Ford F-150 - 1997-2003 :: AC Compressor Is Missing
So today, I planned on switching the belt, idler pulley and tensioner since at least two of them are making noises. After taking all of the stuff off, belt, idler pulley and tensioner... and since I always compare parts I buy to parts that were in, making sure they are identical and I didn't order the wrong one. So first up I checked my tensioner and the position of them or angles are different, completely different.
So Google it to view a few diagrams and bang! it hits me... the one I took out from my F150 is for a non-AC... so back into the truck and I'm looking. Didn't have to go far when I realized that my AC compressor is missing!!!!
I keep looking around and I see that yes, I did have AC in it before I got it; because the guts are there but sliced! Great, so the job went from easy and easy I mean buy compressor and install; but now since the guts were cut, the PO sliced the thing out simply put.
1.) What are the bolt sizes that hold the compressor in place?
2.) Is there a wire connector on the compressor? or no?
Ford F-150 - 1997-2003 :: AC Compressor Not Cycling After Replaced
My AC compressor failed so I replaced it.
I put in 1 can of R134, and I don't see the compressor cycling.
How do I remove the connector to the accumulator so I can jump it and force the AC to run.
Ford F-150 - 1997-2003 :: AC Compressor Clutch Broke
I have a 01 f150 4.2L and a while ago the ac compressor clutch broke. I didn't catch it in time and the stress it caused on the belt broke the power steering pump pulley. So I replaced the steering pump and pulley and the compressor the accumulator/dryer and the office tube put the 134a back in and everything worked fine. three months later ac stopped working. I figured the condenser was bad so i replaced it. Charged it up still no cold ac. so i thought maybe the manifold that goes on the compressor was clogged so i replaced it. While I did that i said to myself well i should tear out the dash and replace the evap as well. so just about everything has been replaced on the ac system.
Aside from the cycle switch and the high side switch witch from my test both seem to be working. now here is the thing. the tube witch holds the office gets ice cold then goes to the evap but the suction line coming from the evap doesn't get cold and the ac blows warm air. this very problem is what convinced me that the evap was clogged and needed to be changed witch is why i undertook the task of tearing the dash out. in all it took 14 hours to do the whole job. now for the pressures that i get from the ac manifold low side goes 40 down to 20 ..... this is normal. high side is a little high. I charge it to 125 still no cold air. so i dump a little more 134 in. at 90 degrees high side pressure should be around 200ish i get it there still no cold air. I have just about replaced everything i can think of.
Ford F-150 - 1997-2003 :: 1999 - No A/C - Compressor Is Not Kicking On
4.6L engine.......Well my A/C isn't working I just found out. The compressor is not kicking on. I checked the charge with my gauges and it is good so I don't think the low limit switch tripped, but I don't have a manual or anything and was wondering which number relay and fuse goes to the A/C compressor.
I also need to know which fuse goes to the power mirrors as well. I downloaded a manual from the ford fleet site, but honestly I haven't gotten around to looking at it. Not home.
Ford F-150 - 1997-2003 :: 2001 - AC Compressor Completely Seized Up
I have a 2001 ford f150 with a 4.6 liter v8, my ac compressor is completely seized up, I can't afford to replace the ac right now. So I would like to just get a shorter serpentine belt to bypass the ac for now, need to get a measurement on the shorter belt for my engine? and the proper way to re route the belt without the ac?
View 7 RepliesFord F-150 - 1997-2003 :: Freon Leaking On The Back Of Compressor
I got a 2001 f150 leaking freon on the back of the compressor, can't afford to fix this summer. When I add freon should I get the freon with oil in to get oil in the system or just add regular can of freon, it took about 6 weeks before I need to add any.
View 7 RepliesFord F-150 - 1997-2003 :: Higher Idle When AC Compressor Kicks In
Sunday afternoon I noticed my 97 F-150 4.2 5-Speed manual had a higher idle. When the AC compressor kicks in, the motor revs up higher than normal for about 4 secs then comes down a little. If you barely press the accelerator, I mean just gently touch it, the motor revs up for 4 secs. Dont have a tach, but just idling in neutral, is about 150 rpms more, and when AC compressor kicks in, rpms jump about 300 rpms i assume. Maybe vacuum, IAC??? Plugs, wires, and normal tune up done about 2400 miles ago.
View 2 RepliesFord F-150 - 1997-2003 :: AC Compressor Clutch Engaging While Heater Is On
soo a friends 03 f-150 w/ the 4.6 has noticed the a/c compressor clutch engaging while heater is on. clutch engages for about 3 seconds or so and kicks back out consistently but only w/ the heater on. a/c dose function property when using a/c functions... Is this normal or does something need serviced???
View 3 RepliesFord F-150 - 1997-2003 :: Alternator Or AC Compressor Growling Noise?
I drive a '99 F150 4x4 5.4 EFI 196,000 miles. Recently I started noticing a growling noise that followed engine speed. I immediately thought alternator going out. So I pulled the belt off and it spins free and doesn't feel rough at all.
So I started it up and realized the noise got a lot louder when the ac clutch cycled. Now I'm thinking ac compressor. A short trip to my mechanic who didn't even really look at it very long and he said the compressor is about ready to seize up. I thought I might just put on an ac bypass pulley to get by for a while. Not really a sound decision in the middle of July, I'm thinking, but I'm poor and it beats having the compressor lock up, right?
Today, when I get off work and pop the hood with the ac off and the clutch not engaged the noise is worse than ever. I put a stethoscope (long screwdriver, I told you I was poor) on the alternator and it is making all of the noise. Turned the ac on again and it was really making noise now. So I applied the stetho-driver to the ac compressor and it is quiet as can be.
