Ford F-150 - 1997-2003 :: 2002 - Trans Cooling Lines To Radiator Leaking?
2002 4.6 SC with towing package... Transmission cooling lines to radiator leaking. Replacing them? How long does it take, can it be done while working on the ground? Any tricks or problems to look out for?
View 3 RepliesFord F-150 - 1997-2003 :: 4R70W Trans Fluid Leaking - Puddle Of Fluid Under The Truck
I have a 1997 Ford F-150 XLT 4x4 with the 4.6W and a 4R70W trans. For the past year is has been leaking trans fluid and has slowly got worse and worse. At first the truck would only leak at high speeds (when driving on the interstate for extended periods of time) and now It has gotten to the point where I am adding close to a quart of fluid a week. ( roughly about a quart every 300 miles!). I thought that it was the pan gasket leaking at first, so I flushed the trans fluid (dropped the pan and drained the TC and put on a new filter) put a new gasket on and torqued it all down and added some new Valvoline max life fluid. The first trip in the truck I noticed a puddle of fluid under the truck again.
The pan looked like it could have been a little warped, so I ordered a new pan and a new FoMoCo gasket (the one the came with the new filter was the cheap felt type). I thought I for sure had fixed the truck this time, but I drove it and once again it was still leaking. I checked all that I could before replacing the pan and gasket. I checked the trans cooler lines and fittings (no leaks) I pulled the inspection plug and it was dry (so I ruled out the front pump or TC leaking). The whole underside of the truck is covered with fluid so it is hard to pin point the leak, but most of the fluid drips down on the transmission cross member.
Ford F-150 - 1997-2003 :: 2001 - Radiator Leaking Antifreeze?
Went to start my truck to leave work yesterday and blew the coil on #2. It's happened before and I can fix that. The other weird thing that happened was that the radiator leaked out some antifreeze. Not a lot, but a good 2 foot puddle. The reserve was still full and it leaked from the passenger side at the bottom (below the upper hose). Upper and lower hose show no sign of leakage. I suppose the drain is on the lower end of the passenger side of the radiator and it leaked from there. Would the compression from the engine cause that to happen? Or is it something more, dare I say, like the head gasket blew?
View 7 RepliesFord F-150 - 1997-2003 :: 2001 - Coolant Started Leaking
I have a 2001 F150 5.4 triton. It recently started leaking coolant so i stopped driving it until i could get it to the shop. The day i took it to the shop, i stopped 3 times and checked the coolant level and i kept it full while driving it to the shop. The mechanic that was fixing it kept putting it off and had an excuse every day why the truck wasn't ready yet. It stayed in the shop almost a month for him to put a new intake on the truck. The truck ran fine on the way to the shop. I finally got tired of excuses and delays so i went to the shop and asked him if it was ready. He told me now the motor is rurnt and water is getting in the oil.
I checked the oil before and after i got there and the oil had no water in it. He cranked it up and the motor had a loud rattle in it. He wants to rebuild it. I want everybody's honest opinion about this deal. Do yall think the motor just burnt up or do y'all think he could of screwed the engine up on purpose to make more money because i always pay on time? Like i said, the truck had 200,000 miles on the motor but i never once had a lick of engine probs. I just think he could have accidentally or purposefully messed the engine up.
Ford F-150 - 1997-2003 :: 1999 - Antifreeze Leaking On Passenger Side Coming Down The Firewall Outside?
99 f150 4.6 4x4 ... auto.. so, driving on the interstate I had to accelerate hard to avoid hitting a crazy driver... after that I smell antifreeze... get home can't find a leak.. wait a bit and I see antifreeze leaking passengers side coming down the firewall outside... if you are laying behind the passengers front tire with your feet to the back tire.. looking up you see the catalytic converter.. behind that on the firewall a stream of antifreeze... follow the stream up and there is a piece of plastic just about were the firewall starts to go straight up from the floorboard bend.. putting my hands in that it goes inside..and its wet inside..
I can't tell what that's for really but. Am I guessing evap coils access? any rate. I don't feel any dampness inside yet.. but I do smell it in the cab stronger now. I haven't ripped up the carpet either. Im suspecting my heater core sprung a leak?? there is a good amount of fluid coming out and down the firewall outside I would say I have about a 6-foot puddle now. course I parked on a hill too. no fluid that I can tell is at all leaking off the heater core hoses.. they felt dry. Im guessing there is a drain port in that black box inside and that is where this is coming out?? no noticeable leak from the motor side.. it's all dry.. its actually going down the firewall and hitting a metal plate that carries out to a cross member on the transmission and then leaking down.. motor area is dry.
Ford F-150 - 1997-2003 :: 2001 - Antifreeze Leaking Around The Crank Shaft?
