Ford F-150 - 1997-2003 :: 1999 - Charge Light Won't Go Off?
I have a 99 Ford F-150 Lariat 5.4L 4x4. I was driving my son to work and the truck died. My son-in-law gave me a jump and as soon as he removed the jumper cables my truck died. We took the alternator to Auto Zone and had it tested, twice they tested it and it passed. We took the battery to them for a battery test and it was dead. Got a new battery and put it in the truck and the truck starts. The voltage on the battery was 12.4 off and when we turned the truck on the voltage went to 12 so we replaced the voltage regulator on the alternator and now I get 13 volts on battery while it is off and on the voltage goes a little above 15 and the charge light will not go off. What to look for to try and fix this problem. What can cause the light to stay on? I can push down on the belt a little but my son-in-law says the belt is ok, it does have a few cracks in it.
View 11 RepliesFord F-150 - 1997-2003 :: Red Battery Line On - No Charge System
Had a little fender bender. Right after that i noticed the battery red light was on. When I got it home I took the solenoid off the firewall (all the battery wires meet here). When you put 12 volts to the small terminal, the solenoid pulls in and the two big terminals are connected together. That works. When installed on the truck and startup, I have no 12v voltage at the small terminal. Don't have a diagram, but service manual says something about fuse #14 under the dash feeding the "battery cutout".. Checked that fuse and its o.k. .... where does the 12 v signal to the solenoid come from ? I assume somehow it triggers after the alternator starts charging ?
View 12 RepliesFord F-150 - 1997-2003 :: 1999 V6 - Battery Won't Hold Charge
I can charge it off someone else battery and it will start and drive, but by the next morning it's dead again. Truck charges fine while truck runs so I don't think it's the alternator. 1999 4.2L V6 ....
View 3 RepliesFord F-150 - 1997-2003 :: Electrical Charge Coming From Bumper Occasionally
2000 F150 5.4... I was cleaning the battery posts tonight. I was leaning against the bumper when I touched the positive cable and got voltage into my knee. I have had weird electrical problems occasionally.
View 5 RepliesFord F-150 - 1997-2003 :: 1998 - After Head Gasket Replacement Battery Only Charge When Punch It?
I have a quick question, I just replaced the head gaskets on my 4.6 with 301,000 miles on it and now my battery only charges when you punch it and when you lift off the gas pedal, in town it does fine, but on drives 25 miles on the highway the battery guage goes to the line on the bottom. What could be causing that?
View 2 RepliesInfiniti - Qx4 :: 1997 - Battery Not Holding The Charge
I've had the alternator and starter tested twice,new battery. Its a 97infiniti qx4 and it won't hold a charge. The weird thing is, I have to wait day or two after I charge the new battery (which I replaced twice thinking it was the battery),then it will run for almost a day and then it just dies. And if someone tries to give me a jump, it will not charge and fire over. I have to get it towed back home and wait a day or two. (the wrecking companies are getting to know me very well). I've checked under the vehicle for any wires that are not suppose to be touching each other. Its my only car that I have at this time
View 5 RepliesVolvo - 850 :: 1997 - Battery Loses Charge?
I have a 1997 Volvo 850 where the battery slowly loses its charge. We don't drive it much so every two weeks it has to be trickly charged.
I have determined that there is a drain of 150 mA. When removing fuse 15, it drops to a drain of 50-60 mA. When removing fuse 6 (central locking)(in conjunction with 15) it drops to a drain of 10 mA. I can live with a drain of 10 mA
I don't mind removing fuse 15 as it is not critical. However, with the fuse removed, it makes a beeping noise - like the indicator when a door is open. IS THERE A SIMPLE WAY TO STOP THE BEEPING?
I understand that there is an electrical issue but not sure I want to spend a lot of money to fix it. I am not very mechanically inclined and I have a feeling it could cost a lot to fix this.
Ford F-150 - 1997-2003 :: 1997 - Click Sound From Converter After Reinstall Engine?
