Ford 7.3L Power Stroke (1999-2003) :: Slight Miss At Idle - White And Blue Smoke From The Exhaust
Early 99 7.3. Runs ok has a slight miss at idle however every injector when unhooked makes a change. Has white and blue smoke From the exhaust. Has enough blow by to blow the oil cap off as your unscrewing it. My question is, I know engine restore is bad for these trucks but I can't afford to rebuild the engine. If I run the restore and then clean the IRP once the truck dies is this going to mess anything else up. Do you think it will by me a few months to save up for a rebuild
View 9 RepliesFord F-150 - 1997-2003 :: 1999 - Smells Like Oil In Coolant Reservoir
I have a 99 Ford F-150 Lariat. I am smelling oil in my coolant reservoir. I have looked all over the engine and do not see any leaks. I do not see any oil on the ground. The truck does not overheat so I don't know how it is getting in. My engine runs great. What can be causing this problem?
View 2 RepliesFord F-150 - 1997-2003 :: 1998 - Coolant Reservoir Smells Like Gas And Truck Smokes Slightly
I have a 98 f150 2wd 4.6 the truck began showing signs that it needed a head gasket about 2k miles ago, my coolant reservoir smells like gas and the coolant is a rusty brown color the truck smokes slightly and the oil cap has chocolate moose like substance from the oil mixing with water. I dont care to keep the truck to much longer however i need it to last me to the end of year. I purchased some k-seal and new oil/coolant etc but after thinking about it all of that chocolate moose up in the valve covers will still be in my motor after i perform the oil change and coolant flush. How should I go about attempting to clean the motor out ? seafoam scares me because i do not know if my rings are already damaged from driving while needing the head gasket, Or should i just keep doing oil changes until it looks clean?
View 3 RepliesFord F-150 - 1997-2003 :: Bad Miss Under Acceleration Below 2500 RPM
I have a 97 f150 with 4.2 4x4 auto. I have a bad miss under acceleration. if i ease on the gas no problems. stomp it and it chugs and pops back thru airbox til it gets to 2500 rpm then clears up. If I shift it manually and keep rpms up its fine till it gets below 2500. I have replaced spark plugs, plug wires, fuel filter, upper and lower intake gaskets, cleaned injectors, new air filter and cleaned o2 and mas sensors. Had vacuum system checked and was told all good.
View 12 RepliesFord F-150 - 1997-2003 :: 2000 - Transmission Miss Between 45 - 55 MPH?
My dad has a 2000 F-150 with the 4.6L with 90,000 miles. He just had the transmission rebuilt 5,000 miles ago if that. It seems to miss between 45-55 mph when you have a little hill and give it some gas. Once its shifts out of over drive, it seems to be better. With over drive off, it does not miss as much. I know we put new plugs in it but don't remember how long ago it was. He bought the truck brand new.
View 2 RepliesFord F-150 - 1997-2003 :: 2001 - Miss At Low RPM - Light Throttle
My 01 Super Crew 5.4l is missing at light throttle. Cruise control on flat hwy, no miss, slight incline, starts missing. Put my foot into it and either it stops missing or it covers it up where I don't notice it. No codes set at this point. It's got about 135k on it and for all I know it may have had the original plugs in it so I figured I'd change them. Changed the plugs, still misses. Shortly a code set, something about the EGR sensor (it's got another name but I forget what it is at 1:30am). I found I had broken a hose while changing plugs, fixed it, no more code, still misses.
When I sent my GF up to get the non-existent codes checked the parts guy sold her some Lucas fuel system cleaner. I'm figuring a COP going out but the cleaner pretty much completely fixed the miss, till that tank of gas was gone. Few tanks later and it's back again as bad as ever. I bought some seafoam as I've had good luck with that in the past. It almost completely fixes the miss but I get a rare 'bump'. What do I need to look at next? Can it be the fuel filter? I'd think no because I'd figure it'd be even worse at greater throttle opening. Injector? How do I check them?
Ford F-150 - 1997-2003 :: Rough Idle And A Miss While Driving
I recently inherited a 99 Expedition 5.4 with 90k miles. I'm trying to fix it up so I can sell it. Like the title states, the truck runs rough but there's no check engine light on. I did some research and ended up replacing the PCV elbow and that made it run better for a while but now it's back like it was. It won't die, just a really rough idle and a miss while driving. I imagine it's probably a (or a few) coil pack(s), but I have no way of knowing which one(s) to replace. I would think that would illuminate a CEL though. I'm also having problems with the AC. Upon inspection, I found that the compressor clutch assembly was completely gone from the front of the compressor. I replaced the whole clutch assembly, then voided the system of Freon and refilled it to spec, still no cold air. The compressor clicks on and off like it's low on Freon but it can't be. I'd just sell it as is but in south Louisiana a working AC is a huge selling point!
