Ford F-150 - 1997-2003 :: 2002 XLT - Flowmaster 40 Drone At Highway Speeds?
2002 5.4L XLT. Just want to upgrade the exhaust on a budget to get better mpg. Pretty settled on a Flowmaster 40 swapped in, no fancy pipes or tips or anything. Just wanted to know how the interior drone was at highway speeds (75-80). I drive 15-20 min of highway to/from work give or take if I get off and take back roads home.
View 6 RepliesDakota :: 2000 4.7L V8 Overheating In Idle / On Highway At High Speeds And While Driving Slow
I drive a 2000 Dodge Dakota Sport w/ 4.7L V8 engine. I have been dealing with an overheating problem for about 6 months now and have nearly exhausted all hope of correcting the issue. It has been in the shop on 4 separate occasions and seen 2 different mechanics. The radiator has been replaced, the thermostat and thermostat housing have been replaced, the radiator fan works properly, hoses have been replaced and no subsequent leak has been found by either mechanic, they haven't mentioned the possibility of a blown Head Gasket (nor has the typical "milky residue," shown up in my oil cap). Each time I got it back from the shop the problem was fixed for about two weeks, then returned and slowly got worse.
It overheats in idle (with the fan running), on the highway at high speeds, and while driving slow. Sometimes it only gets about 3/4th to the red (usually when its cool at night) and sometimes it will hover just below the red; while I'm doing everything I can to keep it from hitting red (defrost on, revving engine). Some days it takes a little while to get hot and some days it happens very quickly. I'm tired of sinking money into the vehicle but as a recent grad I don't have the money for a new truck at this point. Suggestions included heater core clogged, water pump gone bad, fan clutch.
Civic - Honda :: 1997 - Overheating When Driven At High Speed On Highway
My '97 Honda Civic overheats when driven at high speed on the highway for more than an hour. I've changed the thermostat and the radiator fan, but it still does it.
View 15 RepliesCavalier :: 1997 / 2.2 Overheating While Driving After 30 Minutes Or So At City Speeds
I am having overheating problems with my car, I had the car in the shop where they replaced the headgasket, got the head machined, got the radiator rodded out, checked the water pump, replaced the thermostat tried three different ones. The only way they could get it to run without overheating after doing all of this was to run it without a thermostat. I ran it that way for a couple of months, but it is getting colder where I live so I put a new thermostat back in it, now I am having the same problems, it runs somewhat OK while driving, it does not heat up right away maybe after 30 mins or so at city speeds, however at lower speeds it starts to heat up. If i put it in neutral and increase the RPM's the temp gauge will drop down.
After stopping I can feel the hose coming out of the thermostat housing to the radiator and the hose is cool, so for whatever reason the thermostat is not opening, I drilled an 1/8" hole in the thermostat to let any air through that may be in the system. When I refilled the system I opened the bleeder screw that is above the exhaust manifold until antifreeze came out of it then I closed it and filled the rest of the way.
Ram / SRT10 :: 1997 - Front End Shaking At Highway Speeds
Had upper and lower ball joints replaced a few hundred miles ago and the truck had run just fine. Just replaced the the front bearings, axle seals, left axle shaft (Spicer brand) and right U-joint. Now at highway speeds if I hit just the right bump the front of the truck will start to shake and within a few seconds the shaking is violent, almost have to come to a complete stop for shaking to stop. What is causing this?
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2003 F350 - Rumbling At Highway Speeds
2003 f-350 6.0 4wd dual rear wheels
4 inch superlift suspension lift, dual shock steering Stabilizer
33 inch wheels.
4 inch turbo back exhaust
Other than that it's really bone stock
Here's what's going on. In 2wd, between 55mph and 62ish mph, once I hit a constant speed, a rumble beneath my feet emerges. If I either speed up or slow down, it immediately goes away.
Does the same thing in 4wd high.
I can eliminate front drive shaft and u joints seeing as they shouldn't be turning while in 2wd. I did notice that when I push up or side to side motion in the front drive shaft, there is a click and a bit of motion. Is that normal? Just a side thought.
