Ford F-150 (2004-2008) :: 4 Wheel Drive Is Not Working / Front Hubs Won't Lock In
(2004 f150 S.Crew 4x4) I noticed that my 4 wheel drive is not working. The front hubs won't lock in. The transfer case will go into 4 low but the hubs still won't lock in.
Anyway, I have pulled vacuum on both actuators and one of them won't hold. It's obviously bad, but is that why I don't have 4x4? It seems to me like it is not...
When I pull a vacuum on the actuator that does hold, it disengages the hub from the driveshaft allowing free-wheeling. Correct me if I'm wrong, but when the truck is running in 2wd, vacuum must flow to the actuators preventing the hubs from engaging? The actuator on the bad side is locked 'in' so the driveshaft always turns.
According to my train of thought, since the actuator has failed in the 'locked in' position, I should still have 4x4- What am I missing?
Ford F-150 (2004-2008) :: Four Wheel Drive Not Engaging
I have read through the folders and many websites on 4x4 problems. My problem has to deal with my four wheel drive not wanting to engage. It has nothing to do with the front end or solenoids. When I put it into 4x4, hi or low it will not send any power to my transfer case motor. It wont even illuminate any lights on the selector switch. I have checked all fuses and replaced any relays that have to do with the 4x4. Where I should go with this?
View 7 RepliesFord F-150 (2004-2008) :: 2005 - Four Wheel Drive Not Engaging
I have a 2005 F-150 with ESOF. When I turn the switch to 4x4 or 4low the lights on the dash will turn on but the front tires will not turn. I checked all the fuses and they were good. I'm not very familiar with this 4x4 system, what the issue is or on how to fix it?
View 3 RepliesFord F-150 (2004-2008) :: Vibration Only In 4 Wheel Drive / Rumbling Sound
I have a 07 f150 and while driving I have a vibration only in 4wheel drive high but not a bad one but when I take my foot off the throttle it gets worse as well as a rumbling sound!! this is only after a 6" lift was installed it seems and I have replaced both front drive shaft u joints thinking that was the problem but didn't solve the problem....
View 2 RepliesFord F-150 (2004-2008) :: Switch 4 Wheel Drive To 4 Low Position - Not Shifting Into 4 High Or Low?
I made a big mistake, I was cleaning out my truck and accidentally switched my 4 wheel drive to the 4 low position. Not knowing this I started the truck and just drove it all day. Then I noticed my mistake and now the truck will not shift into either 4 high or 4 low!
The truck drives just fine, I feel no pull when I turn to the left or right so it seems that it never did any shifting into 4 high or 4 low, so I'm looking for recommendations on maybe how to fix?
Ford F-150 (2004-2008) :: 2006 - Truck Trans Would Not Move Out Of Drive
Long delay bringing new travel trailer home last week. Shift cable not placed properly in retainer during assembly (there is NO way it popped out) and it was resting on exhaust manifold. Evidently towing camper made enough heat to burn through the shielding and truck trans would not move out of drive.
The good news is that I could climb under (getting too old for that stuff!) and put it into gear/park by hand. But of course I didn't know that for the first 4 hours.
Ford F-150 (2004-2008) :: 2006 - Ticking Sound When Drive - Hubs Not Locking
Ok, So, Im 40 miles from home stuck in ice and snow in a hotel.. (my wife works close by- thought it would be safer than driving in the 10 inches of snow we got 3 days in a row) so, I go to pick her up tonight and I engage 4hi.. I hear the click and the light comes on.. but no clunk of the hubs locking.. I drop it in 4 lo.. it shifts in low.. but the hubs are not locking..
I hear a ticking sound as I drive and when I put it in 2wd it goes away. I turn off the truck, turn the wheel hard both ways .. get out and I can physically turn the drive shaft and I hear the ticking in the hubs. If I read correctly when the truck is off these should be locked?
is it possible the vacuum is not releasing? I also get the groaning when I start up of the air diverter.. that im told is operated by vacuum.. so I am guessing I have a vacuum problem??
Saturn :: 2004 - Front Wheel Drive Transmission Fit In Place Of All Wheel Drive?
Do a 2004 Saturn view front wheel drive transmission will fit in place of an all wheel drive...
View 1 RepliesFord F-150 (2004-2008) :: 2006 - No Power To Front Wheel?
my f150 has the push button 4x4 and the light on the dash illuminates but i get no power to the front wheels only a grinding noise if the rear wheels spin.
