Ford F-150 - 1997-2003 :: 1999 V6 - Battery Won't Hold Charge
I can charge it off someone else battery and it will start and drive, but by the next morning it's dead again. Truck charges fine while truck runs so I don't think it's the alternator. 1999 4.2L V6 ....
View 3 RepliesFord F-150 - 1997-2003 :: A/C Won't Take Charge?
I have an 03 F150 that I put a 4bt 3.9 cummins diesel in a couple years back. I'm just now working on ac issues. I have custom lines built and have a new drier in it. I am uncertain of the location of the expansion valve. I have not found a diagram of where that would be. It is a supercrew so it has the large condenser and I don't remember seeing the expansion valve/filter in that line when it was apart.
So I pulled full vacuum on the system and let it set for over an hour and it held the full vacuum. I plugged the Freon to it and it pulled just a small amount into the system. with the vehicle off it registered about 90lbs on both high and low with just the one can attached. I closed high side and jumped the ac pressure switch and it dropped to about 30 lbs on low side, but would move back up to 90lbs when I turned compressor off. It would not pull anymore out of the can. Do I have a plugged filter somewhere?
Ford F-150 - 1997-2003 :: Red Battery Line On - No Charge System
Had a little fender bender. Right after that i noticed the battery red light was on. When I got it home I took the solenoid off the firewall (all the battery wires meet here). When you put 12 volts to the small terminal, the solenoid pulls in and the two big terminals are connected together. That works. When installed on the truck and startup, I have no 12v voltage at the small terminal. Don't have a diagram, but service manual says something about fuse #14 under the dash feeding the "battery cutout".. Checked that fuse and its o.k. .... where does the 12 v signal to the solenoid come from ? I assume somehow it triggers after the alternator starts charging ?
View 12 RepliesFord F-150 - 1997-2003 :: Electrical Charge Coming From Bumper Occasionally
2000 F150 5.4... I was cleaning the battery posts tonight. I was leaning against the bumper when I touched the positive cable and got voltage into my knee. I have had weird electrical problems occasionally.
View 5 RepliesFord F-150 - 1997-2003 :: 1998 - After Head Gasket Replacement Battery Only Charge When Punch It?
I have a quick question, I just replaced the head gaskets on my 4.6 with 301,000 miles on it and now my battery only charges when you punch it and when you lift off the gas pedal, in town it does fine, but on drives 25 miles on the highway the battery guage goes to the line on the bottom. What could be causing that?
View 2 RepliesFord F-150 - 1997-2003 :: 1999 - Low Battery Light On?
1999 F150
automatic, v8 4wd 430K miles Low Battery light is on.
Other than the usual things to check: battery cable connections, corrosion at contact points, checking with a voltmeter, having battery tested, having alternator tested for volts and amps... are there other known issues with this year model/setup?
Also, once the battery is changed, is there a way for the codes to be cleared out or reset without having to hook it up to a computer?
Ford F-150 - 1997-2003 :: 1999 - ABS Light Won't Turn Off?
I have a 1999 ford f150 2wd 4.2l v6 manual 5 speed kk... i recently put back brake pads on it on both sides bc they were original and they were getting kinda worn down after have 184,000 on them. so after i got them replaced i put it all back together and test drove it and every time I'd go to take off my abs light would light up. strange huh? i thought so. so i brought it back home and i remembered i forgot to bleed them after i put them on so i bleed them and everything still didn't work, it kept coming on..
So I checked the FL & FR abs speed sensors cleaned them up and put them back on still didn't work. So I found the rear speed sensor mounted on the differential and took it off it was pretty nasty and had a little bit of metal fragments on it so i bought a new one and I unplugged the batter and stuck it on hooked up the battery test drove it and the light has stayed off ever since!! so if u have put new back brakes on and the light comes on check the rear speed sensor first.. real easy to install just one bolt.
Ford F-150 - 1997-2003 :: 1999 - ABS Light On Dash Has Been Coming On?
I have a 99 F150 4X4 with 4 wheel ABS and 80K miles. My ABS light on the dash has been coming on recently. It will go out for a while, & then come on again later.What is the first step to figure this out? I am a points/carburetor guy trying to figure out these modern machines.
View 14 RepliesFord F-150 - 1997-2003 :: 1999 - White Light At Rear Won't Turn Off?
My buddy just purchased a 1999 F-150. He called me to complain that the white lights on either side of the high mount stoplight (above the rear cab window) won't turn off. Are these a bed light or a reverse light? If they are independent of the reverse lights, how do you turn them off?
View 2 RepliesFord F-150 - 1997-2003 :: 1999 - OD Light Started Flashing While Going Down The Interstate
I got a 99 f150 with a 4R70W and 311,000 miles on it and last year the od light started flashing while I was going down the interstate so I checked the fluid when i got home and it was beyond burnt so i changed fluid and filter. So a month or so ago it started doing this thing where on take off it will rev up like its in neutral for a couple seconds then reengage and drive normal till i stop and start to take off again. It don't do it every time and it drives/pulls just fine other than that.
View 4 RepliesFord F-150 - 1997-2003 :: 1999 - When Engage 4Hi Dash Light Low Range Turns On But Not 4x4
I have a 99 F150 5.4 V8 4x4, My problem is when I engage 4Hi the dash light "low range" turns on but NOT the 4x4 light. Now if I go to 4Low the 4x4 light turns on(Low Range light stays on). So in essence the lights are backwards. In 4Hi it is not engaging 4 wheel drive. Also its a SOTF not electronic selector.
