sound. It stays the same if I am turning the tires. Seems to go away if I put the brakes on hard, but I slow down so much I am not sure. Front CV Joint?
View 1 RepliesFord F-150 (2004-2008) :: 2006 - Steering Wheel Gets Loose For A Split Second When Coming Onto Bridges And Off
I purchased a 2006 Lariat crew cab 4x4 back in early feb... since then, I've been on the Interstates a little more than usual ( traveling back home.. dad had a surgery 3 hours away) . . . anyway, the truck gets kinda loose feeling when coming onto bridges and off of them, almost like the back end is swaying and the tires are leaving the ground in the front.. my steering wheel gets loose for a split sec. When I bought the truck I wrote this off as bad tires.. it had some over inflated BFG stock looking tires and where too small.
now, I have new wheels and new tires one size up on the tire. While the ride is great off any bumps.. the second I hit a bump it gets squirmy... I had a guy look at the shocks, he said the seemed ok.. could it be possible to have the wrong shocks on ?
My 2004 crew 4x4 did not do this.. so I know its not a characteristic of the truck. Tired of feeling like I am driving on ice... which is how I lost my 04. My first guess was the Shocks... I bought a level kit for my 04 and never got to put it on... so, it may work out to replace them while I am at it.
Ford F-150 (2004-2008) :: 2006 - Front Differential Won't Engaging?
2006 F150, SuperCrew with 5.4
I just replaced the firewall actuator valve for the hubs, and went to try out the 4 wheel drive. The hubs engage and lock to the axle shaft, the transfer case engages and locks to the front driveline, but the front differential isn't doing anything. Is there an actuator for the front or did something break inside?
Ford F-150 (2004-2008) :: 2006 - Leaking From The Front Of Rear End
I noticed the rear end of my F-150 starting to leak from the front of the rear end. What will I need to do to fix it and is there a quick way to fix this issue, as two kids unfortunately prevent me from having much time to fix the issue.
View 5 RepliesFord F-150 (2004-2008) :: 2006 - Front Wheels Won't Engage When Select 4H Or 4L
2006 Lariat 4x4 Troubleshooting. My front wheels wont engage when I select 4H or 4L. No dash lights are ever lit.
I read up and understand how the system works and plan to replace the solenoid, transfer case motor and both hub actuators. I swapped out the solenoid and wanted to test that it was functioning properly so I followed the video below:
YouTube........
With the engine running and selector switch at 2WD, I pull the vacuum lines off and can feel vacuum at the supply. I then hook up just the supply line up (to the bottom port) and expect to feel vacuum at the other solenoid port (top port - what I would call the outlet) and cannot feel any vacuum.
This has halted my repair attempts as I am not convinced this is functioning and would pull in the actuators if they were functional. I know it's a small vacuum from a small orifice but I would think I should feel it by hand, no?
The solenoid's electrical connector is plugged in during this as well. I get the same performance with the old solenoid and the new. If I bypass the solenoid I can feel vacuum at the front wheel hubs.
Should I try a third solenoid? Seems unlikely I would have 2 bad ones...No OBDII codes at all. What to try next?