View 7 RepliesFord F-150 (2004-2008) :: 2006 XLT - Replacing Wheel Hub Assembly?
I've got an 06 XLT 4x4 with the 4.6L. I'm replacing the wheel Hub bearing assembly this evening and got the old one removed. Opened the new on to find no grease! I was shocked considering I just replaced the IWE and they come pre-greased. I plan on adding some grease around the hub gear but wondered if i should some how get grease in on that inner needle bearing? I have to have this put back together in a couple of hours so I can drive to work tomorrow.
View 6 RepliesFord F-150 (2004-2008) :: 2006 - 4wd Module Not Working
I have a 2006 F-150 Supercab King Ranch 4wd. The 4wd is not working. Took it to the dealer and they tell me the 4wd module is not communicating with the PCM. It is my understanding that this problem is rare...like 1 in a million. Ford wants to replace the entire PCM. In the past, I have had electrical problems with this vehicle due to corroded wires.
View 9 RepliesFord F-150 (2004-2008) :: 2006 - 4x4 Quit Working / Won't Engage
I have a 2006 F-150 4x4 and the 4x4 quit working, it gives me a P1867 & P1891 code but my scanner don't tell me possible causes. Where to start looking?
View 3 RepliesFord F-150 (2004-2008) :: 2006 - AC Randomly Stops Working
About a month ago, I was driving 50 mph in my 06 screw on a dirt road. There was an old wood bridge that was not as flush as I was expecting. Jolted the truck pretty good but it kept on trucking. However, a few seconds after the jolt, the power to the AC cut out. All I had to do was turn the AC to "off" then back on and it'd start working fine. Over the last month, the power randomly cuts out, but will go back on after I switch to "off" then back on. It's happened maybe 3 or 4 times since The Big Jolt.
View 6 RepliesFord F-150 (2004-2008) :: 2006 XLT - All 4 Power Windows Stopped Working
2006 XLT F150 Triton 4x4 crew cab. My widows all 4 stopped working I have replace the 30amp breaker in pos#401 and I have replaced. The switch in the drivers door but still nothing.
View 2 RepliesFord F-150 (2004-2008) :: 2006 - Cruise Control Just Quit Working
The cruise on my 06 F-150 just quit working. No light and can't set it .
View 1 RepliesFord F-150 (2004-2008) :: 2006 - Steering Wheel Gets Loose For A Split Second When Coming Onto Bridges And Off
I purchased a 2006 Lariat crew cab 4x4 back in early feb... since then, I've been on the Interstates a little more than usual ( traveling back home.. dad had a surgery 3 hours away) . . . anyway, the truck gets kinda loose feeling when coming onto bridges and off of them, almost like the back end is swaying and the tires are leaving the ground in the front.. my steering wheel gets loose for a split sec. When I bought the truck I wrote this off as bad tires.. it had some over inflated BFG stock looking tires and where too small.
now, I have new wheels and new tires one size up on the tire. While the ride is great off any bumps.. the second I hit a bump it gets squirmy... I had a guy look at the shocks, he said the seemed ok.. could it be possible to have the wrong shocks on ?
My 2004 crew 4x4 did not do this.. so I know its not a characteristic of the truck. Tired of feeling like I am driving on ice... which is how I lost my 04. My first guess was the Shocks... I bought a level kit for my 04 and never got to put it on... so, it may work out to replace them while I am at it.
Ford F-150 (2004-2008) :: 2006 - Driver Side Window Stopped Working
I have a 2006 Ford F-150 with about 43,000 miles .. love it. However, my driver side window stopped working today. For about the past month when you would power up, it would delay and then go up. This happened every so often. Going down was never a problem. Some times window would go up, then drop down an inch or so. Now this morning I went to the store and the window won't go up and it is down all the way. I do not hear grinding, only clicking. All other windows work fine.
View 5 RepliesFord Super Duty (1999-2016) :: 4 Wheel Drive Low Not Working
Checked the EOF vacuum lines and pump but still have a problem. The EOF works and locks the hubs when I switch to 4x4 high, Easy to feel when you turn the wheels but it will not go into low. The light on the dash does not light up the word "low".
View 1 RepliesFord F-150 (2004-2008) :: 2006 - Power Windows And Door Locks Stopped Working?
2006 F150 5.4 2WD extended cab tow package 24k miles
My power windows have stopped working from all locations. I checked and the fuses are good. I can no longer use the exterior keypad to unlock the truck, yet my remote keyring switch will electronically open both driver and passenger doors. Neither driver's nor passenger's interior door switches work.