I looked under my truck and noticed a Antifreeze Leak I looked under the truck and noticed the antifreeze leaking around the crank shaft. I have never seen a leak from that area. I haven't pulled anything just want a good direction before I start pulling parts off.
I looked up top didn't see any hoses leaking. looked all around the block. the only place I can see it coming from is behind the crank shaft pulley somewhere.
2001 F150 XLT 4X4 ....
Ford F-150 - 1997-2003 :: 2001 - Factory Sliding Rear Window Leaking
2001 F150 Supercrew Lariat, the back window is the factory sliding window, it is leaking around the top on the drivers side, leaks bad. Question is how easy is it to remove the window and replace the seal?
View 10 RepliesFord Excursion :: Smoke Started Coming Out From Under The Hood - Trans Fluid Leaking
I have a 2000 2wd with the 5.4 in it. I tow a travel trailer and loaded is 6500lbs. Today leaving the campground I had to climb an extremely steep hill as soon as you left the campground. No time to build speed. The old Ex made it, but I was definitely worried. The truck ran fine the rest of the 2 hours home. I went to back my camper into its spot to store, and smoke started coming out from under the hood. When I crawled under it, tranny fluid was leaking on the ground. A pretty steady drip. I let it cool down, added fluid and drove around. Didn't leak anymore. Did the tranny just get hot and had to burp? The drip was coming from where the tranny connects to the motor.
View 8 RepliesFord Excursion :: Trans Fluid Leaking Out Of Bell Housing Onto Y-Pipe / Smoke Coming From Under The Hood
A little background info...up until about 6 months ago my 01 Ex V10 was a grocery getter for the wife; only got a few thousand miles a year for the most part. Since we moved from Washington state to Texas it has turned into my daily driver (after a 2500 mile drive towing 8k trailer).
A couple of weeks ago we were running errands and after we got home there was smoke coming from under the hood, but I couldn't pin point it. I let it be because I figure it would let me know when something was really wrong. A few days later it did it again but this time I found the problem; transmission fluid was leaking out of the bell housing onto the y-pipe. I did my research and come to find out it is most likely the front pump seal that got soft from overheating. So my buddy and I drop the transmission and replace the seal. Put it all back together and everything seems great.
Another week goes by and we have driven the Ex fairly extensively around town and even took a couple short day trips and everything is great. Then as we are turning onto an on ramp to get on the highway I give it gas to speed up and all of a sudden the RPMs climb like it dropped into neutral. I had enough momentum that I got over onto the shoulder and started to check thing under the hood. Looked like I was low on trans fluid; ok so I added a quart. Put it in "D" and still nothing. Then I try "1", "2", "R" and they all work fine.
Ford F-150 - 1997-2003 :: 2001 - Occasional Knocking Noise Coming From Engine
I have a 2001 F150 4x4 4.6L Auto trans. 96,000 miles... I purchased it in Jan with 93,000. About a month ago it started making and occasional knocking noise coming from the engine, this noise was heard at idle in park and in drive. when I revved the motor it would go away but as the idle settle back down you could hear it again. the noise would go away as I was driving and come back with no rhyme or reason, I put a stethoscope on the engine and it seemed loudest under the oil pan. The oil gauge is up between 5/8 to 3/4. Fast forward to now, When I start it I hear a scraping almost grinding noise that resonated thru the cab it has the same intermittent characteristics. I think I am going to remove the serp belt, remove the trans inspection cover next and see what happens. Oh I did put a scan too on it, no codes but did notice 1 long term 02 sensor trim was staying around -.618 if I remember.
View 11 RepliesFord F-150 - 1997-2003 :: 2001 - Whistling Noise Coming From The Front Axle
2001 F150 SCAB with 74,000 miles. There seems to be a whistling noise coming from the front axle. It is definately a rolling noise. I can shift into neutral and put it in 4H and still have the noise. Brakes are good, tires are fair... I just rotated my tires (criss-crossed front to back) also sprayed all of my boots with silicone spray. Still has a whistling metal to metal bearing sound. When I have the front jacked up and spin the wheels, there seems to be a decent drag turning by hand. I don't remember having much of a drag before.
View 6 RepliesFord F-150 - 1997-2003 :: 2001 V8 - Creaking Sound Coming From Front End While Turning
2001 F 150 5.4 V8 4WD. I have a weird creaking sound coming from the front end, sounds like the passenger side, whenever I turn right at any speed. What it is?