When i take off there's a bit of vibration from the rear half of the truck, but I've isolated that to the center support bearing. With all this being said, none of these symptoms were around before I lifted it.
Ford Ranger / B-Series :: 2003 - Lean Codes / Jerking At Highway Speeds
I've got a 2003 Ranger 2.3L DOHC, 5 speed, 2WD. It has a check engine light with codes :
P0316-Engine Misfire Detected On Startup
P0704-Clutch Switch Input Circuit Fault
P2195-O2 Sensor Excess Lean Signal Bank 1-Sensor 1
P0171-System Too Lean (Bank 1)
The truck runs fine when coasting or accelerating but when holding a steady light throttle to maintain speed the truck starts bucking and jerking. It's doesn't feel like a misfire, more like a fuel cut out condition. When this happens and you come to a stop, you can smell that the exhaust is very rich coming out of the tailpipe. I've already replaced the upstream O2 sensor and I did a tune up about 15k ago. I'm thinking fuel pump or fuel pressure regulator. I doubt if this is related, but on start up (more so on a cold start up) the A/C compressor clutch kicks in and out 3-5 times and makes a terrible racket.
Ford 6.0L Power Stroke Diesel :: 2003 F350 Shakes At Highway Speeds
Have a 03 f350 with the 6.0 have been experiencing very harsh shaking problems. This only happens at highway speeds 55-60 any other speed is smooth as can be weather it's 25-95 mph. The weird part is that it only shakes when the truck shifts into overdrive and it shakes bad and if you lay into it like you were gonna pass someone it stops then shifts back into overdrive and shakes again.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Clunk / Vibration When Traveling At Highway Speeds
I'm a mechanic but work only on cars so I'm a little shy on diagnosing trucks. I have a 2001 7.3 f250 4x4 short bed, when I give it gas I can hear a clunk, when I let off of the gas I also hear a clunk. Also when traveling at high way speeds I can feel a strong vibration when I very lightly give it gas but the vibration goes away as I give it more gas.
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: Surging Noise While Driving At Highway Speeds
I have a 45 min drive to work every day, all highway. Lately on the way home in the afternoon I have been experiencing a surging noise that seems to just happen while I'm doing hwy speeds. It sounds to me like the fan is tuning on and off. Is that possible? It comes on for a few min. And then off again. I have new icp ipr cps. New oil and filter and fuel filter.
Also I'm still having a battery light on and off issue while I'm driving. Is possible the two issues are connected. I plane on doing extensive search for a bad wire this weekend. Batteries and alternator have checked out and are fairly new.
Honda - Accord :: 1997 Shimmy When Driving At Highway Speeds And Hit The Brakes Hard
When I'm driving at highway speeds and hit the brakes hard-ish (e.g., if the car in front of me stops or if I suddenly realize I'm going too fast on an exit ramp), my 1997 Honda Accord feels like it's shimmying from side to side. It only happens for a moment, but in that moment I feel like I'm on the verge of losing control of the car.
I've only noticed this in the last few months. What this might be? I'm going in for an oil change tomorrow and would like to ask my mechanic to take a look at this, but I'd like to have some theories/guesses in my back pocket before I go in.
Civic - Honda :: 2003 - Significant Overheating Event While On A Highway
I've owned this Civic since new, now at 153K miles. This is a recurring problem that I've been having for over a year. First symptom was there would be no heat coming from the heater at idle with the motor well warmed up. Add some rpm's and the heat returned. The reason was not enough coolant in the system, filled up radiator and all OK. Then it happened again and there is coolant in the overflow tank, but pull the radiator cap and no fluid under cap. Fill radiator and all OK, but it kept happening. I replaced the OEM radiator cap with a new "Slant" brand for an '03 Civic. No better, no worse.