I am cautiously optimistic that the alternator is the sole culprit and that it only gets louder when the ac cycles because of the extra drag on the belt.
Does that seem like a logical explanation? Should I just try the alternator? I really don't want to destroy a perfectly functioning ac system only to find out that it was OK to begin with and I don't want to buy a $150 alternator for no reason either.
Ford F-150 - 1997-2003 :: Compressor Cycling Even When AC Or Defroster Is Not Turned On
My 2003 F150's compressor cycles even when the a/c or defroster is not turned on. It has the climate control type of temperature system. This doesn't seem normal.
View 2 RepliesCamry :: 2003 - Rough Take Off From Stop And Rattling / Grinding Sound When Accelerate
I recently acquired a 2003 Camry with 150,000mi. its has a rough take off from stop and when I accelerate it make a rattling/grinding sound. the sound disapates after around 30mph. Ive changed trannyfluid, oil change next is plugs and all that good stuff since I do not know when it was done last.
View 4 RepliesFord F-150 - 1997-2003 :: Locked Up AC Compressor Not Letting Motor To Turn Over
I have a 97 f150 5.4 4x4 a/c compressor and clutch. It won't let my motor turn over because the ac compressor is locked up bc the bearings are shot is there any way to by fix this until i get a new compressor and clutch....
View 6 RepliesFord F-150 - 1997-2003 :: A/C Compressor Not Engaging After Suspension Belt Replacement?
I have a F150, 97, 4.6L. I changed my Suspension belt, and now my A/C compressor is not engaging. This has happened before, and when I took it to the shop, they called me and said the A/C works just fine. They did not tell me why the A/C stopped engaging or what they did. I tried to locate a relay fuse, but I can't find it.
View 5 RepliesFord F-150 - 1997-2003 :: 2001 - Rattling Noise At 75 - 80 MPH?
At the above speeds my truck has a rattle/ticking. I think its the cats but I'm not sure. I checked all the obvious like the heat shields and stuff. The truck has 118000 miles on it and has been in So. Cal. its whole life.
View 6 RepliesFord F-150 - 1997-2003 :: Truck Started Rattling From The Exhaust
1997 F150... Truck has slowly started getting worse and worse performance. About 3 weeks ago the truck started rattling from the exhaust, Towing my trailer the other day, the truck had NO power, I thought it was the plugs, so I replaced them.
Now the rattle is worse (no lose heat shields). I am blowing the little tubes off the drivers side exhaust manifold, the ones that go to the DPFE sensor.
Did I mention, that the truck has no power, sluggish, now I am dumping hot exhaust fumes into the engine compartment. Still got the rattle underneath.
I think the cat is plugged up on the drivers side. (which probably explains all my symptoms)
Any other reason for the rattle literally coming from the drivers side cat and the little tubes being blown off?
Ford F-150 - 1997-2003 :: No Oil Pressure And Light On / Rattling Noise
I have a 2001 Ford F150 4.6 liter V8 Super Crew. I use Castrol full synthetic oil and Fram filters...changing oil about every 10,000-12,000 miles and change filter at half way point.
Here is my issue: I noticed a slight rattle on passenger side of engine a few weeks ago but engine ran well & I wasn't sure if it may be a pulley from AC compressor or something else. It wasn't bad at all...more like a ticking sound.
Yesterday I drove to work with no problem and when I got ready to leave 9 hrs later, I noticed rattling was getting worse. I ran about 2 or 3 miles down the road and my oil pressure flatlined and light came on. This is the 1st time it has ever happened. By this time the rattling sounded bad, almost like it broke something on both sides of engine around valve cover area.
I pulled over immediately and had truck towed to shop down the road from my house, When my mechanic started it up this morning it had oil pressure and rattling was not near as bad. I put a new oil filter on it & topped off oil. He could not get to it today so I drove it home today for the weekend and by the time I got home (3 miles) it did same thing...flatline, oil pressure light on and rattling with no power (very sluggish).
I did notice the oil pressure light came off & on and gauge went up and down a couple of times before I shut it down. What the problem is? Oil pump maybe? I just didn't think oil pumps usually fail.
Ford F-150 - 1997-2003 :: 2002 - No Oil Pressure And Rattling At Idle
I bought a 2002 f150 4x4 with a 4.6l. It has 250k miles on it. a couple days ago. It had no problems at all during the test drive or for the 150 miles home. Yesterday after it warmed up, the oil pressure dropped to 0 while at a red light and had a rattling noise. Not a knock but more of a rattle. I can't isolate where the rattle is coming from. Oil pressure comes back with just the slightest of increase Of RPM and seems To have plenty of power while driving. I had read to check the pressure manually but with the noise I sense there truly is a problem. the oil appears clear and is full. What I should be checking on this.
View 1 RepliesFord F-150 - 1997-2003 :: Compressor Still Engaged When Temp Control Switch Turned To Warm
1997 F150... What part of the control system tells the compressor to turn on and off? After not having air conditioning for a year or more I replaced the broken blend door.
When the a/c is turned on and the temp control switch is turned to cold, I get cold air. When I turn the temp control switch to warm, the air coming out of the vents is very warm. However when I do this I noticed that the compressor is still engaged. I think that at this point the compressor should disengage.
Honda - Accord :: 2003 - Rattling / Grinding Metallic Sound Coming Off Right Rear While Driving Slowly
Recently I started hearing a rattling/grinding metallic sound coming off the right rear while driving slowly. This sound is not reproduced when braking.At first it started while doing sharp right turns only, now its ever present while driving. I showed it to a mechanic he says rotors needs to be replaced. Is he right? 2003 Honda Accord V6....
View 7 Replies