View 2 RepliesFord F-150 - 1997-2003 :: 1999 - 4WD 4.6L - O/D Light On Intermittently - Codes P0781 And P0743?
Ok, so the OD light sometimes blinked and sometimes not. I drive for a week. About 500-600 mi. Today the tranny starts acting up. Up until today NO probs at all. I bought a code scanner. Codes are P0781, and P0743. I also bought new filter and fluid while there. I read here that it could be a shift spring that is easily accessed when doing the filter change. I guess I should get that and do it,and the filter and see what happens next?
View 4 RepliesFord F-150 - 1997-2003 :: 1999 V6 Will Rev Real High When Press The Clutch While Sitting At A Light
I bought this truck for work and all of a sudden it will rev real high when I press the clutch in to switch gears or when sitting at a light. I stopped at a parking lot and popped the hood and tried to pull the throttle back by hand but it will not go. There is a lil slack in the throttle cable but when the truck is off and I manually pull the throttle back it returns normally.
I was wondering if the little black electronic box opposite where the throttle hooks to the throttle body is making it rev so high? I really don't know a lot about these newer trucks as I have driving older trucks my whole life so probably using wrong terms...
Ford F-150 - 1997-2003 :: 1999 - Truck Won't Start / Theft Light Just Started Blinking
I recently changed the heater core on my 99 F-150 which meant i had to remove the dash. I got everything back together turned the key to start it and nothing it wouldn't start it wont even turn over. All the electronics come on like normal it just wont start. I have chased every wire every connection into madness. It has an aftermarket remote start someone said that would have bypassed the PATS but i dont know about that the theft light just started blinking.
View 1 RepliesFord F-150 - 1997-2003 :: 1999 - Service Engine Soon Light On Sometimes At High Rpm Or Rough Erratic Idle
My trucks symptoms include a illuminated service engine soon light, sometimes a high rpm idle, and sometimes a rough erratic idle. When a scan was done it indicated the oxygen sensor was defective. The issue is: which specific one (there are multiple oxygen sensors) or how could I check or determine the faulty one for sure. I am trying to economize and replace only the bad one myself if possible. I own a good multimeter, can it determine the bad one? 1999 F-150 4.2 Litre V6 oxygen sensor dillemna....
View 7 RepliesFord F-150 - 1997-2003 :: 1999 XLT - Crank No Start / Theft Light Flashes A Code Of 1 Then 4 / PCM Not Power Up
I have an intermittent security system issue. I sometimes get a dotted line in odometer and rapidly flashing theft light.
Crank no start. After a time, the theft light flashes a code of 1 then 4. Research gives me the result that PCM did not power up.
Have pulled gauges. Fixed known cold solder joint issue. Checked all connectors and reinstalled. Truck starts fine about 7/10 tries.
I have replaced battery terminals. Removed cleaned and replaced all firewall grounds. Checked harness connection blocks and PCM connector. Made sure all under hood fuses and relays working.
Currently sitting in a parking lot waiting for it to decide to start again. Only one chipped key. Where to look next? 1999 F150 xlt 6 cylinder.
Ford F-150 - 1997-2003 :: 1999 - Check Engine Light Codes P0171 And P0174 Lean On Bank 1 / 2
I have a 99 f150 with the 4.2l v6 with a 5 speed 173000 miles. I picked it up not to long ago. When I first got it it had both the P0171 & P0174 lean on bank 1&2 it was also siting for a while. I replaced the fuel filter which was filled with black fuel, also changed the PCV valve, cleaned the MAF sensor, and changed the oil. I cleared the code, drove it for a little bit and the light came back on after 20 miles.
I then proceeded to replace the upper and lower intake manifold gaskets. Upon doing that i noticed that i was missing one of the linkages for the IMRC. I went to the junkyard and pulled off another linkage rod off the same motor. ordered new plastic clips, put the IMRC on cleaned everything up and began putting it back together. I also cleaned the Injectors while i had them out as well and put in new spark plugs and wires.
Put everything back together. code was cleared since the battery was disconnected. drove it and then the engine light came back on again. this time it was only the p0174. so i then both the upstream and downstream O2 sensors on bank 2, reset the code and it came back on again. I'm lost.
Ford F-150 - 1997-2003 :: 1999 - Check Engine Light Came On / Code P0171 / System Too Lean Bank 1
I just bought a 99 f150 and the check engine light came on with code p0171,system too lean bank 1. It runs and drives fine but has a strong smell of gas when I shut it off.
View 4 RepliesInfiniti - Qx4 :: 1997 - Battery Not Holding The Charge
I've had the alternator and starter tested twice,new battery. Its a 97infiniti qx4 and it won't hold a charge. The weird thing is, I have to wait day or two after I charge the new battery (which I replaced twice thinking it was the battery),then it will run for almost a day and then it just dies. And if someone tries to give me a jump, it will not charge and fire over. I have to get it towed back home and wait a day or two. (the wrecking companies are getting to know me very well). I've checked under the vehicle for any wires that are not suppose to be touching each other. Its my only car that I have at this time
View 5 Replies