Last week I had a significant overheating event while on a highway. I pulled into a "Dollar Store" parking lot, went into the store and bought 50/50 coolant and shop rags and let the car cool off for 30 min. When I pulled the cap, it was a steamy mess and I let it cool some more. Eventually I put in the coolant and finished up the drive with no more overheating. The overflow coolant container was at the "full" mark all during the overheating event.
At this point I took it to my trusted mechanic. My mechanic determined that the overflow tank was clogged and he blew out the line. So, I hoped all was fixed. But I don't think so. With the car cool this morning I pulled the radiator cap and got a swish noise indicating some pressure release. The level of coolant in the overflow contain hasn't moved. It still seems coolant is not being pulled from the overflow container back in to the radiator when the car cools off. I blew into the radiator top (where the cap goes) and that did produce lots of bubbles in the overflow tank. It seems it is no longer plugged - but why isn't the coolant behaving properly?
Ford Super Duty (1999-2016) :: 2003 F250 - Moaning Noise From Front End At Highway Speeds
I noticed a moaning from the front end a few weeks back and it seems to be slowly getting a little worse. It is only noticeable when I'm accelerating or maintain speed, but as soon as I let off the accelerator and start to decelerate, it goes away. Sometimes, when the truck hasn't been driven for at least a couple hours, I pull away and there is a really noticeable sort of "clunk clunk clunk" but then it goes away and it just moans. I can also hear some noise from the front end at highway speeds, but of course it is hard to hear much else other than engine and road noise from the cab. It's a 2003 F250 with a 7.3 and four wheel drive.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Intermittent Engine Light / Momentary Surge At Highway Speeds
I have a 1999 F350 200,000 miles. Now getting an intermittent engine light. Still runs well, although once or twice I felt a momentary surge at highway speeds. The light is on intermittently about 1/2 time. I read the codes and the following codes, as in the thread title, came up:
P0280 - ICP circuit out of range - low
P0113 - intake air temp sensor circuit - high input
P0470 - Exhaust back pressure sensor circuit malfunction
P0478 - Exhaust pressure control valve - high input
What would make these all code at the same time? Would these not make a noticeable problem driving? And how do I resolve these?
Santa FE SM (2001-06) :: 2003 Jerks At Highway Speeds
We have an '03 Santa Fe (2.4L). We are the original owners.
About 18 months ago, one of our Ignition Coils cracked and caused a misfire when then engine was under load. I replaced the coil, wires, and plugs myself at that time.
Since that time, we have experienced intermittent engine jerking while at highway speeds. There does not seem to be any pattern, and it does not happen every time we drive it.
I took it to the dealer who diagnosed a valve cover leak. They replaced the gasket, one ignition coil, wires and plugs. The problem still happened intermittently after that. I brought it back to the dealer, who diagnosed a valve guide/seat leak. Oil is getting into the cylinder and fouling the plug they say.
I could not afford the fix (and was very dissatisfied by the service I received) so the dealer recommended to change the plugs every 3 - 5K miles to get me through. I was told this on 03/31/09 (125695 miles). I replaced the plugs, wires, and BOTH coils again at that time.
Last week @ 130K miles the engine jerked again. I replaced all four plugs again Sunday morning, but the ones that I pulled were NOT look oil fouled. I showed them to a mechanic friend and the guy at the auto parts store. Both agreed that the spark plugs looked almost new. Sunday evening, while driving on the freeway, the car jerked again!
Since this happened again SO soon after changing the plugs, I really have a hard time believing the valve guide diagnosis. Some possibilities I have seen/heard:
- Crank position sensor or camshaft sensor (This was replaced at 78K miles along with the all of the belts)
- Clogged fuel filter
- Bad O2 sensor
- Vacuum leak from the hose that is between the throttle body and the engine casing
- The dealer's valve seat suggestion
Ford 7.3L Power Stroke (1999-2003) :: Strange Noise Occurs At Both Highway And Surface Street Speeds - Throttle Related
I have a strange noise that occurs at both highway and surface street speeds. On surface streets at low speeds 45 mph and under, if I let off accelerator to coast and lightly step on accelerator I get this quick sharp noise.