I have just finished changing head gasket. I started up the engine works fine. But I hear a little clik sound form the converter. I put it in gear, but it can't move either forward or backward. It ran 2-3 liters of oil out of the converter when I took the engine out. I have filled new oil in the gearbox but not in the converter, dosnt it came form the gearbox into the converter?Is there air in the converter or what's wrong?
it is a F150 4x4 4.6 1997 automatic.
Ford F-150 - 1997-2003 :: 2003 - Got Code U1262 - Random Misfire?
I have a 03 F150 with a bi-fuel 5.4 engine an it has 195000 miles. I have had trouble for some time now with misfires. I bought the truck in october of 2011 with 125000 miles and replaced all the coils and spark plugs because it was misfiring badly will running on CNG. It was fine on gasoline and never had any codes. After I replaced the plugs and coils it ran fine on CNG and gasoline.
This summer 2013 it began missing badly at highway speeds only when running on CNG. If I accelerated the miss would go away until I was light on the throttle again.I checked the misfire count and found the bad cylinder and replaced a coil. Then a day later same thing on another cylinder. I swapped a coil from another cylinder and problem went away for a day. Eventually I chased the misfire around all the cylinders on the engine until I had ended up either replacing a spark plug or swapping a coil on all the cylinders. And I still had a misfire. It seemed to be worse on days with temperatures above 90 degrees. Eventually I got it to stop misfiring.
So now 5 months later I am back again with a misfire. This time it is misfiring on both gasoline and CNG and under any throttle conditions, except coasting. I have no codes. And the misfire monitor is sending me around the engine again. I have replaced a spark plug in two cylinders and swapped 4 coils.
I'm ready to buy all new coils, but I want to be sure that it is not a waste of money since the old ones only have 70000 miles on them.
Two days ago I had the misfire monitor saying #4 in the evening and the next day without me having done any work on it it was saying #6. Later that same day it said #7 and I still hadn't done anything other than drive the truck.
I checked the connections at the firewall on the drivers side with the three large plugs that are held in with a 10mm bolt, they looked fine, no corrosion or burnt pins. I checked the connection at the ACFM which also looks good. I will check the connection at the PCM in the next day or so.
Some other problems that may be contributing:
1. I occasionally get a U1262 code (scp fault)
2. Sometimes when I check the misfire monitor it only shows 7 cylinders, sometime 9 cylinders. I am using an Innova 3160 scanner.
3. I have either a leaking valve cover gasket or leaking head gasket, because I have oil dripping from the rear bottom corner of the passenger side cylinder head right above the exhaust pipe.
Ford F-150 - 1997-2003 :: 2003 - Running Sluggish Even Replaced Plugs / Cops And Cleaned MAF Sensor?
I've tried everything I can think of and it still runs sluggish.
1. Had dealer change plugs
2. Changed Cop's
3. Cleaned MAF sensor
The 5.4L has slight miss and doesn't respond well at all when trying to pass or going uphills.
Ford F-150 - 1997-2003 :: 2003 F150 Cranks But Won't Start
This has happened twice in 3 years....I get regular service from a Ford dealer and am overdue.... I think it may be temp related. Has been below freezing the last few nights. Truck was parked on an incline during the last two "shutdowns" ( engine lower than bed slightly), I drifted to a level position and it started. This has only happened twice previously. Now it seems to be a permanent problem but I am unable to get to the dealer without a tow... which I am trying to avoid.
View 2 RepliesFord F-150 - 1997-2003 :: 2003 4x4 - Tranny Doesn't Engage
I have a 03 4x4 5.4lt supcab with 154k miles. I replaced the shift motor about 40,000 ago but it has always been tempormental like I had to engage it in 4lo in N and then shift to 4hi to keep it in 4hi. Now fast forward to today. Went to shift to 4lo in N and it didn't shift. I only heard the relays click once and then it wouldn't shift into any gear even though the indicator was on PRND123. Didn't matter.
