Ford F-150 - 1997-2003 :: Cooling System Leak On Heater Line
Got F-150 4.6 cooling system leak on the heater line (farthest back line) coming out of the block. Fitting looks to be steel. How does it attach/ do I need to remove the Intake to replace?
View 5 RepliesFord Excursion :: 2000 V10 - Overheating / Gasket Leak Into Cooling System
I borrowed a friends 2000 Excursion with the Triton V10, along with his 3300lb, 28' trailer to tow a car from Ashland, OR to Reno, NV to begin a restoration project. His Excursion has 175,000 miles on it and made the trip down flawlessly, but as they say, "No good deed goes unpunished." When attempting to return last Sunday, had to turn around due to overheating problems. Analysis at a local automotive shop concluded a bad radiator cap. Attempted the return trip Tuesday and the same thing happened (only got farther due to the new cap and ability to hold pressure longer).
Finally got into a Ford dealer and have been informed that the truck has a bad head gasket causing pressure to leak into the cooling system. They suggest replacement of with a remanufactureded engine as opposed to replacing head gaskets, due to the time on the entire engine (who knows what else might be bad?). The vehicle can be driven around town for miles with no problems. But put that heavy load on it and grades and it spews out nearly "all" of the coolant.
Prius (Gen 3) :: Temperature Indicators And Cooling System Overheating
This video is about the Toyota Prius Gen 3 Temperature Indicators and cooling system overheating. I thought the prius did not have temperature indicators but found out it did, so this video is about how to know if your toyota prius is overheating and understand the basics of its cooling system.
View 2 RepliesIsuzu - Trooper :: 1998 - Overheating - Air In The Cooling System
I have a 1998 isuzu trooper. it is over heating and there is air being put into the cooling system. there is a lost of fluid but only the same amount each each time and i dnt knw where too. i replaced water pump had radiator serviced and it flowing at the right flow for truck. it still over heated. i tried chemical called blue devil it worked for two days then failed it is freezing cold here and no garage but do have all tools.
View 9 RepliesGolf IV / Jetta IV :: 2000 VR - Overheating After Bleeding The Cooling System
Alrighty. I have replaced everything dealing with my coolant. New water pump, mishi radiator, pusher fans, thermal switch, temp sensor, t stat, t stat housing coolant pipes, also new gasket and o rings. All new coolant pentofrost sf. Today I went to bleed the cooling system and waited til it did not suck any more coolant down, and we're no signs of air bubbles. Today when I drove it a to Walmart it began to over eat quickly. I pulled over and looked ubder the hood. Coolant was dripping out of my 19-21 pounds moroso cap. And my coolant hoses were rock hard.
Although my top radiator hose was very hot and my bottom was not, but closer to the motor it was. Like if there was a blockage but there isn't in the hose that goes to the block on the bottom of my radiator. Even with the air flow and my fans manually turned on when I first started the car it was steal overheating. On my vehicle there is not a reservoir it has been deleted. I have just my hoses and my radiator that's it. I don't know what can be causing this to happen. Also I ran an air pressure test and my head gasket is not leaking. Any clue what could be going on????
Civic - Honda :: 2005 - Replaced Entire Cooling System Still Overheating
I have a 2005 honda civic. About a month ago it started overheating. Drives Ok on the highway but heats up to the H mark almost as soon as I get off the highway. Have replaced the water pump, thermostat, radiator, flushed the system, most hoses, fan, 2 sensors, timing belt, spark plugs and had the head gasket checked 3 times by 2 different shops. Both said it was fine. The mechanic that has done most of the work is baffled. Says he has never seen anything like this and is at a loss as to what to do next. I am supposed to drive this car halfway across the country in a week to meet my husband who is in the air force. Should I just sell this piece of junk!?
View 10 RepliesTransmissions - Silhouette :: 2003 - Coolant System Stop Leak Clogged Cooling System Of Transmission?
Is it possible to use so much coolant system stop leak that you could clog the transmission cooling system?The fluid is burned and seems like I am having problems with gear shifting and power from the transmission. 2003 Olds Silhouette...
View 1 RepliesPassat (B5) :: 1997 - Air Trap In Cooling System
I have a 1997 no turbo Passat 2.0 6 cyl.Over the weekend one of the plastic pipes for the coolant system cracked and after the replacement I end up with the panel telling me that there is no coolant on the reservoir. How to bleed the air out of the system or if there is any bleeding valve for this purpose? And where is located?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: How To Burp The Cooling System
I just installed a new water pump and thermostat on my truck, and now hardly any heat? I let the truck run for almost an hour without the radiator cap on. And I added coolant back up to the full level. I took it for an almost 100 mile ride and the temp level hardly even moved off of cold? And it is hardley even blowing warm air with the heater on hi.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Coolant Flow - No Pressure In Cooling System By Squeezing Upper Hose
Well I was fueling the truck today and I opened to hood to check it out and noticed that there was no pressure in the cooling system by squeezing the upper hose. I did have a spare degas bottle cap and removed the old one slowly and replaced. I have been driving over 30 minutes and it is close to 100 degrees.