Everything I have read regarding a similar noise is under load and being described as a turbo fart. Clearly I am not under any load. I'm lost.
Definitely not a low woooo noise. Also not a hard accel and release and definitely no chuckle and or popping. The sound is high pitched and quick, roughly .5 to 1 second at most. The sound is more like a "zzzrrp" or "zzzoop". I can replicate the sound 50% of the time easily at speeds under 45 mph by briefly coasting (no accelerator) and lightly tapping the accelerator and releasing or holding. Occasionally this sound will occur at full stop when I step off of the brake pedal and before I step on the accelerator. This sound can also occasionally be heard at highway speeds under similar accelerator conditions though it may be more frequent and I just don't notice it.
Would this condition throw a code? Just received "Total Ford Scan Tool Package Enhanced Bundle SP03" scanner from autoengenuity. Hoping to put it through its paces tomorrow.
Additional info: 145k miles. Injectors serviced by a reputable diesel shop here in Vegas approximately 1.5 years ago. Unknown oil leak where oil is collecting in the valley on top of the engine beneath the turbo. HPOP seals were replaced roughly 1 year ago at another reputable diesel shop here in Vegas. Still have an oil leak (turbo related?) Oil is under 500 miles old and acceptable level. Fuel filter is due for a change but that does not seem to affect condition. Air filter 1000 miles. Thinking about upgrading to AIS severe duty kit soon.
Ford 7.3L Power Stroke (1999-2003) :: 2000 - Occasional Miss At Highway Speeds / Bucking And Jerking During Even Gentle Acceleration
165k miles 4x4 6 speed, bone stock unmolested
Slowly progressing problem over 6 months. Occasional miss at highway speeds uphill has progressed to bucking and jerking during even gentle acceleration attempts.
I hadn't got my cam sensor recall done but no change after that procedure completed yesterday. Oil recently changed as well.
I have a torque pro but it never finds any fault codes even though 'service engine' light comes on sporadically. I'm not sure I'm operating it properly but it at least reads rpm when its running.
I'm contemplating the hutch mod but I'd like to have an official diagnosis beforehand if its possible in my case.
Ford F-150 - 1997-2003 :: 2001 - A/C Overheating Within Minutes?
'01 F150 XLT 5.4L EFI 207,000 miles
I've had this truck since '03 @ 45,000 mi and have loved it ever since. It hasn't failed me yet, until now. Living in TX with no A/C is the pits,
He first replaced the large hose assembly (with a non Motorcraft part) due to a pinhole then recharged the system. It cooled great until the pressure pop off valve (or whatever it's called) blew all the freon out.
His first suspicion was the fan clutch, which was replaced with a motorcraft fan clutch. Next he used his a/c machine to evacuate/flush/recharge the system - problem persisted. Lastly, he cleaned the radiator and condenser fins and recharged again. The system still overheated and lost the freon.
While the freon is in the system it cools like never before but after driving it, parking for a while, then re-starting it overheats within minutes.
Ford F-150 - 1997-2003 :: V6 Slowly Overheating In Hot Weather
I have an 1997 F150/4.2 V6/220,000 miles/4x2. During hot weather (over 90F) the engine slowly overheats. While driving on the interstate (from Indy to Fort Wayne), the coolant temperature shows normal on the gauge. Slowly the temperature gauge creeps up to close to the red area. I am running the A/C.
When I switch the heater on and the heater fan at max, the temperature gauge drops pretty quickly to a normal range. I switch off the heater and the A/C back on, then it takes 30 minutes for the temperature gauge to start rising again.
When I open the hood when the gauge shows close to the red area, the upper coolant hose has a lot of pressure (can not squeeze it), which would mean that the thermostat is open and the water pump is working. Also the fan is running fast.
The coolant was changed out a few weeks ago and the coolant level is at normal level when the engine is cold. At lower ambient temperatures, there is no overheating. I am puzzled what the problem can be. I am thinking of a restricted coolant flow.