Ford F-150 - 1997-2003 :: Squeaky Lower Ball Joint
I have a 1997 F150 4x4 4.6 liter 140,000 miles. I want to replace just the lower ball joints but my service manual says you can't, that you have to replace the lower control arms. Is there any way around this?
View 5 RepliesFord F-150 - 1997-2003 :: Ball Joint Replacement / Control Arms Are Not Correct
I'm halfway through replacing the ball joints on my '03 F-150 4WD. When I pressed the new lower ball joint in, it's snap ring groove is ~1/8" above the top of the lower control arm surface. These are Moog 8695T joints. I've taken them in and compared with another new joint at the parts store and they seem to be correct. This implies that the control arms are not correct- they're too thin where the joint presses in. The old joints sat the way they should, with the snap ring flat against the arm. The old joints are definitely different than the 8695T's- they are shorter from the shoulder of the joint to the snap ring groove. I'm guessing that now I'll have to replace the lower control arms, as well.
View 11 RepliesFord F-150 - 1997-2003 :: Front U-Joint On Rear Drive Shaft Has Grease Fitting
I recently bought a 1997 F150 4wd 5sp manual. While changing the fluids, I noticed that the front u joint on the rear drive shaft has a grease fitting. No matter how I rotate that shaft, I cannot access that fitting with my grease gun, even when fitted with a flexible rubber hose.
View 14 RepliesFord Excursion :: Leaking Axle Fluid After Ball Joint Replacement
Did ball joints this weekend and now have little axle fluid leaking out passenger side. was going to change axle fluid when i saw this so continued and when pulled the fill plug i would say 8oz or more came draining out. Did I mess up the seal inside the tube?
View 5 RepliesFord Aerostar :: Roof Leaking - Factory Weld Joint / Sealant?
I'm about 90% sure this is the cause of my nuisance leak on my 93 Aero. Upon inspection, I see tiny cracks (some near 1mm wide, most less) longitudinally down the factory seams (gutters) in the roof. I've had a small leak which manifests itself right above the drivers rear cubby hole (jack within).
Unless I hear otherwise, plan to buy a caulking tube of Butyl rubber sealant from NAPA and run beads the full length of the roof in each corner of those seams. Of course, prepped first for adhesion. I need another 100K out of this Van!
Honda - Odyssey :: 2006 - CV Joint Boots Are Torn / Leaking
The Honda dealer tells me that both of the van's CV joint boots are torn/leaking. Their recommended solution is to replace both front CV axles at a cost of about $500 per axle.
Is replacing the axle the standard repair when the boot is torn, or is the dealer trying to "over-fix" the problem at a greater cost to me? Can't they just replace the boots (at a lower cost, hopefully)?
Astro - Chevrolet :: 1989 - Leaking Red Fluid Drips From U-joint?
My 89 Astro van is leaking red fluid when parked uphill (slightly) that drips from the u-joint closest to the transmission and only from the part that is in the yoke that goes into the transmission. I dropped the drive shaft thinking wrongly that there would be a bad seal where i thought the yoke went into i thought a second piece, but it is all one piece with a collar. When parked in the garage nice and level it did not seem to leak.
View 1 RepliesFord F-150 - 1997-2003 :: Rear Differential Leaking
Any likely culprits? 2002 F150 (with Triton V8 if that makes a difference).
View 4 RepliesFord F-150 - 1997-2003 :: 2000 F350 - Leaking Behind Oil Pan?
I have a small leak (seems to only be leaking while driving and shortly after I stop the truck). I dont know what the part its leaking from is called but its right behind the oil pan (looks similar to the pan but a little larger) It has a small 1/8-1/4 inch hole/nozzle in it that looks like its meant to be there.
So my question is..
Is there supposed to be a rubber stopper in there?
Is this common?
Whats the part called?
This seems to be the only place its leaking from.
Ford F-150 - 1997-2003 :: 2002 - Oil Pan Gasket Leaking?
I brought my 2002 F150 into the shop because of a small oil leak. I thought it was coming from a leak in the gasket of the oil pan which the shop confirmed. I changed the oil and put in the Lucas oil product that can seal leaks in gaskets (sometimes). This didn't work. I continue to have a small oil drip, more annoying than anything. I am not having to add oil continuously.
To change the gasket the shop basically quoted me $1,200 because on this engine size you have to drop the engine etc.