I then drove on down the road, the truck is not getting hot. I stopped to look at some running boards and the truck was running and then I came home and still no pressure, the truck is still running, I removed the cap and no pressure, I then removed the small hose going to the top of the degas tank and no coolant came out. I turned the truck off and disconnected the upper hose and some coolant did come out.
Is this normal? The truck runs just fine, just has me worried. I just bought the truck and the previous owner recently replaced the water pump, T-stat, hoses, etc. All parts were bought at O'Reilly. So everything looks good.
Ford F-150 - 1997-2003 :: Heater Core Replaced - Air In Cooling Lines
I have a '03 f 150 screw 4x4 with 5.4. I had to replace the heater core in the truck and I could hear air going through before the replacement. Now I can still hear it, have tried to burp the system a few times, even jacked up drivers side front on an incline to get reservoir higher. Ended up replacing the hose with the flow restrictor and that worked or so it seemed. The noise is back and I am lost on what to do next. I tested the head gasket and that came back negative also. What to do next or possibly what the issue is?
View 13 RepliesFord F-150 - 1997-2003 :: 2002 - Trans Cooling Lines To Radiator Leaking?
2002 4.6 SC with towing package... Transmission cooling lines to radiator leaking. Replacing them? How long does it take, can it be done while working on the ground? Any tricks or problems to look out for?
View 3 RepliesFord F-150 - 1997-2003 :: 2002 - Code P1289 Since The Temperature Started Cooling Off
I just started recently getting this code on my '02 F150 with the 5.4. It only started doing this since the temperature started cooling off. The light, next to the oil pressure gauge comes on only at initial start up. Once the motor warms up, it goes off. I'm due for an oil change, which I'm getting today.
View 4 RepliesFord F-150 - 1997-2003 :: 2001 - A/C Overheating Within Minutes?
'01 F150 XLT 5.4L EFI 207,000 miles
I've had this truck since '03 @ 45,000 mi and have loved it ever since. It hasn't failed me yet, until now. Living in TX with no A/C is the pits,
He first replaced the large hose assembly (with a non Motorcraft part) due to a pinhole then recharged the system. It cooled great until the pressure pop off valve (or whatever it's called) blew all the freon out.
His first suspicion was the fan clutch, which was replaced with a motorcraft fan clutch. Next he used his a/c machine to evacuate/flush/recharge the system - problem persisted. Lastly, he cleaned the radiator and condenser fins and recharged again. The system still overheated and lost the freon.
While the freon is in the system it cools like never before but after driving it, parking for a while, then re-starting it overheats within minutes.
Ford F-150 - 1997-2003 :: V6 Slowly Overheating In Hot Weather
I have an 1997 F150/4.2 V6/220,000 miles/4x2. During hot weather (over 90F) the engine slowly overheats. While driving on the interstate (from Indy to Fort Wayne), the coolant temperature shows normal on the gauge. Slowly the temperature gauge creeps up to close to the red area. I am running the A/C.
When I switch the heater on and the heater fan at max, the temperature gauge drops pretty quickly to a normal range. I switch off the heater and the A/C back on, then it takes 30 minutes for the temperature gauge to start rising again.
When I open the hood when the gauge shows close to the red area, the upper coolant hose has a lot of pressure (can not squeeze it), which would mean that the thermostat is open and the water pump is working. Also the fan is running fast.
The coolant was changed out a few weeks ago and the coolant level is at normal level when the engine is cold. At lower ambient temperatures, there is no overheating. I am puzzled what the problem can be. I am thinking of a restricted coolant flow.
Ford F-150 - 1997-2003 :: V8 Started Overheating - Oil In Coolant
I have a 2003 F150 4.6l triton v8.... I started over heating yesterday. Got home, let it cool down and found Oil in Coolant. No coolant in oil or transmission fluid. What could be wrong?
View 2 RepliesFord F-150 - 1997-2003 :: Overheating At Highway Speeds
1999 F150, 6 cyl. 4.2L, 233,000 miles. My temp gauge went way high on the interstate so I assumed I had a bad thermostat. replaced it with a genuine Ford themostat, added coolant and here's where I'm at.
1. Let it idle up to operating temp. When it was warm, the heater was blowing cold air.
2. Thermostat opened up, top radiator hose was hot and full of coolant, still no heat in cab.
3. Took it for a ride on the hwy. Heat started to work in cab, temp gauge went way up. I slowed down and went home down a side road. Temp gauge went back to normal and stayed there. Only driving about 30 mph.
I don't get why I'm overheating at 60mph. My best guess is I have some sort of obstruction in the cooling system.
Ford F-150 - 1997-2003 :: V8 Started Overheating - Oil In Coolant
I have a 2003 F150 4.6 Triton V8.... My truck started over heating again after replacing the Thermostat and Water Pump later this summer.... Well I checked Coolant and I have Oil in the Coolant. I see Nothing wrong with the Tranny Fluid and see nothing wrong with the Oil.... What could be the problem??????
View 4 RepliesFord F-150 - 1997-2003 :: Transmission Slip At 62K Miles?
Tranny just started slipping a couple of weeks ago, only occasionally. Seems to be between 2nd and 3rd. any chance a fluid change will work? I don't have have the money right now for a new or rebuilt and I am far from mechanically inclined to do the work myself. 2000 F150 62K org Miles....
View 1 Replies