Also, Park didn't engage and the speedometer acted like it was engaged in RN and D. No movement what so ever. I think it might be the shift motor that shifted part way and is stuck in between gears. Is this possible? I drove fine to the dirt road and I haven't had problems other then the shift motor being touchy. I don't want to pay for a new tranny if it might be the shift motor.
Ford Expedition :: 2005 - AC Not Working / Low On Charge
I am working on my wife's 2006 Expedition limited with rear air (AC charge of 58 oz). The AC wasn't working so I checked it and it was very low on charge. I figured it was leaking so I added some 134a with dye. In one day it was very low again (like almost no charge). There was dye and oil all over the pump. I figure it is leaking out of a seal on the shaft (I could be wrong about that though, either way the pump is shot).
I remove the pump and got about 1 oz of oil out of it. I also drained the accumulator and got just a few drops out. I have a feeling most of the oil leaked out with the 134 because it was leaking so bad. The new pump came with 150 ml (5 oz) of oil in it. I am now installing it with the oil in it. How much oil should I add/ remove?
Ford - Taurus :: 1998 - Battery Will Not Hold A Charge
My 98' Taurus will not hold a charge. I have replace the battery 3, The alternator was replaced 4 times, and the 175 amp mega fuse was replaced once.I am at wits end cause I don't have a clue what is causing the the battery to discharge over night in the winter and with in 3 days in the sommer. I have rewired the main fuse box under the hood cause the relay to the starter melted the box, I replaced cables to the battery, the alternator, the starter, and the ground to the battery, and the main fuse box under the hood. I have tested the battery to see if it will hold a charge on its own. This test took 3 weeks before it drained. I know it is not the battery. What is going on with this car, Did I miss something?
View 1 RepliesFord :: Huge Jolt Of Shock / Static Charge Getting Out Of Car
I get a huge jolt of shock when I get out of the car and touch the car frame. I live around Detroit where its cold and very dry, so I have to wear warm coat. How I can avoid collecting static while driving and best way to discharge it when I get out.
View 5 RepliesFord Wiring/Electrical :: Battery Won't Take A Full Charge
I have a vehicle I am storing for the winter, but do want to start it up on occasion just to keep it fresh. my question is this. I put a trickle charger on the battery to keep it charged up, its one of those chargers you can leave on indefinitely, once the green light goes on the charger, it goes into maintanance mode. but I've had the charger on for a week now and it seems the battery won't take a full charge. to put the battery charger into maintance mode. is it dangerous to keep charging a battery that won't fully charge up?
View 8 RepliesFord A/C :: System Not Taking Initial Freon Charge
Just got done replacing a compressor, dryer, and orifice tube, flushed all hoses and the evaporator and condenser, blew everything out several times with compressed air, hooked up the vacuum pump and let it run for almost an hour and when I went to put in the new freon, it won't pull it into the system. Low side jumped up to 100psi when I opened the valve to the can and the high side is reading right about 100psi also but the freon is not flowing into the system. Without tearing everything back apart, I thought I would check what could be the problem. I jumped the low pressure switch and the compressor is running.
View 4 RepliesFord - F250 :: 2006 - Replaced Alternator But Cannot Get The Batteries To Keep A Charge
I have a 2006 Ford F250 Superduty 4x4 6.0L Diesel with an alternator/battery problem. We have charged the batteries (had them tested at auto zone), and replaced the alternator and still cannot get the batteries to keep a charge. I'm not talking a slow drain, with the ignition switch on for less than a minute it drains about 4 amps and the truck dies. We also noticed a trouble code "TBC fault" and discovered that was to do with the trailer brakes. Disconnected the trailer brake system (have been noticing a "check trailer" warning occasionally recently). What could be causing such a massive drain on the batteries?
View 3 RepliesFord 6.7L Power Stroke Diesel :: Charge Primary Battery Or Both?
If I had to charge the batteries, Do you charge only the primary battery or do you charge both?
View 4 Replies