I am looking for alternative solutions, recommendations, etc. I can live with the leak but would prefer to fix.
Ford F-150 - 1997-2003 :: Brake Lines Leaking?
Blew a hole in the 3/16 inch line to the rear on the left frame rail, behind the gas tank. Lost all brake function.
Got the truck home and inspected. The line was rusted bad about 6 ft long from the connection at the rear hose to the axle, up to the rear seat area ( crew cab). From the drivers seat forward, the line looks very good. The line across the rear axle from left to right looks very good. I bought two 50 inch standard lines 3/16 inch. Started at the rear hose connection 6 inches behind the gas tank and ran forward to the rear seat area.
Cut about 32 inches of the other 51 inch line and connected and ran forward to below the front seat area. There is a metric connector at this point. I cut an inch in front of it to eliminate it. NAPA sells a high psi compression fitting ( steel , 10,000#) that you can connect two 3/16 inch lines together. I did that under the drivers foot area. I have done two different 2002 F150s in the last year due to this failure. Something to look into. Not nice to loose brakes in traffic.
If your worried about the steel compression fitting, don't. I have used these on several cars and trucks over the last 15 years. Make sure you get the STEEL high pressure compression fitting. Total line replaced on CREW cab, 51 + 32 inches. Pops right back into the original plastic clamps.... I might mention, that is where the failure was, under the plastic clamp at the rear end of the gas tank area.......... crud must collect on the clamp.
Ford F-150 - 1997-2003 :: Rear Window Leaking?
My rear window is leaking on my '97 f-150. When it rains water gets in on the passenger side only. I know from reading that this is a common problem. I've tightened up the fasteners that hold the window in place, but it still leaks. Could the high mount brake light be the entry point? Is there supposed to be a gasket behind it? Or is any water that may get behind it supposed to be channeled away somehow?
View 14 RepliesLexus RC 2015+ :: Front Camber Ball Joint Is Leaking Greasy Oil
I have 2015 Rc350 F, with 13k miles on it and my right Front Camber Ball Joint is leaking greasy oil. Do I need to replace this or can this be covered under warranty? I have lowered springs on which I don't think has affected the camber ball.
View 4 RepliesFord F-150 - 1997-2003 :: Freon Leaking On The Back Of Compressor
I got a 2001 f150 leaking freon on the back of the compressor, can't afford to fix this summer. When I add freon should I get the freon with oil in to get oil in the system or just add regular can of freon, it took about 6 weeks before I need to add any.
View 7 RepliesFord F-150 - 1997-2003 :: Oil Filter Stand Gasket Is Leaking
My oil filter stand gasket is leaking and I have the gasket and am getting ready to drain coolant/flush/oil change/gasket fix and am just wondering which antifreeze to use. 2000 F150 4.6L 2WD.
View 9 RepliesFord F-150 - 1997-2003 :: 2001 - Radiator Leaking Antifreeze?
Went to start my truck to leave work yesterday and blew the coil on #2. It's happened before and I can fix that. The other weird thing that happened was that the radiator leaked out some antifreeze. Not a lot, but a good 2 foot puddle. The reserve was still full and it leaked from the passenger side at the bottom (below the upper hose). Upper and lower hose show no sign of leakage. I suppose the drain is on the lower end of the passenger side of the radiator and it leaked from there. Would the compression from the engine cause that to happen? Or is it something more, dare I say, like the head gasket blew?
View 7 RepliesFord F-150 - 1997-2003 :: 2001 - Trans Leaking - Where It Is Coming From
I have a 2001 f150 5.4 4x4 with the 4R70W trans. its leaking fluid from somewhere. its not the pan gasket or the seal. it seems to be coming from the top somewhere. the dipstick tube has new o-rings. and the cooler lines have been replaced and are not leaking either. Where else it could be coming from. the passenger side of the bell housing is wet with fluid.
View 11 RepliesFord F-150 - 1997-2003 :: Water Leaking Through Top Of Rear Window
I have unfortunately discovered that rain is coming through the rear window of my truck. If it was a big job to fix it. The caulking appears to be rotten and I'm wondering if some goop will seal it up. I'm just not sure how to get the trim off!!
View 14 RepliesFord F-150 - 1997-2003 :: 2002 - Losing Oil But No Signs Of Leaking
I have a 2002 f150 5.4 4x4 with 151,000 miles. I am using a lot of oil but its not leaking out. What should I do to fix problem.
View 4 Replies