View 1 RepliesFord F-150 - 1997-2003 :: Exhaust Leak On Passenger Side / Broken Exhaust Manifold Bolts
My wife's 97 f150 4x4 had an exhaust leak on the passenger side. 7 out of the 8 bolts holding the manifold on are snapped off. 4 of them are snapped off 1/8" below the top of the hole on the cylinder head . I am I unable to get a drill in to drill these out. The other 3 I've tried welding a nut on these but they won't budge and I wring the nuts off. If I have to pull the head(something I don't want to do)can I just pull that 1 head or do I have to tear the intake and everything off?
View 1 RepliesFord F-150 - 1997-2003 :: Miss At Idle When Warm Low End Power Slacking
Alright so I have an 03 5.4 with 144000 miles. once it warms up to temperature it has a miss and low end power is low and no fuel mileage gets 12 to 13 if I'm lucky. From idle to 3000 rpm its doggy get it over 3000 rpm it runs great. All new plugs and coil packs. What it could be. When the motor is cold it runs great has most its power.
View 3 RepliesFord F-150 - 1997-2003 :: 2000 - Miss / Hesitate And Bog When Shift Into Drive
My father's 2000 F150 5.4L has developed an issue. But the issue only surfaces in it's last gear. As it shifts into overdrive it begins to miss and hesitate and bog. If you disable overdrive you never feel it.
I'm thinking an exhaust restriction. There are no trouble codes, no check engine light. I notice that the note of his exhaust changes as the vehicle warms up, sounds like it's being smothered. And the flow out of the pipe lessens.
My only issue is whether the EGR is causing it or the converters. Haven't seen them go bright red yet, but this has been going on for a good while.
I wanted to get a few opinions before I tear into it today. I'll do a vacuum test on the EGR valve and rescan the codes but don't wanna drive it and heat up the exhaust when i gotta disassemble it.
Ford F-150 - 1997-2003 :: 1999 V6 - Engine Will Miss In A Pull And Die Sometimes But Start Back
Engine will start and run but will miss in a pull and die sometimes but will start back, we hooked it to a scanner and it said (intake wiring) it wasn't a dealer hook up just a gas station garage, we have already done plugs and wires.
View 2 RepliesFord F-150 - 1997-2003 :: 1998 F250 - Transmission Shudder Or Engine Miss Below 10MPH?
I have a new to me 98 F250LD with the 4.6/4R70W. I have maintained this truck fro my FIL as best as I could get him to spend (neglected). Filter and fluid replace with Mercon VI last year due to 2-3 shift slip.
He gave me the truck after it would not climb a hill, just hit stall speed and would not move up a steep hill, as I understand it. I put Seafoam trans tune in hoping it would free up sticky solenoids or valves in the VB.
I finally got it registered in my name and drove it to work and back today. After about 25 miles highway driving it shudders pretty bad trying to climb a hill at low speed.
It seems to me that at this low speed, torque converter lockup should not even be a possibility. I do not have COP, but rather a single coil pack. I replaced the wires and plugs for Dad a few years ago, but some shady shop later told him that I didn't replace the left rear (to make an upsale I suppose). Not sure what they may have done in there.
I have scanned with my ELM 327 and Droid using Torque Pro, and the only Fault is EGR flow.
Ford F-150 - 1997-2003 :: Slight Miss / Rough Idle - Hesitation Or Stumble On Acceleration
2003 F150 5.4 72852 miles
I have a Rough Idle & sometimes a hesitation or stumble on acceleration. I cleaned the MAF & IAC motor & Air & Fuel Filters are new. I got a 20890 scanner & ran test 6 53 as suggested in many posts by BlueGrass. Here are My results & what They Convert to.
1 00F5 .3675
2 0051 .1215
3 0000
4 0000
5 00A3 .2445
6 0000
7 0000
8 0000
I'm guessing the cop's are ok & probably need plugs? I was hoping to just swap a coil. Too cold to do plugs & truck won't fit in my garage.
Ford 7.3L Power Stroke (1999-2003) :: White Smoke Blowing / Smells Like Fuel And Loses All Power
I am a mechanic and tow operator running a late 99 f350 7.3 6 speed cab and chassis wrecker. This truck has had a hard life and has been neglected for quite some time, and now has become my baby/headache. Truck starts great, idles nice, and will run great for about 5 minutes until it starts billowing white smoke that smells like fuel and loses all power. If you continue to drive it it will die. Sounds like it's dropping cylinders and will barely idle. If you stop for 5 minutes or so and let it idle it will smooth back out and will run great again for another minute or two, then right back to stumbling.
Using torque app, hpop pressure looks good when it's running well. Peaks at 3k, IPR maintaining 30-40% max. As soon as it stumbles you can see the hpop drop to 5-600 and the IPR will climb to 65%. Let it idea bit and they go back to normal, and stay good until it stumbles again.
Ive changed the fuel pump, ICP,rebuilt FPR, change fuel filter, pulled and cleaned the fuel tank (metal tank, no delamination, looks perfect inside). Pickup screen looked good. Cleaned the IPR, cleaned the hpop reservoir, there was no screen inside. Checked voltage at fuel pump, 11.78 across the pump with it running. Pulled valve covers, no noticeable leaks around injectors. Injectors have less than 5k miles. Remans with 100% larger tips.