View 6 RepliesFord F-150 - 1997-2003 :: 2001 4x4 - Humming Type Groaning Noise Coming From Up Front
2001 f150 xl with 151800 miles 5.4l had it for a few years now I get a humming type groaning coming from up front. only when in 4x4 and only at lets say 25 mph to 45 mph .seems to be worse when slowing down especially the slower you get then around 20 or 25 its gone. it is still quite noticeable on acceleration and after 45 its gone. Truck has always been a little noise while in 4x4 weather it was an issue that had already started or if that's how it is. This is my first 4x4 truck.
View 5 RepliesFord F-150 - 1997-2003 :: 2001 - Running Rough When Cold / Stalling Out When Coming To A Stop Light
2 questions regarding our 2001 F150 Supercrew. My 2 questions are:
My 2001 Ford F150 Supercrew (5.4L, 230,000 miles)has the check engine light on with the code reader telling me that it is the P0174. The truck would run rough when cold (usually in the mornings) and sometimes it would get close to stalling out when coming to a stop light. So we would quickly put it in park and give it some gas to rev it up a bit. After the truck gets warmed up, it runs great with no hint of the rough idle. Since this all started I have changed out the PCV valve and replaced the PCV hose (including the elbow). I have also replaced the Idle Air Control unit but that didn't really make a difference.
We then experienced a cylinder #4 misfire which we resolved by changing out the cop with a new Motorcraft unit. The misfire went away but we still had the problem of running rough at idle to the point of stalling out at stops when the engine is cold. A few weeks ago we cleaned the MAF sensor and that seemed to work. The truck doesn't run as rough now (when cold) at stop-lights, but occasionally it will still have the loping idle. We cleared the check engine code and it stayed off for about a week before returning.
I don't know what else to check other than trying to see if there is some type of vacuum leak, but I don't have access to a smoke machine nor would I know how or where to hook one up. Removing and cleaning the throttle body would work? What could be causing the trouble, or what I should do to further isolate or troubleshoot the problem? I saw a you-tube video on the F150 intake manifold gasket possibly being the problem and although I hope that isn't the trouble with my truck, if it is then I will have to deal with it. We need the truck to get to work and the car is now due for a registration renewal, but we can't get a California smog certificate with the check engine light on.
Ford F-150 - 1997-2003 :: 2001 - Strange Rubbing And Whumping Noises Coming From Underneath The Truck
I have strange rubbing and whumping noises coming from underneath my truck. Yesterday I changed the old e-brake and lines, thought it my be rubbing on the wheel. Today I changed the front and rear axle u-joint and rear pinion seal. The front u-joint was ceased and the pinion seal was leaking. I thought this would cure it but the noise is still there , the noise is more pronounced when I make a turn. Besides that the truck runs perfect. This summer I changed all 4 rotors, calipers and pads and ball joints , shocks and muffler. Tomorrow I will jack the front up and check the front, where the noise would coming from.
2001 F150 4X4 7700 ....
Ford F-150 - 1997-2003 :: 2001 Truck Will Not Start And Clicking Noise Coming From A Relay In Cabin Fuse Box
I am having trouble with my 2001 F-150. Starting yesterday it would not start. At 1st i thought it wa the battery, so i took it off, charged it, put it back in the truck and still no start. There is a clicking noise coming from a relay in the cabin fuse box, disconnected the battery, removed relay to inspect and everything looks good. After plugging it back in, and connecting the battery, the truck still wont start and there is a clicking sound coming from the dash near the radio. Rhis is my work vehicle!!!
View 3 RepliesFord F-150 - 1997-2003 :: 2001 - Fog Horn Sound Coming Form Left Side At Idle After 4.6L Warmed Up?
My '01 F-150 2WD, XLT has a foghorn sound coming from the left front side at idle after the 4.6L is warmed up. It goes away with an increase in engine RPM and is unnoticeable at hwy speeds. I have no codes (I have checked w/ my code reader). The service desk guy at the stealer said it is my abs pump going bad (I figured it was a pump of some sort, my 55 packard PS makes the same noise when almost empty-the system leaks). It also appears this is a stealer only part, and going to cost 6 or 7 benjamins to buy and probably another 5 benjamins too fix.
View 4 RepliesFord F-150 - 1997-2003 :: Possible To Put 351 Or 302 With 5.4 E40d Trans?
is it possible to put a 351 or a 302 in a 97 f150 with the 5.4 e40d trans is so what all would have to be done in order for everything to work rite??
View 9 RepliesFord Ranger / B-Series :: 2001 - Trans Judder When Coming To A Stop Moving At Around 3 - 4 MPH
2001 4.0 4x4 auto trans... Problem, tranny judders when coming to a stop moving at around 3-4mph. Engine drops to around 500rpm and maybe one second later returns to normal as the tranny seems to disengage. No judder or shifting problem when accelerating.
View 5 Replies