To me it seems like the lpop is not keeping up with the hpop under load, starving it until you idle and let it catch up. Could it still be bad injector orings? Bad lpop? Something I'm not thinking of?
Ford F-150 - 1997-2003 :: Starts Perfect After A Cold Soak But Then Miss / Sputter And Loss Of Power
1997 F150 4X4 4.6 engine with 285,000 miles
Truck was running perfect down the road, then suddenly it lost power and started missing at all RPM ranges. So i keep driving another 6 miles and then POOF the miss is gone and truck runs perfect. Couple hours later i hop back in it and its running good and then suddenly it starts missing and loosing power again except this time it never started running good again. Never did throw a CEL.
I hooked up my SCT Tuner (for my F250) to check for codes and came up with P0171 which indicated one of the banks was running lean, but no missfire codes. Did a search on here and learned the common problems(vacum leak) of that code.
Found the vacum leak at the PVC elbow, so i replaced both ends of the plastic tube.
Pulled the throttle body elbow and cleaned out the clogged up EGR ports.
Put a new air filter in and took the MAF out and cleaned it with MAF cleaner.
Put it back together and it idled way better but still ran like crap with the bad miss/sputter. Ran it down the road a few miles and came back thinking of the catalytic converter, i crawled underneath and it was glowing red. It does run and feel like the converter is stopped up but if i have a dead miss and dumping fuel wouldnt that make it glow red to or no? Still no CEL and now no codes.
Also i held the engine at about 1000 rpms where i could here the miss good and unplugged the fuel injectors one at a time to see if that made a difference. Each one i unplugged made it miss worse, so wouldnt that tell me that all 8 cylinders are firing?
And i changed the spark plugs (motorcraft) 250 miles ago.
So it still cranks and runs smooth after a cold soak overnight and then after a mile of driving or less it starts the dead miss/sputter and loss of power.
Ford Excursion :: Coolant Puking And Overflow Tank Smells Like Exhaust
I have owned my 2005 v10 ex since 60000 miles. Have had many dependable family road trips and love my truck.
Recently it has started puking coolant and the overflow tank smells like exhaust. The oil cap has some coolant sludge on it. But there is no coolant mixed with the oil. Or oil in the coolant.
I am pretty certain these are the signs of failing head gaskets. The truck has 193000 miles on it now.
Want to keep it on course. But keep it reliable. So do I buy new engine or do I just replace head gaskets?
Ford Aerostar :: 1990 4.0 Liter - Running Rough / Exhaust Smells Like Gas And Has A Misfire
1990 Ford Aerostar. When I start runs really rough and has excessive fuel consumption and the exhaust smells like gas and has a misfire my friend says its the coil pack going bad im not sure. I love my ford aerostar dont wanna get rid of it.
View 5 RepliesFord F-150 - 1997-2003 :: 4x4 - Dash Light Blinking Very Fast
I bought a 1998 F250 5.4 XLT, 4x4, automatic gear shifting, electric 4x4 HI/LO switch. I'm living up on a hill and when I drove back home last time there was snow and I had to use 4x4 all the way up back home. 4x4 worked fine. I parked the truck and switched of 4x4.
But when I started the truck next time and switched in a gear the 4x4 dash light started blinking. But different to many post I read so far the 4x4 dash light is not just blinking 6 times every 2 minutes, it is blinking constantly very fast (double time of flasher) as soon as I switch in a gear, even without moving the car. The dash light is blinking regardingless to the position of the 4x4 switch. I realized that interior lamp is flashing in same rythm as the 4x4 dash light.
When I shift from 2HI to 4HI 4WD does not engage but it sounds like shift motor on transfer case is doing something. When I switch to 4LO 4WD does not engage either but the gear reduction works. I noticed that when I drive downhill and put on brakes the 4x4 dash light stops blinking for short.
What might be the problem?
What I tested so far:
- All fuses (under dash and under hood) are okay
- Relays under the hood (they switch when I connect them to 12V)
- Switched heating mode selector to panel. Air comes out of panel. Then switched on 4x4 and air comes still out of panel. Not switching to window. So vacuum pump system should be okay as well, right?
- disconnected car battery for a while. Reconnected, started engine, put in a gear and 4x4 dash light was NOT blinking any more. But as soon as I drove a few meters it started blinking again.
- When I drive the speed indicator works as well. So shouldn't be the rear speed sensor, right?
What else can I test?
Ford F-150 - 1997-2003 :: 2002 - Overdrive Light Blinking Off And On
My overdrive light is blinking off and on. When I accelerate normally, the truck starts stumbling? (don't know a better word) some, sort of like a clogged air filter or fuel filter. I am going to take it to a transmission shop because its a little beyond me, but don't want to get ripped off.
View 10 Replies